期刊文献+

软锰矿浆催化氧化烟气中二氧化硫产酸过程研究 被引量:1

Study on Catalytic Oxidation of SO_2 in Flue Gas by Pyrolusite Slurry for Producing Sulfuric Acid
下载PDF
导出
摘要 采用软锰矿浆催化氧化烟气中的SO2,使其生成硫酸。考察了软锰矿浆液固比、软锰矿浆初始pH、气体流量、进口SO2浓度、气体中氧浓度和反应温度对硫酸浓度的影响。试验结果表明,软锰矿浆的液固比和气体中的氧浓度对产酸速率的影响最大。软锰矿浆与SO2反应生成硫酸的过程分为线性阶段和幂函数两个阶段,符合Pasiuk提出的反应动力学模型。 The catalytic oxidation of SO2 in flue gas by pyrolusite slurry for producing sulfuric acid was studied. The effects of liquid - solid ratio and initial pH of pyrolusite slurry, the flux of flue gas, the concentration of SO2 and that of O2 in inlet gas and the temperature of reaction on the concentration of sulfuric acid were examined. The results show that the liquid - solid ratio of pyrolusite slurry and the concentration of O2 in gas have the most significant effects on the yield of sulfuric acid. The reaction of SO2 with pyrolusite slurry can be divided into two steps,linear step and non- linear step,which agree well with the kinetic model suggested by Pasiuk.
出处 《化工环保》 CAS CSCD 北大核心 2004年第6期399-402,共4页 Environmental Protection of Chemical Industry
基金 国家自然科学基金资助项目(50278059)
关键词 软锰矿 催化氧化 二氧化硫 废气处理 pyrolusite, catalytic oxidation, sulfur dioxide, waste gas treatment
  • 引文网络
  • 相关文献

参考文献7

二级参考文献4

共引文献85

同被引文献13

  • 1Ukawa N, Okino S, Oshima M, et al. Effects of salts on limestone dissolution rate in wet limestone flue gas desulfulization. J Chem Eng Japan, 1993, 26 ( 1 ) : 112 - 113
  • 2Ukawa N, Takashina T, Oshima M, et al. Effects of salts on limestone dissolution rate in wet limestone flue gas desulfurization. Environ Progr, 1993, 12(4) : 294-299
  • 3Rochelle G T, King C J. The effect of additives on mass transfer in CaCO3 or CaO slurry scrubbing of SO2 from waste gases. Ind Eng Chem Fundam, 1977,16( 1 ) :67 - 75
  • 4Mobley J D, Cassidy M, Dickerman J. Organic acids can enhance wet limestone flue gas scrubbing. Power Eng,1986: 30(3): 32-35
  • 5Karatza D, Prisciandaro M, Lancia A, et al. Calcium bisulfite oxidation in the flue gas desulfurization process catalyzed by iron and manganese ions, Ind Eng Chem Res, 2004, 43(16) : 4 876 -4 882
  • 6Gunther K S, Rolf M, Matthaus S. Experimental investi-gation and modeling of catalytically supported sulfite/bisulfite oxidation with oxygen. Chem Eng Technol,2004, 27 (6) : 630 - 633
  • 7马双忱,赵毅,郑福玲,王淑勤.液相催化氧化脱除烟道气中SO_2和NO_x的研究[J].中国环境科学,2001,21(1):33-37. 被引量:40
  • 8孙文寿,吴忠标,李悦,谭天恩.旋流板塔钠强化石灰石湿式烟气脱硫研究[J].环境科学,2002,23(5):105-108. 被引量:19
  • 9孙文寿,吴忠标,谭天恩.硫酸镁对湿式石灰石烟气脱硫过程的影响研究[J].环境科学学报,2002,22(5):620-624. 被引量:14
  • 10孙文寿,吴忠标,谭天恩.烟气脱硫过程中添加剂对石灰石的促溶作用[J].中国环境科学,2002,22(4):305-308. 被引量:30

引证文献1

二级引证文献4

;
使用帮助 返回顶部