期刊文献+

煤气化废水处理过程瓶颈及改进措施分析 被引量:25

Analysis and debottlenecking retrofits for the coal-gasification wastewater treatment process
下载PDF
导出
摘要 对煤气化废水处理过程进行的全流程模拟结果进行了瓶颈分析,针对流程中存在的CO2残留量高导致的铵盐结晶和萃取脱酚效率低等问题,分析了各种可能的改进措施。结果表明,残留CO2主要是以离子态存在的,增加汽提塔的塔板数和调酸降低pH值都不能经济有效地降低CO2残留量,适当措施是提高汽提塔操作压力;通过增加现有脱酚萃取剂二异丙醚流量、萃取级数或降低pH值以使废水酚残留量降至400 mg/L以下都不具备工业可行性;而采用甲基异丁基甲酮(M IBK)作萃取剂可达到这一要求,并将废水中COD残留量降至4 000 mg/L左右,达到生化处理的进水要求。 The bottleneck of the coal gasification wastewater treatment process was analyzed based on simulation by using Aspen Plus. The feasibility of several renovations for the two main problems, i. e. , low phenols removal performance of extraction and crystal deposition induced by the crystallization of CO2 and NH3, were discussed. The results show that it is not economical to reduce the residual concentration of CO2 by increasing the stripper stages or lowering pH of wastewater, since the residual CO2 mainly exists as ions in gasification wastewater. However, the residual concentration of CO2 can be effectively reduced by increasing the operating pressure of the stripper. It also indicates that using diisopropyl ether as solvent, the residual concentration of phenols can not be reduced to less than 400 mg/L by increasing solvent flowrate and extractor stages or lowering pH of wastewater. Based on experimental results, methyl isobutyl ketone (MIBK) can be selected as extraction solvent to meet the requirement, and the performances of phenols removal and COD removal are greatly improved for the coalgasification wastewater treatment.
出处 《化学工程》 EI CAS CSCD 北大核心 2007年第8期57-60,共4页 Chemical Engineering(China)
基金 国家自然科学基金资助项目(20536020)
关键词 煤气化 废水 流程模拟 瓶颈分析 改进措施 coal-gasification wastewater flow simulation debottlenecking analysis renovation
  • 引文网络
  • 相关文献

参考文献7

二级参考文献47

  • 1杨义燕,杨天雪,戴猷元.磷酸三丁酯(TBP)对苯酚的络合萃取[J].环境化学,1995,14(5):410-415. 被引量:55
  • 2杨义燕,冯颖,戴猷元.三辛胺萃取多元酚的研究[J].应用化学,1995,12(1):55-58. 被引量:22
  • 3国家环保局.水和废水监测分析方法(第三版)[M].北京:中国环境科学出版社,1989.108,354.
  • 4郭天民.液-液萃取过程的模拟计算[J].化学工程,1982,10(5):1-11.
  • 5卢功姿.炼厂油品精制和碱渣处理现状、问题与发展[M].北京:中国石油化工总公司环境保护科技情报中心站,1992..
  • 6黄理纳.炼油厂碱渣废水综合处理技术研究.华南理工大学硕士学位论文[M].-,1996..
  • 7杨义燕.络合萃取法处理工业含酚废水.化学工程研究与进展——第二届全国青年化学工程学术研讨会论文集[M].华南理工大学出版社,1993.563.
  • 8杨义燕.磷酚三丁酯(TBP)对苯酚的络合萃取.化学工程研究与进展——第二届全国青年化学工程学术研讨会论文集[M].华南理工大学出版社,1993.206.
  • 9Dean J A(J.A.迪安编)Translated by SHANG Jiu-fang el a1.(尚久方等译).Lange's Handbook of Chemistry(兰氏化学手册)[M].Beijing(北京):Science Press(科学出版社),1991.5-16.
  • 10FU Yu(符钰).[D].Beijing(北京):Tsinghua University(清华大学),2001.

共引文献117

同被引文献227

引证文献25

二级引证文献214

;
使用帮助 返回顶部