期刊文献+

不锈钢冶炼电炉渣结构性质及浸出行为研究 被引量:7

Microstructural properties and leaching behavior of the stainless steel EAF slag
下载PDF
导出
摘要 研究电弧炉(EAF)渣的结构性质及渣中重金属离子的浸出行为。结果表明,EAF渣呈碱性,渣中Fe、Cr和Ni等金属元素主要以金属颗粒、(Cr,Al)2O3和(Fe,Mn,Mg)(Cr,Al)2O4晶体形式存在,具有较高的回收价值;电炉渣中可浸出重金属离子含量未超出国家标准,但存在Cr(III)再氧化为Cr(VI)的可能;Cr(VI)浸出量随浸出时间延长而增加,且Cr(VI)在蒸馏水中的浸出能力较冰醋酸中强。因此,EAF渣应尽量避免堆放或填埋在低pH场所,以防止其中重金属离子浸出。 tainless steel smelting generates large amounts of chromium-bearing waste slag such as electric arc furnace(EAF) slag.In this paper,the microstructural properties of the EAF slag as well as the leaching behavior of the heavy metals in the slag are investigated.The results show that the EAF slag is basic,iron,chromium and nickel in the slag mainly existing in the form of metal particles or crystalline phases of(Cr,Al)2O3 and(Fe,Mn,Mg)(Cr,Al)2O4,and therefore it has potential value for recovery.The amount of leachable heavy metals in the EAF slag does not exceed the national standard.However,the risk of the oxidation of Cr(III) to Cr(VI) still exists.The leaching experiments show that the leachability of the Cr(VI) in the distilled water is more than that in the 0.1mol/l acetic acid,and the Cr(VI) concentration in the leachate of EAF slag increases with the increase of leaching time.Furthermore,the EAF slag should not be stockpiled or landfilled at low pH sites to avoid the leaching of heavy metal ions.
出处 《武汉科技大学学报》 CAS 2009年第5期466-470,共5页 Journal of Wuhan University of Science and Technology
基金 武汉科技大学钢铁冶金及资源利用省部共建教育部重点实验室开放基金资助项目(FMRU2007K01)
关键词 EAF渣 CR(VI) 浸出 不锈钢 EAF slag Cr(VI) leaching stainless steel
  • 引文网络
  • 相关文献

参考文献16

  • 1Durinck D, Arnout S, Mertens G, et al. Borate distribution in stabilized stainless steel slag [J]. Journal of the American Ceramic Society, 2008, 91 (2) :548-554.
  • 2薛正良,胡会军,张友平,李正邦,周渝生.含碳铬矿团块高温还原特性研究[J].武汉钢铁学院学报,2004,27(1):1-3. 被引量:10
  • 3Dusing D C , Bishop P L , Keener T C. Effect of redox potential on leaching from stabilized/solidified waste materials[J]. Journal of the Air Waste Management Association, 1992, 42:56-62.
  • 4GB5085-72007,危险废物鉴别标准--浸出毒性鉴别[S].
  • 5白英彬,宣春生,王仲英,任希棠.从铬不锈钢废渣中提取和富集铬的研究[J].山西化工,1999,19(3):9-13. 被引量:4
  • 6王海燕.一钢公司不锈钢炉渣处理工艺设计[J].宝钢技术,2004(2):22-24. 被引量:6
  • 7Ye G, Burstorm E, Kuhn M, et al. Reduction of steel-making slags for recovery of valuable metals and oxide materials[J]. Scandinavian Journal of Metallurgy, 2003, 32:7- 14.
  • 8Lee H H, Jeong H J. Utilization of AOD slag produced in stainless steel works[J].RIST, 2004, 18 (4) :328- 333.
  • 9孙家瑛,王志新.不锈钢钢渣的污染特性[J].粉煤灰,2005,17(4):11-12. 被引量:10
  • 10Shen H, Forssberg E, Nordstrom U. Physicochemical and mineralogical properties of stainless steel slags oriented to metal recovery[J]. Resources, Conservation and Recycling, 2004, 40: 245-271.

二级参考文献22

共引文献42

同被引文献69

引证文献7

二级引证文献27

相关主题

;
使用帮助 返回顶部