期刊文献+

电炉渣铬浸出行为及资源化利用风险分析 被引量:7

STUDY ON LEACHING BEHAVIOR OF CHROMIUM IN EAF SLAG AND RISK ANALYSIS OF BENEFICIAL REUSE
原文传递
导出
摘要 不锈钢电炉渣含有剧毒的CaCrO4,铬的浸出行为研究,对电炉渣的处置及资源化利用过程中的风险评估具有十分重要的意义。对电炉渣中铬的浸出特征进行了分析,标准浸出程序结果表明,电炉渣Cr和Cr(Ⅵ)浸出量分别为4.68 mg/L和1.74 mg/L,高于HJ/T 301—2007规定的限值,不宜直接应用于建材领域;电炉渣铬浸出受浸提剂pH影响显著,Cr在中性环境下浸出量最少,酸性和碱性环境都有利于Cr的浸出;Cr(Ⅵ)的浸出量随pH值增大而增加。 CaCrO4 in EAF slag from stainless steel process is hypertoxic, as the importance to risk assessment of EAF slag during disposal and beneficial reuse, the leaching behavior of Cr is evaluated. Leaching characteristic of Cr in EAF slag is analysed,the results showed that the leaching amount of Cr and Cr ( Ⅵ ) is 4..68mg/L and 1.74mg/L in standard leaching process,this is higher than specified limits in HJ/T 301--2007, so EAF slag should not be directly applied to the field of building materials. The leaching behavior of EAF slag is affected by the pH value of extraetant significantly,leaching amount of Cr in neutral condition is the lowest, and promoted in acid and alkaline conditions,leaching amount of Cr( Ⅵ ) is advanced with the increase of pH value.
出处 《环境工程》 CAS CSCD 北大核心 2012年第4期93-95,共3页 Environmental Engineering
基金 国家高技术研究发展计划(2009AA064003)
关键词 电炉渣 资源化利用 六价铬 浸出 EAF slag beneficial reuse chromium Cr( Ⅵ ) leaching
  • 引文网络
  • 相关文献

参考文献6

二级参考文献51

  • 1席北斗,王琪,张晓萱,姜永海.不同浸出毒性鉴别方法对垃圾焚烧飞灰浸出毒性鉴别的适宜性[J].环境科学研究,2005,18(z1):17-22. 被引量:21
  • 2王明玉,李辽沙,张力,张林楠,隋智通,涂赣峰.用鼓风炉渣消除铬渣毒性的研究[J].环境工程,2005,23(4):65-66. 被引量:1
  • 3孙家瑛,王志新.不锈钢钢渣的污染特性[J].粉煤灰,2005,17(4):11-12. 被引量:10
  • 4石玉敏,都兴红,隋智通.碳高温还原解毒铬渣中CaCrO_4的反应热力学研究[J].环境污染与防治,2007,29(6):451-454. 被引量:8
  • 5Durinck D, Arnout S, Mertens G, et al. Borate distribution in stabilized stainless steel slag [J]. Journal of the American Ceramic Society, 2008, 91 (2) :548-554.
  • 6Dusing D C , Bishop P L , Keener T C. Effect of redox potential on leaching from stabilized/solidified waste materials[J]. Journal of the Air Waste Management Association, 1992, 42:56-62.
  • 7GB5085-72007,危险废物鉴别标准--浸出毒性鉴别[S].
  • 8Ye G, Burstorm E, Kuhn M, et al. Reduction of steel-making slags for recovery of valuable metals and oxide materials[J]. Scandinavian Journal of Metallurgy, 2003, 32:7- 14.
  • 9Lee H H, Jeong H J. Utilization of AOD slag produced in stainless steel works[J].RIST, 2004, 18 (4) :328- 333.
  • 10Shen H, Forssberg E, Nordstrom U. Physicochemical and mineralogical properties of stainless steel slags oriented to metal recovery[J]. Resources, Conservation and Recycling, 2004, 40: 245-271.

共引文献63

同被引文献75

  • 1尹贞,张钧超,廖书林,马强,王庆国,张进锋.铬污染场地修复技术研究及应用[J].环境工程,2015,33(1):159-162. 被引量:23
  • 2蓝磊,童张法,李仲民,魏光涛,韦藤幼.改性膨润土对废水中六价铬的吸附过程研究[J].环境污染与防治,2005,27(5):352-354. 被引量:51
  • 3肖琪仲.钢渣的膨胀破坏与抑制[J].硅酸盐学报,1996,24(6):635-640. 被引量:81
  • 4张瑞华,孙红文.电动力和铁PRB技术联合修复铬(Ⅵ)污染土壤[J].环境科学,2007,28(5):1131-1136. 被引量:37
  • 5中国土壤学会.土壤农业化学分析方法[M].北京:中国农业科技出版社.1999.
  • 6唐明述 袁美栖 韩苏芬 等.钢渣中MgO、FeO、MnO的结晶状态与钢渣的体积安定性.硅酸盐学报,1979,7(1):35-45.
  • 7Tessier A;Campbell P G C;Bisson M.Sequential extraction procedure for the speciation of particulate trace metals,1979(07).
  • 8Yoshikawa N, Mashiko K I, Sasaki Y. Microwave Carbo-Thermal Reduction for Recycling of Cr from Cr-Containing Steel Making Wastes[J]. ISI_] International. 2008,48(5) :690.
  • 9Manceau A, Manceau A, Boisset M C, et al. Sorption and Speciation of Heavy Metals on Hydrous Fe and Mn Oxides. From Microscopic to Macroscopic [J]. Applied Clay Science 1992, 7(1) :201.
  • 10国家环境保护总局.HJ/T301-2007铬渣污染治理环境保护技术规范[S].北京:中国环境科学出版社,2007.

引证文献7

二级引证文献64

相关主题

;
使用帮助 返回顶部