期刊文献+

1,3-二元脂肪醇萃取硼酸的平衡特性 被引量:8

Equilibrium behavior of boric acid extracted by aliphatic 1,3-diols
下载PDF
导出
摘要 基于1,3-二元脂肪醇的溶剂萃取法在盐湖卤水提硼方面有广阔的应用前景,系统研究了两种1,3-二元脂肪醇萃取剂:2-乙基-1,3-己二醇(EHD)和2-丁基-2-乙基-1,3-丙二醇(BEPD)对硼酸的萃取性能,分别考察了萃取剂浓度、原料液pH、硼酸浓度、氯化镁浓度以及温度等因素对硼酸分配系数的影响。实验结果表明,温度为303.15K,原料液中硼酸浓度为0.0185mol.L-1,EHD和BEPD甲苯溶液中浓度均为0.4mol.L-1时,硼酸的分配系数分别达到9.43和8.25。高浓度的萃取剂和较低的原料液pH条件对提高分配系数有利;分配系数随原料中硼酸浓度和反应温度的升高而降低,1,3-二元脂肪醇萃取硼酸的过程为放热过程;氯化镁存在下的盐析效应也有利于硼酸的萃取分配。 Solvent extraction based on aliphatic 1,3-diols is a promising technique for the recovery of boric acid from salt lake brine.In this work,two diols,2-ethyl-1,3-hexanediol(EHD)and 2-butyl-2-ethyl1,3-propanediol(BEPD),were selected as extractants and toluene was used as diluent.The effects of extractant concentration,pH of brine,initial boric acid concentration,magnesium chloride concentration,and temperature on the distribution coefficients of boric acid were systematically investigated.Distribution coefficients of boric acid up to 9.43and 8.25were obtained from the boric acid aqueous solutions with the initial concentration of 0.0185 mol.L-1 when using toluene containing 0.4 mol.L-1 EHD and BEPD,respectively,as organic phases at 303.15K.Higher extractant concentration or lower pH is favorable to the extraction.However,the distribution coefficients decrease gradually with the increase of boric acid concentration and temperature.The extraction of boric acid with aliphatic 1,3diols is an exothermic process.The salting-out effect of magnesium chloride enhances the extraction performance.
出处 《化工学报》 EI CAS CSCD 北大核心 2012年第11期3546-3552,共7页 CIESC Journal
基金 中央高校基本科研业务费专项资金项目(2011FZA4023) 国家自然科学基金重点项目(20936005)~~
关键词 硼酸 盐湖卤水 溶剂萃取 1 3-二元脂肪醇 2-乙基-1 3-己二醇 2-丁基-2-乙基-1 3-丙二醇 boric acid salt lake brine solvent extraction aliphatic 1 3-diol 2-ethyl-1 3-hexanediol 2-butyl-2-ethyl-1 3-propanediol
  • 引文网络
  • 相关文献

参考文献26

  • 1李树生,李洪.盐湖卤水提取工业硼酸产业化新技术研究[J].盐业与化工,2008,37(4):1-3. 被引量:11
  • 2Xu Y,Jiang J Q. Technologies for boron removal [J].Industrial Engineering Chemistry Research,2008,47(1): 16-24.
  • 3Remy P, Muhr H,Plasari E,Ouerdiane I. Removal ofboron from wastewater by precipitation of a sparinglysoluble salt [J].Environmental Progress , 2004,24 (1) ?105-110.
  • 4Itakura T, Sasai R,Itoh H. Precipitation recovery of boronfrom wastewater by hydrothermal mineralization [J].Water Research , 2005,39: 2543-2548.
  • 5Miyazaki Y,Matsuo H, Fujimori T,Takemura H,Matsuoka S, Okobira T, Uezu K, Yoshimura K.Interaction of boric acid with salicyl derivatives as an anchorgroup of boron-selective adsorbents [J].Polyhedron, 2008,27 (13): 2785-2790.
  • 6Arias MFC, Bru L V, Rico D P, Galvan P V.Comparison of ion exchange resins used in reduction ofboron in desalinated water for human consumption [J].Desalination, 2011, 278 (1/2/3) : 244-249.
  • 7Wei Y T, Zheng Y M,Chen J P. Design and fabrication ofan innovative and environmental friendly adsorbent for boronremoval [J].Water Research, 2011,45 (6) : 2297-305.
  • 8Tsuboi T,Kunugita E,Komasawa I. Recovery andpurification of boron from coal fly ash [J].Journal ofChemical Engineering of Japan , 1990,23: 480.
  • 9Kabay N,Guler E, Bryjak M. Boron in seawater andmethods for its separation一a review [J].Desalination.2010, 261: 212-217.
  • 10Ayers P,Dudeney A W L, Kahraman F. Solvent extractionof boron with 2-ethyl-1,3-hexanediol and 2-chloro-4-(1,1,3,3-tetramethylbutyl)-6-methylol-phenol [ J ].Journalof Inorganic and Nuclear Chemistry,1981,43: 2097-2100.

二级参考文献35

  • 1余静,刘代俊,杜怀明,徐程浩,刘长洪,刘明.反胶团萃取磷酸溶液中的镁[J].高校化学工程学报,2008,22(3):401-406. 被引量:22
  • 2钟本和,陈亮,李军,龚海燕.溶剂萃取法净化湿法磷酸的新进展[J].化工进展,2005,24(6):596-602. 被引量:49
  • 3韩井伟,李法强,王相文,闫春燕,伊文涛.从液体矿中提取硼的研究进展[J].盐湖研究,2007,15(2):57-61. 被引量:15
  • 4Dean J A(J.A.迪安编)Translated by SHANG Jiu-fang el a1.(尚久方等译).Lange's Handbook of Chemistry(兰氏化学手册)[M].Beijing(北京):Science Press(科学出版社),1991.5-16.
  • 5FU Yu(符钰).[D].Beijing(北京):Tsinghua University(清华大学),2001.
  • 6Takeshita M, Shinkai S. Recent topics on functionalization and recognition ability of calixarenes: the third host molecule [J]. Bull Chem Soc Jan, 1995, 68(4): 1079-1088.
  • 7Kondo Y, Yamamoto T, Manabe O et al. Uranium adorbent [P]. ]P: 62, 210055, 1987-06-19.
  • 8Kondo Y, Yamamoto T, Manabe O et al. Adorbent of uranium [P], JP: 63, 197544, 1988-09-08.
  • 9Izatt S R ,Hawkins R T, Christensen J Jet al. Cation transport from multiple alkali cation mixtures using a liquid membrane system containing a series of calixarene carriers [J]. Am Chem Soc, 1985, 107(1): 63 -66.
  • 10Narjes Toumi, Fabienne Kajo, Didier Fournier et al. A useful approach towards solid-liquid extraction of metal cations with unsupportedcalixarenes [J]. Materials Science and Engineering, 2008, 28(5): 645-652.

共引文献61

同被引文献120

引证文献8

二级引证文献35

;
使用帮助 返回顶部