期刊文献+

含铒铝镁合金TIG焊接焊缝微观组织特征(英文) 被引量:3

Microstructure Characteristics of TIG Welded Al-Mg Alloy with Small Amount Er Addition
原文传递
导出
摘要 对Al-Mg-Mn-Zr-Er合金进行TIG焊接,研究了母材和焊缝的微观组织特征,重点研究了Er在焊缝中的存在形式及其对焊缝微观组织的影响。结果表明:Er在焊缝中以Al3Er相的形式存在,其中初生Al3Er具有细化晶粒的作用,次生Al3Er具有弥散强化的作用;在熔合线附近出现由细小等轴晶组成的细晶区,该区域的出现与Er元素的添加有关。 Samples of Al-Mg-Mn-Zr-Er alloys were welded by the method of TIG welding.Microstructures of base metal and welded zones were analyzed by optical microscopy(OM),electron probe micro-analyzer(EPMA) and transmission electron microscopy(TEM).Particular emphasis was laid on the existence form of Er and its effect on the microstructure and the phase composition of the fusion zone.Results reveal that the trace rare earth element Er mainly exists in the form of primary and secondary Al3 Er phase,which play significant roles of refining and strengthening the fusion zone.A characteristic Equiaxed Zone(EQZ) is obtained beside the fusion boundary between the partially melted zone and the fusion zone(FZ) due to the addition of Er.
机构地区 北京工业大学
出处 《稀有金属材料与工程》 SCIE EI CAS CSCD 北大核心 2012年第10期1713-1716,共4页 Rare Metal Materials and Engineering
基金 the National High Technology Research and Development Program(2009AA03Z516)
关键词 铝镁合金 TIG焊 微观组织 erbium(Er) Al-Mg alloy TIG welding microstructure
  • 引文网络
  • 相关文献

参考文献13

  • 1Blake N, Hopkins M A. JMater Sci[J]. 1985, 20: 2861.
  • 2Sawtell R R, Jensen C L. Metall Trans A [J]. 1990, 21 A: 421.
  • 3Parker B A, Zhou Z F, Nolle P. JMater Sci[J].1995, 30:452.
  • 4Toropova L S, Eskin D G, Kharakterova M Let al. AdvancedAluminum Alloys Containing Scandium: Structure and Properties[M]. Nethlands: Gordon and Breach Science Publishers, 1998.
  • 5Davydov V G. Rostova T D, Zakharov V V et al. Mater Sci EngA[J]. 2000, 280:30.
  • 6Filatov Yu A, Yelagin V I, Zakahrov V V. Mater Sci EngA[J]. 2000, 280:97.
  • 7Lin Shuangping, Nie Zuoren, Huang Hui et al. Mater Des[J]. 2010, 31:1607.
  • 8Meng Gang, Li Bolong, Li Hongmei et al. Mater Sci EngA[J]. 2009, 517:131.
  • 9Gao Xudong, Xing Zebing, Ji Xiaolan et aL Heat Treat Met[J]. 2007, 8:40.
  • 10Xu Guofu, Mou Shenzhou, Yang Junjun et al. Nonferr Metal Soc[J]. 2006, 16:598.

同被引文献17

引证文献3

二级引证文献14

;
使用帮助 返回顶部