期刊文献+

褐煤微波干燥提质生产线的多级功率控制系统研究 被引量:2

Research on multi-stage power control system of lignite microwave drying production line
下载PDF
导出
摘要 与传统的蒸发干燥工艺相比,微波干燥技术采用微波辐射的方式,具有内外同时加热、加热速度快等特点,使得褐煤干燥提质的过程耗能小、效率高、无污染。但是,在微波干燥褐煤的过程中易出现热过度和热失控的情况,会导致褐煤自燃,甚至爆炸,给生产线带来极大损失。为了实现微波干燥过程中褐煤温度的最佳控制,提出了一种基于褐煤含水率的目标温度范围动态调节方法。在该方法的基础上结合微波干燥腔的建模仿真及现场取样数据的分析,构建了一套生产线中多级微波腔的微波功率主动协调控制系统,以温度和反射系数作为输入参数,通过PID控制模型来动态调节微波源的输出功率。将该系统安装于南京三乐公司在内蒙古海拉尔建立的微波干燥褐煤生产线上进行测试,结果表明,该系统能够对各级微波腔内褐煤的温度范围精准控制,保证生产的安全性,并且将褐煤的含水率控制在10%以内。 Compared with conventional evaporative drying processes,microwave drying technology realizes simultaneous and rapid heating of both the inside and outside through microwave radiation,and has the advantages of low energy consumption,high efficiency,and no pollution in the lignite drying and upgrading process.However,overheating and thermal runaway tend to occur during microwave drying of lignite,which may cause spontaneous combustion of lignite or even explosion,thus resulting in great loss to the production line.In order to realize optimal control of lignite temperature during microwave drying,a lignite moisture content based method for dynamic adjustment of target temperature range was proposed in this paper.Based on this method,an active coordinated microwave power control system for multistage microwave drying chambers on the production line was established through modeling and simulation of the microwave drying chambers and analysis of on-site sampling data.Taking temperature and reflection coefficient as its input parameters,the system can dynamically adjust the output power of microwave sources through a PID control model.The system was installed and tested on the microwave lignite drying production line built by Nanjing Sanle Corporation in Hailar,Inner Mongolia.The results show that the system can accurately control the temperature range of lignite at each stage of microwave chambers,guarantee production safety,and keep the lignite moisture content under 10%.
作者 周新志 邵伦 崔岢 杨阳 周余 张若彬 ZHOU Xinzhi;SHAO Lun;CUI Ke;YANG Yang;ZHOU Yu;ZHANG Ruobin(College of Electronic and Information Engineering,Sichuan University,Chengdu 610065,Sichuan,China)
出处 《化工学报》 EI CAS CSCD 北大核心 2018年第A02期274-282,共9页 CIESC Journal
基金 国家重点基础研究发展计划项目(2013CB328903)~~
关键词 微波 干燥 褐煤 功率控制 多级控制 燃料 安全 microwave drying lignite power control coordination control fuel safety
  • 引文网络
  • 相关文献

参考文献20

二级参考文献175

共引文献144

同被引文献16

引证文献2

二级引证文献4

;
使用帮助 返回顶部