期刊文献+

双频干涉共焦台阶高度测量系统 被引量:6

System to Measure Step Hight by Combining Dual-frequency Interferometry and Confocal Microscopy
原文传递
导出
摘要 提出了一种以低频差横向塞曼双频激光器作光源的外差干涉共焦显微测量系统 ,该系统通过共焦显微的光强测量进行粗定位 ,其轴向台阶高度测量范围在 5 μm以上。同时采用相位测量技术 ,实现了对半波长的 36 0 0细分 ,从而使测量分辨率达到 0 1nm。由此同时满足了高测量精度和较大测量范围的要求。实验结果表明系统在没有恒温的普通实验室条件下 1h内的漂移不超过 15nm ,与差动纳米双频干涉仪的比对结果线性系数在 0 9999以上 ,非线性误差约 10nm。 A novel measuring system is proposed in this paper, which is based on transverse Zeeman laser with low beat frequency and combined heterodyne interferometry and confocal microscopy. The range of height measurement reaches over 5 μm in term of intensity derived from the confocal system. Meanwhile the phase measurement technology is adopted to divide half wavelength by a factor of 3600, hence a resolution of 0.1nm can be attained. Accordingly the requirements of both high measurement resolution and relatively large measurement range are met simultaneously. The experimental results show that in ordinary laboratory condition, without constant temperature, the shift of phase measurement is about 15 nm. Calibration with differential dual-frequency interferometer gives the linealy correlation coefficient of 0.9999 and nonlinearity of about 10 nm.
出处 《中国激光》 EI CAS CSCD 北大核心 2003年第11期1015-1018,共4页 Chinese Journal of Lasers
基金 国家自然科学专项基金 (No .5 0 0 2 70 0 2 ) 清华大学博士生创新基金联合资助项目
关键词 测绘仪器 相位测量 外差干涉 共焦显微术 measurement instruments phase measurement heterodyne interferometry confocal microscopy
  • 引文网络
  • 相关文献

参考文献1

二级参考文献2

  • 1Yang Lisong,光学学报,1999年,19卷,7期,962页
  • 2Min Gu,Principles of Three-dimensional Imaging in Confocal Microscopes,1996年,175页

共引文献9

同被引文献50

引证文献6

二级引证文献12

;
使用帮助 返回顶部