期刊文献+

呋喃树脂对煤沥青流变性能的影响 被引量:12

The effect of furan resin on the rheological properties of coal tar pitch
下载PDF
导出
摘要 采用旋转黏度计测定了含有不同比例呋喃树脂的煤沥青的表观黏度.考察了呋喃树脂对煤沥青表观黏度、残炭率及软化点的影响.同时,采用扫描电镜(SEM)研究了添加呋喃树脂后煤沥青的表面形貌.结果表明,添加质量分数为3.6%~9.0%的呋喃树脂使煤沥青在达到相同黏度值时温度下降5℃~15℃,而残炭率不下降;由于呋喃树脂使煤沥青分子隔开从而改善了煤沥青的流动性能;另外加入适量的呋喃树脂可降低煤沥青的黏流活化能,有利于煤沥青在较宽温度范围内进行工艺操作. The effect of furan resin on the rheological properties of coal tar pitches was studied. The apparent viscosity of the parent coal tar pitch and coal tar pitches blended with furan resin were determined using it rotating coaxial -cylinder viscometer. The properties of different coal tar pitches, such is apparent viscosity softening point and carbon yield, were also investigated. Moreover, the coal tar pitches were observed with a scanning electron microscope ( SEM). It was found that the softening point of coal tar pitch vlended with 3.6 - 9.0 w/% furan resin is 5 - 15 degrees C lower than that of the parent coal tar pitch while the carbon yield remain unchanged. SEM observation reveals that the molecules of the coal tar pitch are segregated by furan resin, causing better flow properties. As a result, the viscous flow activation energy ( E-a) of the coal tat, pitches is reduced which is beneficial to the process for producing carbon materials over a wide temperature range.
出处 《新型炭材料》 SCIE EI CAS CSCD 北大核心 2005年第1期67-70,共4页 New Carbon Materials
基金 国防十五预研项目资助(00KZKYB000000253)~~
关键词 呋喃树脂 表观黏度 结焦值 流变性能 煤沥青 多核缩合芳烃 分子量 温度 coal tar pitch furan resin apparent viscosity carbon yield rheological properties
  • 引文网络
  • 相关文献

参考文献9

二级参考文献20

  • 1李铁虎,杨峥,郑修麟.用改质沥青制备C/C复合材料的研究[J].材料工程,1992,20(S1):17-18. 被引量:4
  • 2郭正,赵稼祥.碳/碳复合材料的研究与发展[J].宇航材料工艺,1995,25(5):1-7. 被引量:54
  • 3宋进仁 吕春祥.浸渍剂沥青的研究.第三届全国新型炭材料学术研讨会议论文集[M].,1997.65.
  • 4智林杰 宋进仁.工艺条件对热处理改性沥青组成和性能的影响.第四届全国新型炭材料学术研讨会议论文集[M].,1999.619.
  • 5薜改凤 许斌 等.煤焦油净化工艺条件的研究[J].煤化工,1997,(4):46-48.
  • 6智林杰,第四届全国新型炭材料学术研讨会议论文集,1999年,619页
  • 7智林杰,新型碳材料,1999年,14卷,3期,14页
  • 8宋进仁,第三届全国新型炭材料学术研讨会议论文集,1997年,65页
  • 9郭全贵.炭/炭复合材料[J].新型炭材料,1997,12(2):54-55. 被引量:10
  • 10刘瑞周,许斌,薛改凤,陈鹏.原生QI结构和性质的研究[J].炭素技术,1997,16(5):22-25. 被引量:21

共引文献59

同被引文献159

引证文献12

二级引证文献70

;
使用帮助 返回顶部