期刊文献+

AEO_9/醇/烷/水系反相微乳液陶瓷墨水制备与性能研究 被引量:22

Preparation and Properties of AEOg/Alcohol/Alkane/Water Reverse Microemulsion Ceramic Inks
下载PDF
导出
摘要 AEO_9/醇/烷/水系反相微乳液具有相当优异的溶水性能,选择该系用于陶瓷墨水制备,就醇的种类和用量对反相微乳液区的影响进行了研究,划定了该区在拟三元相图中的位置,确定了体系最佳溶水量条件.以ZrOCl_2·8H_2O和NH_3·H_2O溶液分别替代优化体系中的水,获得2个反相微乳液,再将它们混合,通过反应制得陶瓷墨水,测定分析了陶瓷墨水理化性能变化规律,针对喷射打印成型硬件要求,对二者性能匹配性进行重点考察。 The AEO9/alcohol/alkane/water system, which has excellent water-dissolving characteristics, was chosen for the preparation of ceramic inks. In this paper, different kinds and amounts of alcohols were used to investigate the effects on microemulsion region in the quasi-ternary phase diagram of the system. The microemulsion region was determined and the conditions for the maximum water-dissolving were given. Water for the optimized system of AEO9/alcohol/alkane/water was replaced by zirconium oxychloride solution and ammonia solution respectively and two clear reverse microemulsions were obtained. Then the ceramic inks were readily prepared by reaction after mixing them homogeneously. The properties of the inks, such as viscosity, surface tension, conductivity, stability etc. were systematically determined and analyzed. The match between ink and printer was discussed based on the demands of ink-jet printer available.
出处 《无机材料学报》 SCIE EI CAS CSCD 北大核心 2003年第3期645-652,共8页 Journal of Inorganic Materials
基金 国家自然科学基金(59972023)
关键词 陶瓷墨水 反相微乳液 拟三元相图 理化性能 microemulsion ceramic ink quasi-ternary phase diagram physicochemical property
  • 引文网络
  • 相关文献

参考文献5

二级参考文献37

共引文献63

同被引文献223

引证文献22

二级引证文献75

相关主题

;
使用帮助 返回顶部