期刊文献+
任意字段
题名或关键词
题名
关键词
文摘
作者
第一作者
机构
刊名
分类号
参考文献
作者简介
基金资助
栏目信息

Nd_(12.3)Fe_(80.7)NbB_6纳米晶永磁合金的磁性能与微观结构

Microstructure and magnetic properties of an Nd_(12.3)Fe_(80.7)NbB_6 nanocrystal permanent magnet
下载PDF
导出
摘要 研究了添加Nb元素对Nd2Fe14B单相纳米晶永磁合金微观结构与磁性能的影响.结果表明:添加Nb可以在甩带过程中促进非晶的形成并稳定非晶相;在退火过程中,加入Nb后形成的析出相可以抑制晶粒长大,使晶粒细化且分布均匀,进而大幅度提高了材料的综合磁性能.名义成分为Nd12.3Fe80.7NbB6.0的非晶薄带在550℃退火处理10min后,可得到最佳磁性能:剩磁0.90T,矫顽力912.64kA.m-1,最大磁能积126.24kJ.m-3;随着退火温度的进一步提高,综合性能有所下降. The microalloying effect of niobium on the microstructure and magnetic properties of an Nd2Fe14B nanocrystal permanent magnet was investigated. The results show that niobium addition promotes the formation of amorphous phase and stabilizes the amorphous phase. During the annealing, precipitate phase after niobium adding restrains the growth of grains, uniforms the size of grains, and enhances the magnetic properties of the alloy. The optimum magnetic properties of Jr = 0. 899 8 T, Hci = 912.64 kA· m^-1 and （BH） m = 126.24 kJ·m^-3 were obtained by annealing a melt-spun Nd12.3Fe80.7NbB6.0 amorphous ribbon at 550℃ for 10 min. But the magnetic properties decreased when the annealing temperature further increased.
作者 隋延力 陈治安 包小倩 张茂才 周寿增
机构地区 北京科技大学新金属材料国家重点实验室 北京科技大学粉末冶金研究所
出处 《北京科技大学学报》 EI CAS CSCD 北大核心 2007年第7期708-711,共4页 Journal of University of Science and Technology Beijing
关键词 ND2FE14B 磁性能 纳米晶 非晶相 Nd2Fe14B magnetic properties nanocrystals amorphous phase
分类号 TG132.2 [一般工业技术—材料科学与工程]
  • 相关文献

参考文献9

  • 1张敏刚,金志浩,郭东城.非晶晶化法制备纳米晶双相永磁合金的磁性[J].西安交通大学学报,2000,34(10):53-56. 被引量：11
  • 2王晨,张文勇,严密.铌和锆对(Nd,Pr)_2Fe_(14)B/α-Fe快淬合金晶化和磁性能的影响[J].中国稀土学报,2005,23(3):307-311. 被引量：5
  • 3Chang H W,Chiu C H,Chang W C.High performance PrFeB-type nanocomposite ribbon with high B concentration∥2004年中国磁性会议.西安,2004:133
  • 4张然,刘颖,李军,马毅龙,高升吉,涂铭旌.添加Nb在快淬NdFeB永磁体中的作用研究[J].物理学报,2007,56(1):518-521. 被引量：7
  • 5Chen Z,Zhang Y,Ding Y Q,et al.Studies on magnetic properties and microstructure of melt-spun nanocomposite R8(Fe,Co,Nb)86B6 (R=Nd,Pr) magnets.J Magn Magn Mater,1999,195:420
  • 6Zhang H,Zhang S,Shen B,et al.The effect of Cu,Nb and Zr additions on the permanent magnetic properties of melt-spun Sm-Fe-Si-C ribbons.J Magn Magn Mater,1998(187):247
  • 7Konno T J,Uehara M,Hirosawa S,et al.Effect of Nb on the crystallization behavior and magnetic properties of melt-spun Fe-rich Fe-Nd-B ribbons.J Alloys Compd,1998 (268):278
  • 8张敏刚,周俊琪,郭东城,金志浩.NdFeB系纳米复合永磁合金[J].材料导报,1998,12(1):16-21. 被引量：9
  • 9Bai F,Jiang Z,Chen X,et al.The combined effect of Ga,Nb,Zr,Hf,Pr on the magnetic properties and microstructure of (Nd,Pr)9(Fe,Ga,Nb,Zr,Hf)86.5B4.5 nanocompostie ribbons.J Alloys Compd,2002 343:60

二级参考文献26

  • 1包小倩,周寿增,王佐诚,乔祎,张茂才,刘湘华.制备工艺对Pr_2Fe_(14)B/α-Fe纳米复合永磁材料组织与磁性的影响[J].中国稀土学报,2003,21(1):27-30. 被引量：15
  • 2Ding J，J Magn Mater，1993年，124期，1页
  • 3Yin J H, Zhou Y X, Tang S L, et al.Effect of Mo concentration on the phase composition and magnetic properties of Nd8(Fe,Mo)86B6 nanocomposite magnets [J]. Journal of Applied Physics, 1999, 85(10): 7336.
  • 4Panagiotopoulos I, Withanawasam L, Hadjipanayis G C.Exchange spring behavior in nanocomposite hard magnetic materials [J]. Journal of Magnetism and Magnetic Materials, 1996, 152: 353.
  • 5Buschow K H J.Supermagnets, Hard Magnetic Materials [M]. Dordrecht: Kluwer Academic Publishers, 1991. 553.
  • 6Withanawasam L, Murphy A S, Hadjipanayis G C, et al.Nanocomposite R2Fe14B/Fe exchange coupled magnets [J]. Journal of Applied Physics, 1994, 76: 7065.
  • 7Chen Z, Smith B R, Brown D N, et al.Effect of Zr substitution for rare earth on microstructure and magnetic properties of melt-spun (Nd0.75Pr0.25)12.5-xZrxFe82B5.5 (x=0～3) ribbons [J]. Journal of Applied Physics, 2002, 91(10): 8168.
  • 8Schrefl T, Fischer R, Fidler J, et al.Two- and three-dimensional calculation of remanence enhancement of rare-earth based composite magnets [J]. Journal of Applied Physics, 1994, 76(10): 7053.
  • 9Fischer R, Schrefl T, Kronmüller H, et al.Grain-size dependence of remanence and coercive field of isotropic nanocrystalline composite permanent mangets [J]. Journal of Magnetism and Magnetic Materials, 1996, 153: 35.
  • 10Akira Arai, Hiroshi Kato, Koji Akioka.High-energy isotropic resin bonded magnets produced from (Nd,Dy)-(Fe,Co)-B nanocomposite alloys [J]. IEEE Transactions on Magnetics, 2001, 37(4): 2555.

共引文献28

北京科技大学学报
2007年 第7期

相关作者

内容加载中请稍等...

相关机构

内容加载中请稍等...

相关主题

内容加载中请稍等...

浏览历史

内容加载中请稍等...
;
使用帮助 返回顶部