无位置传感器无刷直流电动机无反转起动及其平滑切换被引量：19

Anti-Reverse Rotation Startup and Smoothly Switching of Sensorless Brushless DC Motor

下载PDF

导出

摘要提出了一种隐极式无刷直流电动机的无反转起动及其平滑切换新方法。根据电动机定子铁心饱和效应,采用短时脉冲检测方法实现转子定位与加速。针对"三段式"起动方法切换的缺点,提出了在一定转速时关闭所有开关器件,利用电动机端电压波形与导通相之间的对应关系实现平滑切换的方法。反电动势过零点检测选在PWM调制信号开通状态结束时刻,在对端电压进行采样后由软件算法确定真实过零点。样机试验结果验证了本文提出方法的可行性和有效性。 In this paper, a novel anti-reverse-rotation startup and smoothly switching method for a non-salient pole brushless DC motor （BLDCM） is presented. Using short pulse sensing method based on the saturation effect of the stator iron, the rotor can be located and accelerated. The drawbacks of the ＂3-stage startup method＂ are analyzed, and the motor is switched smoothly according to the relationship between the terminal voltage waveform and commutation phases, when all the power devices are turned off. The back EMF zero-crossing point detection is conducted at the end of PWM on-state and the true zero-crossing point is extracted from the proposed algorithm. The experimental results verified the feasibility and validity of the suggested method.

作者张智尧林明耀周谷庆

机构地区东南大学电气工程学院

出处《电工技术学报》 EI CSCD 北大核心 2009年第11期26-32,共7页 Transactions of China Electrotechnical Society

关键词无刷直流电动机无位置传感器控制无反转起动反电动势法平滑切换 Brushless DC motor, sensorless control, starting without reverse rotation, back EMF method, switch smoothly

分类号 TM361 [电气工程—电机]

引文网络
相关文献

参考文献13

1林明耀,李强,杨沛骐.无位置传感器无刷直流电机转子位置检测误差分析及其补偿[J].微特电机,2003,31(6):8-9. 被引量：8
2沈建新,吕晓春,杜军红,陈永校.无传感器无刷直流电机三段式起动技术的深入分析[J].微特电机,1998,26(5):8-11. 被引量：71
3Lai Yenshin, Shyu Fusan, Tseng Shianshau. New initial position detection technique for three-phase brushless DC motor without position and current sensors[J]. IEEE Transaction on Industry Application, 2003, 39(2): 485-491.
4Jang G H, Park J H, Chang start-up algorithm of a ro motor utilising inductanc Electric Power Application J H. Position detection and tor in a sensorless BLDC e variation[J]. IEE Proc. ,2002, 49(2): 137-142.
5Lee Wookjin, et al. A new starting method of BLDC motors without position sensor[J]. IEEE Trans. on Industry Application, 2006, 42(6): 1532-1538.
6Schmidt P B, Gasperi M L, et al. Initial rotor angle detection of a non-salient pole permanent magnet synchronous machine[C]. IEEE IA Society Annual Meeting, New Orleans, Louisiana, 1997, 1: 459-463.
7Chang Yenchuan, Tzou Yingyu. A new sensorless starting method for brushless DC motors without reversing rotation[C]. IEEE Power Electronics Specialists Conference, 2007: 619-624.
8Uzuka K, Uzuhashi H, et al. Microcomputer control for sensorless brushless motor[J]. IEEE Trans. on Ind. Appl., 1985, 21(4): 595-601.
9Chen Chenghu, Cheng Mingyang. A new sensorless commutation drive for brushless alternator[C]. IEEE International DC motor and Symposium on Industrial Electronics, 2006, 3:2116-2121.
10Lin Mingyao, Gu Weigang, et al. Design of position detection circuit for sensorless brushless DC motor drive[C]. IEEE IEMDC2007, 2007, 1: 225-228.