乙醇中镧盐催化果糖脱水制备5-羟甲基糠醛的研究

Catalytic Dehydration of Fructose to 5-hydroxymethylfurfural by Lanthanum Salt in Ethanol

以乙醇为反应溶剂,镧盐为催化剂催化果糖制备5-羟甲基糠醛(5-HMF)进行了初步研究。乙醇作为反应溶剂时,5-HMF产率远高于以水作为反应溶剂。氯化镧与硝酸镧相比具有更好的催化活性。提高催化剂浓度可以增大果糖转化为5-HMF的速率,但是对5-HMF的最大产率影响较小。随着反应温度的提高,果糖转化为5-HMF的速率增大,5-HMF的产率也明显提高。当反应温度为140℃时,反应20min产率即可达到41.6%。

A preliminary study of catalytic dehydration of fructose to 5-hydroxymethylfurfural（5-HMF） was carried out by using ethanol as solvent and lanthanum salt as catalyst.A comparison study indicated that the yields of 5-HMF in ethanol was much larger than those in water.LaCl3 had higher catalytic activity than La（NO3）3.Increasing the catalyst concentration can accelerate the reaction of dehydration of fructose to 5-HMF,but had little effect on increasing the maximum yield of 5-HMF.The yield of 5-HMF,as well as the reaction rate of dehydration of fructose to 5-HMF,increased along with the increase in temperature.The yield of 5-HMF up to 41.6 % was achieved after 20 min at 140℃.