摘要
采用湿法制备了高铁酸钾(K2FeO4)氧化剂,研究了其对染料活性艳红X-3B(X-3B)和分散蓝2BLN(2BLN)在不同pH条件下的脱色效果,并对Al2(SO4)3、K2FeO4及O3对活性及分散染料的脱色效果进行了比较。结果表明:高铁酸钾对活性及分散染料的脱色效果明显,X-3B脱色率随pH的增加不断提高,2BLN脱色率在pH 6~10范围内无明显变化,在pH=5时达到最大值。在X-3B及2BLN浓度同为100 mg/L,pH分别为10、5,K2FeO4浓度分别为100 mg/L和200mg/L时,BLN及X-3B的脱色率分别达到92.3%和87.3%。在相同条件下,K2FeO4对活性艳红X-3B的脱色效果好于Al2(SO4)3和O3;而K2FeO4对分散蓝2BLN的脱色效果虽比Al2(SO4)3稍差,但比臭氧的脱色效果要好。同时还研究了K2FeO4对活性及分散染料的脱色机理,结果表明:高铁酸钾对X-3B的脱色依赖于K2FeO4的氧化作用,而对的2BLN的脱色则以絮凝为主。
Potassium ferrate(K2FeO4) oxidant was prepared by wet method.Decolorization of reactive dye(reactive brilliant red,X-3B) and disperse dye(disperse blue,2BLN) by ferrate at different pH was studied.The results showed that potassium ferrate had obvious effect on the decolorization of reactive and disperse dyes.The decolorization rate of X-3B increased with pH increasing.The decolorization rate of 2BLN had no significant changes during pH changed from 6 to 10,but it reached the maximum value at pH 5.Under the conditions of the concentration of dyes both 100 mg/L,pH 10,5 and K2FeO4=100 mg/L and 200 mg/L,respectively,2BLN and X-3B decolorization rates reached to 92.3% and 87.3%.Under the same conditions,the decolorization of reactive red X-3B by ferrate was much better than that by Al2(SO4) 3 and O3.The decolorization of disperse blue 2BLN by ferrate was a little less effective than that by Al2(SO4) 3,but it was much better than that by O3.The decolorization mechanisms of 2BLN and X-3B by ferrate were also studied.The results showed that the decolorization of X-3B was almost dependent on the oxidation of K2FeO4.But the decolorization of 2BLN was mainly dependent on the flocculation of K2FeO4.
出处
《环境工程学报》
CAS
CSCD
北大核心
2012年第2期423-428,共6页
Chinese Journal of Environmental Engineering
基金
国家自然科学基金资助项目(50678104
50978169)
深圳市科技工贸和信息化委员会资助项目(JC200903180722A)
关键词
高铁酸钾
氧化
混凝
脱色
活性染料
分散染料
potassium ferrate
oxidation
coagulation
decolorization
reactive dyes
disperse dyes