在质量块冲击作用下刚架大挠度响应的实验研究

EXPERIMENTAL INVESTIGATION ON LARGE DEFLECTION RESPONSE OF A FRAME IMPACTED BY A MOVING BODY

本文报道刚架跨中受到以不同速度运动的质量块冲击时动态大挠度响应的实验研究工作,实验测取了冲击点位移、速度随时间变化的曲线及某些关键点的动态应变历史,由此描述了在响应过程中,质量块与刚架间动量动能的传递过程,找出了塑性区域形成和扩展的规律。研究表明:初始撞击接近于理想非弹性,动态荷载不宜简化为瞬时冲量,此时初始冲击动能与刚架所能吸收的最大弹性能之比即便很大,响应中弹性成分仍占有很大的比例,能量比率作为判断是否宜于采用刚塑性解答的条件已不再充分;刚架在初始撞击中吸收的能量和冲量与初始动能和动量之比,仅与刚架承受初始撞击的相当质量和冲击物质量之比有关,而与冲击速度无关,文中给出了二者的关系式。

This paper reports on the experimental investigation of the dynamic large deflection response of a portal frame impacted at its midspan by a body moving at a certain speed. Both the deflection and velocity vs. time curves of the midapan and the dynamic history of a number of desired locations were recorded during the process of response. On the basis of the test data, the momentum and kinetic energy conversion between the frame and the moving body in the impact process are realized, and the occurrence and expansion of plastic regions are described. Investigation results show that the initial collision is approximately ideally inelastic, and that the elastic deformation plays a considerable role in the response though the input energy is much larger than the maximum elastic energy capacity of the beam member; therefore, in a general impact, the energy ratio should not be regarded as a sufficient criterion for a rigid-plastic solution. The ratios of the impulse transformed to and the energy absorbed by the frame in the initial collision to that carried by the moving body before impact is only related to the ratio between the 'equivalent mass' of the frame paticipating in the initial collision and the mass of the impacting body, having nothing to do with the impacting velocity to a certain extent.