GC-MS建立醒神滴鼻液中间产物质量控制标准研究

Study on Quality Control Standard of Intermediate Products of Xingshen Nasal Drops by GC-MS

目的 :建立醒神滴鼻液两个“中间产物”(麝香芳香水、石菖蒲挥发油 )的质量控制标准 ,以确保成品批次间主要成分含量及组成保持稳定 ;方法 :采用GC MS制定了麝香芳香水中麝香酮的含量限度 ,同时建立了石菖蒲挥发油的特征指纹图谱 ;结果 :麝香芳香水中麝香酮可控制在 0 .16 6～ 0 .2 0 2mg/mL之间 ,3批成品麝香酮含量差异RSD =4.49% ,不超过10 % ;以甲基丁香酚、顺式甲基异丁香酚、反式甲基异丁香酚、榄香素、β 细辛醚、α 细辛醚 6个主要成分的出峰先后顺序及其相对含量为特征构成了石菖蒲挥发油的特征指纹图谱 ,以上特征在成品中可以重复。结论 :建立“中间产物”的质量控制标准可提高中药复方的质量水平 ,GC MS是有效手段之一。

Objective: To establish the quality control standards of two intermediate products of Xingshen Nasal Drops:musk aromatic water and volatile oil of Acorus tatarinowii Schott so that the content of main components and composition of the different batches of ultimate products remained stable.Methods: The content limit of muskone of musk aromatic water was ascertained by GC-MS. And the characteristic finger print of volatile oil of Acorus tatarinowii Schott was established. Results: The content of muskone of musk aromatic water should be controlled at the range of 0.166～0.202mg/mL. RSD of muskone content of 3 batches of ultimate products was 4.49%, not larger than 10%. The characteristic finger point of volatile oil of Acorus tatarinowii Schott was composed of 6 main component peaks: Methyleugenol, cis-Methylisoeugenol, trans-Methylisoeugenol, Elemicin, β-Asarone and α-Asarone. This characteristiz finger print could be repeated when the ultimate product was determined. Conclusion: The establishment of quality control standard of intermediate product can raise the product quality of compound preparations. And GC-MS is one of effective determination methods.