摘要
针对高铝渣特有的黏度高、流动性差、脱硫能力差的特点,济钢3200 m3高炉通过调整热制度和布料制度,在烧结时提高MgO含量,控制渣中镁铝比>0.6,使渣中MgO含量在8%~11%,高炉的整体操作炉型适应了高铝渣的冶炼要求。在渣铁比升高43 kg/t的条件下,高炉生铁含硅降低,炉渣脱硫能力增强,基本杜绝了三类铁。
To the characteristics of high Al2O3 slag with higher viscosity, poor liquidity, and poor desulphurization ability, by adjusting the thermal system and distributing system, the Mg/Al ratio in the slag is controlled lager than 0.6 by increasing the MgO content in sintering, the MgO content in the slag is made between 8%-11%, the overall operation of 3 200 m^3 BF in Jinan Steel can fit smelting requirement with high Al2O3 slag. Under the condition of slag ratio increase by 43 kg/t, the silicon in the pig iron was decreased, the desulphurization ability of the slag was strengthened and third grade iron was eliminated basically.
出处
《山东冶金》
CAS
2015年第3期1-3,共3页
Shandong Metallurgy
关键词
高炉
高铝渣
镁铝比
MGO含量
blast furnace
high Al2O3 slag
ratio of magnesium and aluminum in slag
MgO content
