摘要
为了解惰性粉气溶胶防虫技术在横向通风系统仓房使用中,惰性粉随气流在粮堆中的扩散和分布状态,采用称重和显微镜、电子显微镜观察等方法对粮堆不同部位采集的粉尘样本进行检测。结果表明,在施粉阶段,施粉对侧主风道内能够检测到惰性粉气溶胶浓度约为0.039 mg/L,表明惰性粉气溶胶能够在粮堆中粮粒的空隙间扩散,可以穿透21 m粮堆,到达对侧主风道。施粉结束后,检测粮堆内粮粒沾粉情况,结果发现紧挨喷粉侧的粮粒沾粉率较高,最高可达6.9%。而沿着气流向粮堆内流动的方向,粮堆中沾粉粮粒的百分率逐渐降低。
In order to understand application of inert dust aerosol pest control technology in crosswise ventilating system warehouse and diffusion and distribution status of inert dusts in grain bulk with airflow, weighing and observation with microscope & electron microscope were conducted to detect dust samples collected at different positions of the grain bulk. Results showed that in dust applying phase, applying dusts inside offside main air duct could detect that concentration of inert dust aerosol was about 0. 039 mg/L, which indicated that inert dust aerosol could diffuse in interspace between grains in grain bulk. Besides, it could penetrate grain bulk which was 21 meters wide and then reached offside main duct. At the end of dust applying, dust sticking situation of grains in grain bulk was detected, and results found that dust sticking rate of grains which was next to dust spraying side was higher, with the maximum rate reaching 6.9%. While along the direction of airflow flowing to internal grain bulk, percentage of grains which had been stuck with dusts in grain bulk would gradually decrease.
出处
《中国粮油学报》
EI
CAS
CSCD
北大核心
2016年第12期90-94,共5页
Journal of the Chinese Cereals and Oils Association
基金
国家粮食公益专项(201313001
2015449-001-03)
国家国际科技合作(2013DFA31960)
关键词
食品级惰性粉
横向通风
气溶胶
分布
food -grade inert dust, transverse ventilation, aerosol, distribution