摘要
采用称重法、动电位极化法和电化学交流阻抗技术研究了30oC时(1,3-Dioxolan-2-ylmethyl)三苯基溴化磷(DTPB)对0.5 mol·L-1柠檬酸中锌腐蚀行为的影响.通过在环保型电解槽中对锌进行酸洗,这在文献中是不常用的.结果表明,DTPB作为一种有效的防蚀剂,添加浓度仅为3×10-3mol·L-1时,锌在柠檬酸溶液中的防蚀效率可达98.9%.由于DTPB和碘化钾存在协同效应,两者联用时的防蚀效果要比单独使用DTPB强,防蚀参数为1.2,并随温度升高而减小.本文提出了碘化钾作为吸附媒介,可使金属表面与DTPB结合的防蚀机制.
The effect of (1,3-Dioxolan-2-ylmethyl)-triphenylphosphonium bromide (DTPB) on the zinc corrosion in 0.5 mol·L^-1 citric acid solution was investigated at 30 -(3 using weight loss, potentiodynamic polarization and electrochemical impedance spec- troscopy (EIS) techniques. An ecofi'iendly bath was used for acid cleaning of zinc, which has not been widely used in literatures. The results showed that DTPB could serve as an effective inhibitor for the zinc corrosion in a citric acid solution with the inhibition efficiency of 98.9% at the DTPB concentration of 3× 10^-3 mol·L^-1. A synergistic effect between DTPB and potassium iodide (KI) enhanced the inhibition capability of DTPB, and better inhibition efficiency was achieved as compared with that by using DTPB alone. The synergism parameter had a value of 1.2 and was found to decrease with temperature. An inhibition mechanism is pro- posed by which KI acts as an adsorption mediator for bonding metal surface and DTPB.
出处
《电化学》
CSCD
北大核心
2017年第4期441-455,共15页
Journal of Electrochemistry
基金
supported by Corrosion Laboratory,Chemistry department,Faculty of science,Alexandria university,Egypt
关键词
锌
极化
电化学交流阻抗
酸蚀
协同
zinc
polarization
electrochemical impedance spectroscopy
acid corrosion
synergism