摘要
通过搭建多层喷雾洗涤塔实验台,研究了液气体积比、塔内气体平均流速、粉尘浓度、喷雾压力等操作参数对除尘效率的影响规律。研究结果表明:洗涤塔内喷雾层数对除尘效率的影响最为显著,与传统的单层相比,除尘效率可以提高15%以上,并且入口粉尘浓度的变化对其除尘效率的影响较小。增大喷雾压力可以有效提升除尘效率,当喷雾压力为0.5~0.6MPa时除尘效率变化趋于稳定。在相同操作参数下,适当降低气体在塔内平均流速有利于提高洗涤塔的除尘效率,对于三层喷雾洗涤,最佳的气体塔内平均流速为0.6~0.8m/s。当喷雾压力为0.6MPa、塔内气体平均气速为0.6m/s、液气体积比为5.27的条件下,三层喷雾除尘的效率可以达到98.3%。
An experimental device was built up to study the dust removal characteristics in multi-layerspray column scrubber.The operating parameters which influence dust removal efficiency wereanalyzed,such as volume ratio of liquid to gas,average velocity of gas in column,inlet dust loadingand spray pressure.The results showed that the spray layer have most significant influence to dustremoval.The efficiency of three-layer column scrubber increased by more than15%compared with thetraditional washing tower,and inlet dust loading have little impact on it.Increasing spray pressure canenhance the efficiency of dust removal obviously.When spray pressure is0.5-0.6MPa,the dustremoval efficiency will be stable.Under the same operating parameters,reducing the average velocityof gas in scrubber will help to improve dust removal efficiency.For the three-layer column scrubber,the best average velocity of gas is0.6-0.8m/s.In this experiment,dust removal efficiency can reach98.3%in three-layer spray column scrubber,when spray pressure is0.6MPa,the average velocity ofgas in column is0.6m/s,and volume ratio of liquid to gas is5.27.
作者
张立栋
李晓博
王擎
秦宏
崔达
ZHANG Lidong;LI Xiaobo;WANG Qing;QIN Hong;CUI Da(Engineering Research Center of Ministry of Education for Comprehensive Utilization of Oil Shale,Northeast Electric Power University,Jilin 132012,Jilin,China;Jishun Oil Shale Development Co.,Ltd.,Jilin 132012,Jilin,China)
出处
《化工进展》
EI
CAS
CSCD
北大核心
2017年第7期2375-2380,共6页
Chemical Industry and Engineering Progress
基金
教育部长江学者和创新团队发展计划(IRT13052)
吉林省自然科学基金(20150101033JC)
吉林市科技计划(201464044)
吉教科合字2015-237项目
关键词
喷雾洗涤塔
粉尘颗粒
脱除
湿法除尘
sprayer column scrubber
fine particles
dust removal
wet scrubber