期刊文献+

Investigation of the Vibration Behavior of Fluidelastic Instability in Closely Packed Square Tube Arrays 被引量:1

Investigation of the Vibration Behavior of Fluidelastic Instability in Closely Packed Square Tube Arrays
下载PDF
导出
摘要 Flow-induced vibrations in heat exchanger tubes have led to numerous accidents and economic losses in the past. Fluidelastic instability is the most critical flow-induced vibration mechanism in heat exchangers. Both experimental and computational studies conducted to determine fluidelastic instability were presented in this paper. In the experiment, a water channel was built, and a closely packed normal square tube array with a pitch-to-diameter ratio of 1.28 was tested, and significant fluidelastic instability was observed. A numerical model adopting large-eddy simulation and moving mesh was established using ANSYS CFX, and results showed good agreement with the experimental findings. The vibration behaviors of fluidelastic instability were discussed, and results showed that the dominant vibration direction of the tubes changed from streamwise to transverse beyond a critical velocity. A 180° phase lag between adjacent tubes was observed in both the experiment and simulations. Normal and rotated square array cases with pitch-to-diameter ratios of 1.28 and 1.5 were also simulated. The results of this study provide better insights into the vibration characteristics of a square tube array and will help improve the fundamental research and safety design of heat exchangers. Flow-induced vibrations in heat exchanger tubes have led to numerous accidents and economic losses in the past. Fluidelastic instability is the most critical flow-induced vibration mechanism in heat exchangers. Both experimental and computational studies conducted to determine fluidelastic instability were presented in this paper. In the experiment, a water channel was built, and a closely packed normal square tube array with a pitch-to-diameter ratio of 1.28 was tested, and significant fluidelastic instability was observed. A numerical model adopting large-eddy simulation and moving mesh was established using ANSYS CFX, and results showed good agreement with the experimental findings. The vibration behaviors of fluidelastic instability were discussed, and results showed that the dominant vibration direction of the tubes changed from streamwise to transverse beyond a critical velocity. A 180° phase lag between adjacent tubes was observed in both the experiment and simulations. Normal and rotated square array cases with pitch-to-diameter ratios of 1.28 and 1.5 were also simulated. The results of this study provide better insights into the vibration characteristics of a square tube array and will help improve the fundamental research and safety design of heat exchangers.
出处 《Transactions of Tianjin University》 EI CAS 2019年第2期124-142,共19页 天津大学学报(英文版)
基金 High-performance Computing Center of Tianjin University supported by the Natural Science Foundation of China(No.21606164)
关键词 Fluidelastic INSTABILITY DOMINANT vibration direction Phase LAG SQUARE TUBE array Heat EXCHANGER Fluidelastic instability Dominant vibration direction Phase lag Square tube array Heat exchanger
  • 相关文献

参考文献1

二级参考文献12

  • 1聂清德,张明贤,郭宝玉,申东雄.管束的流体弹性不稳定性的研究[J].振动工程学报,1993,6(2):107-117. 被引量:5
  • 2GB 151-1999,钢制管壳式换热器[S].
  • 3Standards of Tubular Exchanger Manufactures Association[S].9th Ed.2007.
  • 4ASME Boiler and Pressure Vessel Code,Section Ⅲ,Appendix N(N-1300 series)[S].
  • 5Moulinec C,Pourquie M J B,Boersma B J,et al.Directnumerical simulation on a Cartesian mesh of the flow through a tube bundle[J].International Journal of Computational Fluid Dynamics,2004b,18:1 14.
  • 6Hassan Y A,Ibrahim W A.Turbulence prediction in twodimensional bundle hows using large eddy simulation[J].Nuclear Technology Journal,1997,119:11-28.
  • 7Hassan Y A,Barsamian H R.Turbulence simulation in tube bundle geometries using the dynamic subgrid-scale model[J].Nuclear Technology Journal,1999,128:58-74.
  • 8Rollet-Miet P,Laurence D,Ferziger J H.LES and RANS of turbulent flow in tube bundles[J].International Journal of Heat and Fluid Flow,1999,20:241-254.
  • 9Benharnadouche S,Laurence D.LES coarse LES,and transient RANS comparisons on the ? ow across a tube bundle[J].International Journal of Heat and Fluid Flow,2003,24:470-479.
  • 10Placzek A,Sigrist J F,Hamdouni A.Numerical simulation of vortex shedding past a circular cylinder at low reynolds number with finite volume technique.part Ⅰ:forced oscillations[J].Pressure Vessel and Piping.San Antonio,2007:22-26.

共引文献11

同被引文献3

引证文献1

相关作者

内容加载中请稍等...

相关机构

内容加载中请稍等...

相关主题

内容加载中请稍等...

浏览历史

内容加载中请稍等...
;
使用帮助 返回顶部