摘要
采用聚偏氟乙烯(PVDF)中空纤维膜作为膜材料,利用直接接触式膜蒸馏法处理质量分数分别为5%、15%和25%的NaCl溶液;使用正交实验方法对操作条件进行优化设计,研究表明当料液侧入口温度T1为80℃,渗透液侧入口温度T3为20℃,流量100 L/h时膜通量最大,可达12.599 kg/(m2·h);当料液侧入口温度T1为80℃,渗透液侧入口温度T3为35℃,流量Q为40L/h时造水比最高,可达13.775,截留率均可达到99.9%以上;单因素实验结果表明膜通量随着T1和Q的增大而增加,随着T3的升高而降低;造水比随着T1、T3的升高而增加,随着Q的增加而降低。研究表明膜蒸馏技术处理含盐溶液具有很好的应用前景。
Polyvinylidene fluoride(PVDF)hollow fiber membrane is used as membrane material,NaCl solutions with concentrations of 5%,15% and 25% are treated by direct contact membrane distillation.Orthogonal experiment is used to optimize the operation conditions,and the result show that value of the permeate flux(J)could achieve maximum value of 12.599kg/(m^2·h)when the inlet temperature of liquid side(T1)is 80℃,inlet temperature of osmotic side(T3)is 20℃,and flow rate(Q)is 100L/h.Gained output ratio(GOR)could be 13.775 when T1 is 80℃,T3 is 35℃ and Q is 40L/h.The salt rejection ratio all is more than 99.9%.The result of single factor experiment show that J is raised with the increase of T1 and Q,but decreased with the increase of T3.GOR is increased with the increase of T1 and T3,but decreased with the increase of the Q.The research indicate that membrane distillation technology has a good applied prospect of treat saline solution.
作者
刘羊九
韩吉田
王云山
任天健
LIU Yangjiu;HAN Jitian;WANG Yunshan;TIEN-CHIEN Jen(School of Energy and Power Engineering,Shandong University,Jinan 250061,Shandong,China;Mechanical Engineering Science Department,University of Johannesburg,Auckland Park 2006,South Africa)
出处
《化工学报》
EI
CAS
CSCD
北大核心
2018年第A02期246-251,共6页
CIESC Journal
基金
国家自然科学基金国际(地区)合作与交流项目(41761144067)~~
关键词
直接接触式膜蒸馏
PVDF中空纤维膜
蒸馏
脱盐
设计
direct contact membrane distillation
PVDF hollow fiber membrane
distillation
desalination
design