摘要
加水比例及物相行为研究对硫酸镁亚型盐湖钾镁混盐转化制备软钾镁矾工艺具有重要意义。以柴达木盆地一里坪盐湖钾镁混盐为对象,采用"转化-浮选"法制备钾盐镁矾,研究了钾镁混盐初始及转化产生的物相行为。结果表明,初始物相光卤石、水氯镁石溶解速率最快,分解得到新物相氯化钾。初始物相钾盐镁矾及其转化得到的新物相软钾镁矾,溶解转化速率次之,加水比例高于0.40时,速率趋于平缓。初始物相氯化钠溶解速率始终最低。转化过程中,氯化钾只发生溶解行为,并未与软钾镁矾反应生成新物相硫酸钾。转化实验结果与理论计算结果吻合度高,相对误差低于4%,利用介稳相图理论计算能够指导钾镁混盐转化。同时,正浮选捕收剂对含钾物相的捕收吸附能力强于反浮选,钾的总收率达到66%。
Study on water-salt mass ratio and phase behavior during the K-Mg mixed salt transformation from magnesium sulfate-type salt lake is important for preparing Pic (Picromerite). Pic was prepared from the K-Mg mixed salt of Yiliping salt lake in Qaidam Basin by means of transformation-flotation. Phase behavior was researched which was the initial and new produced by transformation. The results showed that the dissolution rate of the initial phase Car (Carnallite) and Bis (Bischofite) was the fastest, and the new phase KCl (Sylvite) was obtained by decomposition. The dissolution and transformation rate of the initial phase Kai (Kainite) and the new phase Pic transformed from Kai was second, and while the water-salt mass ratio was higher than 0.40, the rate tended to be flat. The dissolution rate of the initial phase NaCl (Halite) was always the lowest. During the transformation, KCl only dissolved, didn't react with Pic to form a new phase SOP (potassium sulfate). Experimental results of the K-Mg mixed salt transformation were in good agreement with theoretical calculation results, the relative error was less than 4% between them, the theoretical calculations of the metastable phase diagram could be used to guide the KMg mixed salt transformation better. Finally, the obverse flotation collector had stronger capacity for collecting and adsorbing the K-containing phase than the reverse, the total yield of K had been reached 66%.
作者
时历杰
王敏
SHI Lijie;WANG Min(Key Laboratory of Comprehensive and Highly Efficient Utilization of Salt Lake Resources, Qinghai Institute of Salt Lakes,Chinese Academy of Sciences, Xining 810008, Qinghai, China;Key Laboratory of Salt Lake Resources Chemistry of QinghaiProvince, Xining 810008, Qinghai, China)
出处
《化工学报》
EI
CAS
CSCD
北大核心
2019年第5期1832-1841,共10页
CIESC Journal
基金
国家自然科学基金项目(415030610)
青海盐湖研究所引导基金项目(Y560311147)
青海省重点研发与转化计划项目(2017-GX-145)
关键词
钾镁混盐
溶解转化
钾盐镁矾
物相行为
硫酸镁亚型
介稳相平衡
制备
浮选
K-Mg mixed salt
dissolution and transformation
kainite
phase behavior
magnesium sulfate type
metastable phase equilibria
preparation
flotation