过载对丁羟三组元推进剂燃烧特性的影响

Effects of acceleration overload on combustion characteristics of HTPB/AP/Al propellant

为研究过载对丁羟三组元推进剂燃烧特性的影响,设计了兼具燃速测量和凝相产物收集功能的过载实验发动机。利用过载实验方法,研究了不同过载大小(-50g~+50g)对燃烧室压强、平均燃速、瞬态燃速、凝相产物和发动机羽流的影响。研究表明:(1)反向过载对燃烧室压强和推进剂燃速几乎没有影响。随着正向过载的增大,燃烧室压强和推进剂燃速增大。(2)与无过载相比,燃烧室压强在+10g过载下增加35.8%,+30g过载下最大压强增加69.9%,+50g过载下最大压强增加76.8%,且在+30g过载和+50g过载下出现了“驼峰现象”。(3)与0g相比,+10g过载下燃速增加21%,+30g过载下燃速增加40%,+50g过载下燃速增加44%;+30g和+50g过载下,瞬态燃速先增加后减少,最大值随过载增大而增大,达到最大值的时间随过载的增大而减少。(4)药杯内的碳和单质铝含量随过载的增大而减小,从-50g过载到+50g过载,分别减小100%和82.28%,氧化铝随过载的增大而增大,增加了402.17%,收集装置内几乎不含碳和铝单质。且收集装置内凝相产物的粒径随正向过载的增大而减小。(5)过载对发动机羽流颜色有显著影响;反向过载下,发动机羽流火焰呈现黄色,且伴随明亮的火星;正向过载下呈现紫色。

In order to study the effect of acceleration field on the combustion characteristics of HTPB/AP/Al propellant,an overload test rocket with both burning rate measurement and condensate product collection functions was designed.The effects of different overload magnitudes(-50g to +50g) on combustion chamber pressure,mean combustion velocity,transient combustion velocity,condensed phase products and rocket plume were investigated by using the overload test method.The research showed that:(1) the reverse overload had little effect on the pressure of the combustion chamber and the burning rate of the propellant.With the increase of forward overload,the combustion chamber pressure and propellant burning rate increased.(2) Compared with that without overload,the combustion chamber pressure increased by 35.8% under +10g overload,69.9% under +30g overload,and 76.8% under +50g overload,and there was a “hump phenomenon” under +30g overload and +50g overload.(3) Compared with 0g,the burning rate increased by 21% under +10g overload,40% under +30g overload,and 44% under +50g overload.At +30g and +50g overload,the transient combustion velocity increased and then decreased,the maximum value increased with the increasing overload,the time to reach the maximum value decreased with the increasing overload.(4) The content of carbon and elemental aluminum in the medicine cup decreased by 100% and 82.28%,respectively,with the increase of positive overload,and the alumina increased by 402.17% with the increase of positive overload.There was almost no carbon and aluminum in the collection device.And the particle size of the condensed-phase product in the collection device decreased with the increase of positive overload.(5) Acceleration field had a significant effect on the color of rocket plume;under reverse overload,the engine plume flame appeared yellow accompanied by bright sparks;under forward overload,it appeared purple.