The liquid phase Beckmann rearrangement of cyclohexanone oxime (CHO) using fuming sulfuric acid as a catalyst is a traditional method for preparing ε-caprolactam (CPL). This process has drawbacks, such as environment...The liquid phase Beckmann rearrangement of cyclohexanone oxime (CHO) using fuming sulfuric acid as a catalyst is a traditional method for preparing ε-caprolactam (CPL). This process has drawbacks, such as environmental pollution, corrosion of equipment, and low added value of by-product ammonium sulfate. This article designed and prepared a green silica gel-supported trifluoromethanesulfonic acid catalyst for the liquid-phase Beckmann rearrangement of CHO to prepare (CPL). The influencing factors of catalyst preparation and the optimal reaction conditions for Beckmann rearrangement were investigated. It was found that the optimal conditions for catalyst preparation were as follows: raw material silica gel:trifluoromethanesulfonic acid = 1:0.2 (mass ratio), room temperature, stirring time of 2.5 hours, and solvent of acetonitrile, silica gel mesh size is 100 - 200. The optimal reaction conditions for Beckmann rearrangement are CHO: catalyst = 1:2 (mass ratio), temperature of 130˚C, solvent of benzonitrile, volume of 30 mL/g CHO, and reaction time of 4 hours. Under the above conditions, the conversion of CHO is 90%, and the selectivity of CPL is 90%.展开更多
The addition of platinum over the B2O3/TiO2-ZrO2 remarkably enhanced its catalytic stability in the vapor phase Beckmann rearrangement of cyclohexanone oxime under the carder gas of H2. The content of coke deposited ...The addition of platinum over the B2O3/TiO2-ZrO2 remarkably enhanced its catalytic stability in the vapor phase Beckmann rearrangement of cyclohexanone oxime under the carder gas of H2. The content of coke deposited on catalyst surface was decreased from 1.92% over the B2O3/TiO2-ZrO2 to 1.14% over the platinum promoted B2O3/TiO2-ZrO2 after reaction of six hours. This result indicates that the platinum added on the B2O3/TiO2-ZrO2 catalyst plays an important role in reducing the coke formation on the catalyst surface.展开更多
Four different ZSM 5 zeolites are tested for the gas phase Beckmann rearrangement of cyclohexanone oxime (CHO) into lactam. B ZSM 5 derived titanosilicalite (Ti ZSM 5) exhibits catalytic performances comparabl...Four different ZSM 5 zeolites are tested for the gas phase Beckmann rearrangement of cyclohexanone oxime (CHO) into lactam. B ZSM 5 derived titanosilicalite (Ti ZSM 5) exhibits catalytic performances comparable to hydrothermally synthesized titanosilicalite (TS 1), much better than B ZSM 5 and Al ZSM 5. The effect of reaction conditions (solvent, feed space velocity, and water) on the catalytic performance of Ti ZSM 5 is studied. It is found that a quantitative relationship exists among the feed space velocity, the reaction time, and the CHO constant conversion. Ethanol or methanol as solvent shows higher activity, lactam selectivity, and stability than benzene and n hexanol. The addition of water to the rearrangement with a maximum amount of 1.0 mole per mole CHO results in the increase of CHO conversion while no meaningful changes in lactam selectivity and stability are observed.展开更多
Silicalite-1 was hydrothermally synthesized in the presence of different concentrations of Na+using tetrapropylammonium hydroxide(TPAOH)as a template.The synthesis was followed by a base treatment.The silicalite-1samp...Silicalite-1 was hydrothermally synthesized in the presence of different concentrations of Na+using tetrapropylammonium hydroxide(TPAOH)as a template.The synthesis was followed by a base treatment.The silicalite-1samples were characterized using X-ray diffrac-tion,scanning electron microscopy,N2 adsorption,X-ray photoelectron spectroscopy,Fourier transform infrared spectroscopy and NH3 temperature-programmed deso-rption.The samples were used as catalysts for the vapor phase Beckmann rearrangement of cyclohexanone oxime.During the synthesis,the sodium ions were incorporated onto the silicalite-1 crystals,but were then removed by the base treatment.All the catalysts exhibited nearly complete conversion of cyclohexanone oxime toε-caprolactam with selectivities grater than 95%.Addition of less than 2.5 mol-%Na^(+)(relative to TPAOH)did not influence the catalytic properties.However,for Na+concentrations≥5 mol-%,the particle sizes of silicalite-1 increased and the catalytic activities decreased,which can be attributed to carbon deposition.The results in this work are of great importance for the polymer industry.展开更多
研究了氢氟酸后处理对silicalite-1催化环己酮肟气相Beckmann重排反应性能的影响.结果表明,经适当浓度的氢氟酸溶液处理后,催化剂的选择性和稳定性都明显改善.其中,silicalite-1原粉先经硝酸铵预处理后再进行氢氟酸后处理所得到的催化...研究了氢氟酸后处理对silicalite-1催化环己酮肟气相Beckmann重排反应性能的影响.结果表明,经适当浓度的氢氟酸溶液处理后,催化剂的选择性和稳定性都明显改善.其中,silicalite-1原粉先经硝酸铵预处理后再进行氢氟酸后处理所得到的催化剂催化性能最好,反应53 h后环己酮肟的转化率仍保持在96%左右,己内酰胺的选择性高达96.1%.XRD,FT-IR和29Si MAS NMR的结果表明,较高的具有氢键相互作用的硅羟基与孤立硅羟基的比例值对环己酮肟气相Beckmann重排反应有利,同时,silicalite-1表面硅原子的排布方式对该反应也有重要影响.展开更多
文摘The liquid phase Beckmann rearrangement of cyclohexanone oxime (CHO) using fuming sulfuric acid as a catalyst is a traditional method for preparing ε-caprolactam (CPL). This process has drawbacks, such as environmental pollution, corrosion of equipment, and low added value of by-product ammonium sulfate. This article designed and prepared a green silica gel-supported trifluoromethanesulfonic acid catalyst for the liquid-phase Beckmann rearrangement of CHO to prepare (CPL). The influencing factors of catalyst preparation and the optimal reaction conditions for Beckmann rearrangement were investigated. It was found that the optimal conditions for catalyst preparation were as follows: raw material silica gel:trifluoromethanesulfonic acid = 1:0.2 (mass ratio), room temperature, stirring time of 2.5 hours, and solvent of acetonitrile, silica gel mesh size is 100 - 200. The optimal reaction conditions for Beckmann rearrangement are CHO: catalyst = 1:2 (mass ratio), temperature of 130˚C, solvent of benzonitrile, volume of 30 mL/g CHO, and reaction time of 4 hours. Under the above conditions, the conversion of CHO is 90%, and the selectivity of CPL is 90%.
文摘The addition of platinum over the B2O3/TiO2-ZrO2 remarkably enhanced its catalytic stability in the vapor phase Beckmann rearrangement of cyclohexanone oxime under the carder gas of H2. The content of coke deposited on catalyst surface was decreased from 1.92% over the B2O3/TiO2-ZrO2 to 1.14% over the platinum promoted B2O3/TiO2-ZrO2 after reaction of six hours. This result indicates that the platinum added on the B2O3/TiO2-ZrO2 catalyst plays an important role in reducing the coke formation on the catalyst surface.
基金the Foundations for Basic Research ofTsinghua U niversity and of China Petrochem icalCompany
文摘Four different ZSM 5 zeolites are tested for the gas phase Beckmann rearrangement of cyclohexanone oxime (CHO) into lactam. B ZSM 5 derived titanosilicalite (Ti ZSM 5) exhibits catalytic performances comparable to hydrothermally synthesized titanosilicalite (TS 1), much better than B ZSM 5 and Al ZSM 5. The effect of reaction conditions (solvent, feed space velocity, and water) on the catalytic performance of Ti ZSM 5 is studied. It is found that a quantitative relationship exists among the feed space velocity, the reaction time, and the CHO constant conversion. Ethanol or methanol as solvent shows higher activity, lactam selectivity, and stability than benzene and n hexanol. The addition of water to the rearrangement with a maximum amount of 1.0 mole per mole CHO results in the increase of CHO conversion while no meaningful changes in lactam selectivity and stability are observed.
文摘Silicalite-1 was hydrothermally synthesized in the presence of different concentrations of Na+using tetrapropylammonium hydroxide(TPAOH)as a template.The synthesis was followed by a base treatment.The silicalite-1samples were characterized using X-ray diffrac-tion,scanning electron microscopy,N2 adsorption,X-ray photoelectron spectroscopy,Fourier transform infrared spectroscopy and NH3 temperature-programmed deso-rption.The samples were used as catalysts for the vapor phase Beckmann rearrangement of cyclohexanone oxime.During the synthesis,the sodium ions were incorporated onto the silicalite-1 crystals,but were then removed by the base treatment.All the catalysts exhibited nearly complete conversion of cyclohexanone oxime toε-caprolactam with selectivities grater than 95%.Addition of less than 2.5 mol-%Na^(+)(relative to TPAOH)did not influence the catalytic properties.However,for Na+concentrations≥5 mol-%,the particle sizes of silicalite-1 increased and the catalytic activities decreased,which can be attributed to carbon deposition.The results in this work are of great importance for the polymer industry.
文摘研究了氢氟酸后处理对silicalite-1催化环己酮肟气相Beckmann重排反应性能的影响.结果表明,经适当浓度的氢氟酸溶液处理后,催化剂的选择性和稳定性都明显改善.其中,silicalite-1原粉先经硝酸铵预处理后再进行氢氟酸后处理所得到的催化剂催化性能最好,反应53 h后环己酮肟的转化率仍保持在96%左右,己内酰胺的选择性高达96.1%.XRD,FT-IR和29Si MAS NMR的结果表明,较高的具有氢键相互作用的硅羟基与孤立硅羟基的比例值对环己酮肟气相Beckmann重排反应有利,同时,silicalite-1表面硅原子的排布方式对该反应也有重要影响.
