Long-term operation optimization of circulating cooling water systems under fouling conditions

Fouling caused by excess metal ions in hard water can negatively impact the performance of the circulating cooling water system(CCWS)by depositing ions on the heat exchanger's surface.Currently,the operation optimization of CCWS often prioritizes short-term flow velocity optimization for minimizing power consumption,without considering fouling.However,low flow velocity promotes fouling.Therefore,it's crucial to balance fouling and energy/water conservation for optimal CCWS long-term operation.This study proposes a mixed-integer nonlinear programming(MINLP)model to achieve this goal.The model considers fouling in the pipeline,dynamic concentration cycle,and variable frequency drive to optimize the synergy between heat transfer,pressure drop,and fouling.By optimizing the concentration cycle of the CCWS,water conservation and fouling control can be achieved.The model can obtain the optimal operating parameters for different operation intervals,including the number of pumps,frequency,and valve local resistance coefficient.Sensitivity experiments on cycle and environmental temperature reveal that as the cycle increases,the marginal benefits of energy/water conservation decrease.In periods with minimal impact on fouling rate,energy/water conservation can be achieved by increasing the cycle while maintaining a low fouling rate.Overall,the proposed model has significant energy/water saving effects and can comprehensively optimize the CCWS through its incorporation of fouling and cycle optimization.

Effect of Flow Directions on Multiphase Flow Boiling Heat Transfer Enhanced by Suspending Particles in a Circulating Evaporation System

A circulating fluidized bed evaporator(including down-flow, horizontal, and up-flow beds) was constructed to study the effect of flow directions on multiphase flow boiling heat transfer. A range of experimental investigations were carried out by varying amount of added particles(0-2%), circulation flow rate(2.15-5.16 m^3/h) and heat flux(8-16 kW/m^2). The comparison of heat transfer performance in different vertical heights of the horizontal bed was also discussed. Results reveal that the glass bead particle can enhance heat transfer compared with vapor-liquid two-phase flow for all beds. At a low heat flux(q = 8 kW/m), the heat-transfer-enhancing factor of the horizontal bed is obviously greater than those of the up-flow and down-flow beds. With the increase in the amount of added particles, the heat-transfer-enhancing factors of the up-flow and down-flow beds increase, whereas that of the horizontal bed initially increases and then decreases. However, at a high heat flux(q=16 kW/m), the heat-transfer-enhancing factors of the three beds show an increasing tendency with the increase in the amount of added particles and become closer than those at a low heat flux. For all beds, the heat-transfer-enhancing factor generally increases with the circulation flow rate but decreases with the increase in heat flux.

Optimization of circulating cooling water systems based on chance constrained programming

Recent research on deterministic methods for circulating cooling water systems optimization has been well developed. However, the actual operating conditions of the system are mostly variable, so the system obtained under deterministic conditions may not be stable and economical. This paper studies the optimization of circulating cooling water systems under uncertain circumstance. To improve the reliability of the system and reduce the water and energy consumption, the influence of different uncertain parameters is taken into consideration. The chance constrained programming method is used to build a model under uncertain conditions, where the confidence level indicates the degree of constraint violation. Probability distribution functions are used to describe the form of uncertain parameters. The objective is to minimize the total cost and obtain the optimal cooling network configuration simultaneously.An algorithm based on Monte Carlo method is proposed, and GAMS software is used to solve the mixed integer nonlinear programming model. A case is optimized to verify the validity of the model. Compared with the deterministic optimization method, the results show that when considering the different types of uncertain parameters, a system with better economy and reliability can be obtained(total cost can be reduced at least 2%).

Corrosion Inhibition by Co-Immobilized Lysozyme and Lipase in Circulating Cooling Water System

The corrosion inhibition performance of co-immobilized lysozyme and lipase was investigated in a recirculating cooling water system. Four methods were carried out in co-immobilization, and the operating parameters were optimized by using the respond surface methodology(RSM). The corrosion inhibition performance of co-immobilized lipase and lysozyme was evaluated by weight loss measurements and electrochemical measurements. The results revealed that the optimal co-immobilization method should be the sequential immobilization of lysozyme and then lipase. The inhibition efficiency was 86.10% under the optimal co-immobilized conditions. Electrochemical data showed that co-immobilized lysozyme and lipase was a mixed-type inhibitor and the corrosion inhibition efficiency was 81%.

Inhibition characteristics of circulating current in parallel inverter driving system of mine hoist

This research investigated the outputting circulation current inhibition characteristic which are controlled by the instantaneous feedback voltage in inverter parallel driving of the mine hoist. We established a transfer function of the parallel inverters controlled by the close-loop adjustment of instantaneous voltage feedback. The influence of the parameters of the close-loop feedback circuit to the inhibition effects to the outputting circulation current is observed. After analyzing the circulating current inhibition characteristics, the proportion integration （PI） controller is introduced into the close-loop adjustment by instantaneous voltage feedback. The characteristics equation is gained to determine the PI parameters by drawing the Bode plots. The inhibition effects of the proposed controller are examined by the established simulation model of parallel inverter system. The harmonic distortion rate at the outputting voltage frequency value of 4, 10, 20, 41 and 50 Hz, are all lower than 2.32 % by the instantaneous outputting voltage feedback.

Circulating Levels of Hypoxia-regulating MicroRNAs in Systemic Lupus Erythematosus Patients with Hemolytic Anemia

Objective MicroRNAs are fine regulators for gene expression during the post-transcriptional stage in many autoimmune diseases.HypoxamiRs(miR-210 and miR-21)play an important role in hypoxia and in inflammation-associated hypoxia.Systemic lupus erythematosus(SLE)is a chronic systemic autoimmune disease that would potentiate many pathological complications,including hemolytic anemia.This study aimed to investigate the role of hypoxamiRs in SLE/hemolytic anemia patients.Methods This work was designed to analyze the circulating levels of↱the miR-210 and miR-21 expressions and hypoxia-inducible factor-1α(HIF-α)in SLE/hemolytic anemia patients.SLE activity was evaluated for all patients by SLE Disease Activity Index(SLEDAI).Clinical manifestations/complications and serological/hematological investigations were reported.HIF-αconcentration was assayed by ELISA and expression of miR-21 and miR-210 was analyzed by qRT-PCR.Results The results indicated that the fold change of the miR-210/miR-21 expressions in plasma was significantly elevated in SLE/hemolytic anemia patients.A strong positive correlation between the miR-210 and miR-21 expression levels was also recorded.Among the associated-disease complications,hypertension,arthritis,oral ulcers,and serositis were associated with a high circulating miR-210 expression,while the occurrence of renal disorders was associated with the increased miR-21 expression.Furthermore,the HIF-αlevel was remarkably elevated in SLE/hemolytic anemia patients.A high positive correlation was recorded between the HIF-αconcentration and miR-210/miR-21 expression levels.The occurrence of oral ulcers,arthritis,and hypertension was associated with the increased HIF-αconcentration.On the other hand,SLEDAI and white blood cell count were positively correlated with miR-21/miR-210.The erythrocyte sedimentation rate was positively correlated with miR-21.Conclusion The dysregulation of the circulating miR-210/miR-210/HIF-1αlevels in SLE/hemolytic anemia patients advocated that the hypoxia pathway might have an essential role in the pathogenesis and complications of these diseases.

An analysis approach of mass and energy balance in a dual-reactor circulating fluidized bed system

An analysis approach considering gas-solids hydrodynamics,reaction kinetics and reacting species nonuniformity together in a dual-reactor system is presented for better understanding its mass and energy balance.It was achieved by a 3-dimensional comprehensive hydrodynamics and reaction model for the dual-reactor system,which was developed from the successfully verified 3-dimensional comprehensive combustion model for one circulating fluidized bed(CFB)system(Xu and Cheng,2019).The developed model and analysis approach was successfully used on a 1 MW circulating fluidized bed–bubbling fluidized bed(CFB-BFB)dual-reactor system.Results showed the sensible and chemical energy between two reactors as well as the energy distributions in each reactor were balanced and they agreed well with the experimental measurements.The analysis approach indicated energy balance had a close relationship with the mass transfer in the CFB-BFB dual-reactor system.It may be applied in a design and operation optimization for a dual-reactor system.

MIC in Circulating Cooling Water System

MIC is one of the main problems of circulating cooling water system. The direct economic loss by MIC is about 300 to 500 billion dollars. It is good to understand MIC in order to control MIC. Source and species of microorganisms was introduced firstly. There are three kinds of microorganisms in the system, including bacteria, fungi and algae. Species of these microorganisms are shown in the paper. Then, mechanisms of MIC are analysed. Although there is no universal mechanism of MIC, MIC is still mainly an electrochemical corrosion in nature. Meanwhile, the mechanisms on SRB and iron bacteria are introduced in details. At last, several methods of microorganisms control are put forward in the paper.

Laccase Immobilized on Mesoporous Silica Materials and Its Corrosion Inhibition Performance in Circulating Cooling Water System

Mesoporous SiO_2 microspheres were synthesized using the sol-gel method and were characterized by TEM, FT-IR and BET techniques. The diameter of the microspheres is about 100—150 nm, and the average mesopore diameter is 2.55 nm, while the specific surface area is 1 088.9 m2/g. Mesoporous SiO_2 microspheres adsorb glutaraldehyde and immobilize laccase by means of the aldehyde group in glutaral which can react with the amidogen of laccase. The immobilization conditions were optimized at a glutaraldehyde concentration of 0.75%, a crosslinking time of 8 h, a laccase concentration of 0.04 L/L and an immobilization time of 10 h. When diesel leakage concentration was 80 mg/L, the highest corrosion inhibition efficiency of immobilized laccase reached 49.23%, which was slightly lower than the corrosion inhibition efficiency of free laccase(59%). The diesel degradation ratio could reach up to 45%. It has been proved that the immobilized laccase could degrade diesel to inhibit corrosion.

Circulating tumor DNA in liquid biopsy: Current diagnostic limitation

With the rapid development of science and technology,cell-free DNA(cfDNA)is rapidly becoming an important biomarker for tumor diagnosis,monitoring and prognosis,and this cfDNA-based liquid biopsy technology has great potential to become an important part of precision medicine.cfDNA is the total amount of free DNA in the systemic circulation,including DNA fragments derived from tumor cells and all other somatic cells.Tumor cells release fragments of DNA into the bloodstream,and this source of cfDNA is called circulating tumor DNA(ctDNA).cfDNA detection has become a major focus in the field of tumor research in recent years,which provides a new opportunity for non-invasive diagnosis and prognosis of cancer.In this paper,we discuss the limitations of the study on the origin and dynamics analysis of ctDNA,and how to solve these problems in the future.Although the future faces major challenges,it also con-tains great potential.

Exercise training mode effects on myokine expression in healthy adults:A systematic review with meta-analysis

Background:The benefits of exercise are well known;however,many of the underlying molecular mechanisms are not fully understood.Skeletal muscle secretes myokines,which mediate muscleorgan crosstalk.Myokines regulate satellite-cell proliferation and migration,inflammatory cascade,insulin secretion,angiogenesis,fatty oxidation,and cancer suppression.To date,the effects of different exercise modes(namely,aerobic and resistance exercise)on myokine response remain to be elucidated.This is crucial considering the clinical implementation of exercise to enhance general health and wellbeing and as a medical treatment.Methods:A systematic search was undertaken in PubMed,MEDLINE,CINAHL,Embase,SPORTDiscus,andWeb of Science in April 2023.Eligible studies examining the effects of a single bout of exercise on interleukin15(IL-15),irisin,secreted protein acidic and rich in cysteine(SPARC),oncostatinM(OSM),and decorin were included.A random-effects meta-analysis was also undertaken to quantify the magnitude of change.Results:Sixty-two studies were included(n=1193).Overall,exercise appeared to induce small to large increases in myokine expression,with effects observed immediately after to 60 min post-exercise,although these were mostly not statistically significant.Both aerobic and resistance exercise resulted in changes in myokine levels,without any significant difference between training modes,and with the magnitude of change differing across myokines.Myokine levels returned to baseline levels within 180 min to 24 h post-exercise.However,owing to potential sources of heterogeneity,most changes were not statistically significant,indicating that precise conclusions cannot be drawn.Conclusion:Knowledge is limited but expanding with respect to the impact of overall and specific effects of exercise on myokine expression at different time points in the systemic circulation.Further research is required to investigate the effects of different exercise modes at multiple time points on myokine response.

Is it possible to block the cancer cells in circulating blood by extracorporeal circulation? Implications of the immune system and other factors (review)

The presence of cancer cells in circulating blood and the possibility of colonization in the tissues of the body worsen in a determinant way the prognosis of the disease. Nevertheless, there are factors in the body that can lead to a prognostic improvement, even in such conditions. In addition to the immune system, other favorable factors can act at the level of the microenvironment of the tumor so much that cases of spontaneous total regression, not only of primary tumors but also metastases, have been reported in the literature. Since it was recently reported that patients with renal tumors and in permanent hemodialysis present at post mortem examination, a metastatic spread much less extensive than observed in patients deceased for renal tumors but not on hemodialysis. The authors maintain it likely that the dialytic membrane concurs to block at least in part the cancer cells circulating in the blood. The possibility to block cancer cells can be extended in addition to the dialytic membrane also to other types of filters inserted in the extracorporeal circulation. The block of the cancer cells thus is obtained and that occurs in regional lymph nodes and in the microenvironment of the tumor causing a relative increase in the elements of the immune system compared to the number of cancer cells, which could determine clearly positive therapeutic results also in cases with advanced metastatic spread.

Circulating tumor DNA and its role in detection, prognosis and therapeutics of hepatocellular carcinoma

Hepatocellular carcinoma(HCC) is considered the fifth most prevalent cancer among all types of cancers and has the third most morbidity value. It has the most frequent duplication time and a high recurrence rate. Recently, the most unique technique used is liquid biopsies, which carry many markers;the most prominent is circulating tumor DNA(ctDNA). Varied methods are used to investigate ctDNA, including various forms of polymerase chain reaction(PCR) [emulsion PCR(ePCR), digital PCR(dPCR), and bead, emulsion, amplification, magnetic(BEAMing) PCR]. Hence ctDNA is being recognized as a potential biomarker that permits early cancer detection,treatment monitoring, and predictive data on tumor burden are subjective to therapy or surgery. Numerous ctDNA biomarkers have been investigated based on their alterations such as 1) single nucleotide variations(either insertion or deletion of a nucleotide) markers including TP53, KRAS, and CCND1;2) copy number variations which include markers such as CDK6, EFGR, MYC and BRAF;3) DNA methylation(RASSF1A, SEPT9, KMT2C and CCNA2);4) homozygous mutation includes ctDNA markers as CDKN2A, AXIN1;and 5) gain or loss of function of the genes, particularly for HCC. Various researchers have conducted many studies and gotten fruitful results.Still, there are some drawbacks to ctDNA namely low quantity, fragment heterogeneity, less stability, limited mutant copies and standards, and differential sensitivity. However, plenty of investigations demonstrate ctDNA's significance as a polyvalent biomarker for cancer and can be viewed as a future diagnostic, prognostic and therapeutic agent. This article overviews many conditions in genetic changes linked to the onset and development of HCC, such as dysregulated signaling pathways, somatic mutations, single-nucleotide polymorphisms, and genomic instability. Additionally, efforts are also made to develop treatments for HCC that are molecularly targeted and to unravel some of the genetic pathways that facilitate its early identification.

Simulation of gas-solid flow characteristics of the circulating fluidized bed boiler under pure-oxygen combustion conditions

Under the pressure of carbon neutrality,many carbon capture,utilization and storage technologies have witnessed rapid development in the recent years,including oxy-fuel combustion(OFC)technology.However,the conventional OFC technology usually depends on the flue gas recirculation system,which faces significant investment,high energy consumption,and potential low-temperature corrosion problem.Considering these deficiencies,the direct utilization of pure oxygen to achieve particle fluidization and fuel combustion may reduce the overall energy consumption and CO_(2)-capture costs.In this paper,the fundamental structure of a self-designed 130 t·h^(-1) pure-oxygen combustion circulating fluidized bed(CFB)boiler was provided,and the computational particle fluid dynamics method was used to analyze the gas-solid flow characteristics of this new-concept boiler under different working conditions.The results indicate that through the careful selection of design or operational parameters,such as average bed-material size and fluidization velocity,the pure-oxygen combustion CFB system can maintain the ideal fluidization state,namely significant internal and external particle circulation.Besides,the contraction section of the boiler leads to the particle backflow in the lower furnace,resulting in the particle suspension concentration near the wall region being higher than that in the center region.Conversely,the upper furnace still retains the classic core-annulus flow structure.In addition to increasing solid circulation rate by reducing the average bed-material size,altering primary gas ratio and bed inventory can also exert varying degrees of influence on the gas-solid flow characteristics of the pure-oxygen combustion CFB boiler.

Experimental study on secondary air mixing along the bed height in a circulating fluidized bed with a multitracer-gas method

A multitracer-gas method was proposed to study the secondary air(SA)mixing along the bed height in a circulating fluidized bed(CFB)using carbon monoxide(CO),oxygen(O_(2)),and carbon dioxide(CO_(2))as tracer gases.Experiments were carried out on a cold CFB test rig with a cross-section of 0.42 m×0.73 m and a height of 5.50 m.The effects of superficial velocity,SA ratio,bed inventory,and particle diameter on the SA mixing were investigated.The results indicate that there are some differences in the measurement results obtained using different tracer gases,wherein the deviation between CO and CO_(2) ranges from 42%to 66%and that between O_(2) and CO_(2) ranges from 45%to 71%in the lower part of the fluidized bed.However,these differences became less pronounced as the bed height increased.Besides,the high solid concentration and fine particle diameter in the CFB may weaken the difference.The measurement results of different tracer gases show the same trends under the variation of operating parameters.Increasing superficial velocity and SA ratio and decreasing particle diameter result in better mixing of the SA.The effect of bed inventory on SA mixing is not monotonic.

Particle residence time distribution and axial dispersion coefficient in a pressurized circulating fluidized bed by using multiphase particle-in-cell simulation

The particle residence time distribution(RTD)and axial dispersion coefficient are key parameters for the design and operation of a pressurized circulating fluidized bed(PCFB).In this study,the effects of pressure(0.1-0.6 MPa),fluidizing gas velocity(2-7 m·s^(-1)),and solid circulation rate(10-90 kg·m^(-2)·s^(-1))on particle RTD and axial dispersion coefficient in a PCFB are numerically investigated based on the multiphase particle-in-cell(MP-PIC)method.The details of the gas-solid flow behaviors of PCFB are revealed.Based on the gas-solid flow pattern,the particles tend to move more orderly under elevated pressures.With an increase in either fluidizing gas velocity or solid circulation rate,the mean residence time of particles decreases while the axial dispersion coefficient increases.With an increase in pressure,the core-annulus flow is strengthened,which leads to a wider shape of the particle RTD curve and a larger mean particle residence time.The back-mixing of particles increases with increasing pressure,resulting in an increase in the axial dispersion coefficient.

Desulfurization characteristics of slaked lime and regulation optimization of circulating fluidized bed flue gas desulfurization process--A combined experimental and numerical simulation study

Circulating fluidized bed flue gas desulfurization(CFB-FGD) process has been widely applied in recent years. However, high cost caused by the use of high-quality slaked lime and difficult operation due to the complex flow field are two issues which have received great attention. Accordingly, a laboratory-scale fluidized bed reactor was constructed to investigate the effects of physical properties and external conditions on desulfurization performance of slaked lime, and the conclusions were tried out in an industrial-scale CFB-FGD tower. After that, a numerical model of the tower was established based on computational particle fluid dynamics(CPFD) and two-film theory. After comparison and validation with actual operation data, the effects of operating parameters on gas-solid distribution and desulfurization characteristics were investigated. The results of experiments and industrial trials showed that the use of slaked lime with a calcium hydroxide content of approximately 80% and particle size greater than 40 μm could significantly reduce the cost of desulfurizer. Simulation results showed that the flow field in the desulfurization tower was skewed under the influence of circulating ash. We obtained optimal operating conditions of 7.5 kg·s^(-1)for the atomized water flow, 70 kg·s^(-1)for circulating ash flow, and 0.56 kg·s^(-1)for slaked lime flow, with desulfurization efficiency reaching 98.19% and the exit flue gas meeting the ultraclean emission and safety requirements. All parameters selected in the simulation were based on engineering examples and had certain application reference significance.

Causal relationship between circulating vitamin C and 25-hydroxyvitamin D concentrations and common mental disorders-a Mendelian randomization study

Mental disorders seriously affect people’s health and social stability.This Mendelian randomization(MR)study was designed to investigate the causal relationship between circulating vitamin C(VC)or 25-hydroxyvitamin D(25(OH)D)levels and mental disorders.The data used for the MR analysis were derived from the summary genome-wide association studies(GWAS)database for VC and 25(OH)D and from the Finn Gen consortium for fourteen mental disorders.Based on the inverse variance weighted(IVW)method,we found a potential causal association between circulating VC and anxiety disorders(IVW:OR=1.139,95%CI:1.023-1.269,P=0.018).However,no causal association was found between VC or 25(OH)D and other mental disorders(P>0.05).In the reverse MR analysis,individuals with Alzheimer’s disease was causally associated with higher concentrations of circulating VC(P=0.012),while individuals with anxiety disorders had a negative association between the concentrations of 25(OH)D(P=0.012).However,the current evidence does not support a causal relationship between VC or 25(OH)D and other mental disorders.In addition,there was no causal association between circulating VC and 25(OH)D(P>0.05).Future studies are needed to confirm these findings and to elucidate the mechanisms of potential causality.

In vivo fluorescence flow cytometry reveals that the nanoparticle tumor vaccine OVA@HA-PEI effectively clears circulating tumor cells

Tumor vaccine therapy offers significant advantages over conventional treatments,including reduced toxic side effects.However,it currently functions primarily as an adjuvant treatment modality in clinical oncology due to limitations in tumor antigen selection and delivery methods.Tumor vaccines often fail to elicit a sufficiently robust immune response against progressive tumors,thereby limiting their clinical efficacy.In this study,we developed a nanoparticle-based tumor vaccine,OVA@HA-PEI,utilizing ovalbumin(OVA)as the presenting antigen and hyaluronic acid(HA)and polyethyleneimine(PEI)as adjuvants and carriers.This formulation significantly enhanced the proliferation of immune cells and cytokines,such as CD3,CD8,interferon-,and tumor necrosis factor-,in vivo,effectively activating an immune response against B16–F10 tumors.In vivofluorescenceflow cytometry(IVFC)has already become an effective method for monitoring circulating tumor cells(CTCs)due to its direct,noninvasive,and long-term detection capabilities.Our study utilized a laboratory-constructed IVFC system to monitor the immune processes induced by the OVA@HA-PEI tumor vaccine and an anti-programmed death-1(PD-1)antibody.The results demonstrated that the combined treatment of OVA@HA-PEI and anti-PD-1 antibody significantly improved the survival time of mice compared to anti-PD-1 antibody treatment alone.Additionally,this combination therapy substantially reduced the number of CTCs in vivo,increased the clearance rate of CTCs by the immune system,and slowed tumor progression.Thesefindings greatly enhance the clinical application prospects of IVFC and tumor vaccines.