Long-term operation optimization of circulating cooling water systems under fouling conditions

Fouling caused by excess metal ions in hard water can negatively impact the performance of the circulating cooling water system(CCWS)by depositing ions on the heat exchanger's surface.Currently,the operation optimization of CCWS often prioritizes short-term flow velocity optimization for minimizing power consumption,without considering fouling.However,low flow velocity promotes fouling.Therefore,it's crucial to balance fouling and energy/water conservation for optimal CCWS long-term operation.This study proposes a mixed-integer nonlinear programming(MINLP)model to achieve this goal.The model considers fouling in the pipeline,dynamic concentration cycle,and variable frequency drive to optimize the synergy between heat transfer,pressure drop,and fouling.By optimizing the concentration cycle of the CCWS,water conservation and fouling control can be achieved.The model can obtain the optimal operating parameters for different operation intervals,including the number of pumps,frequency,and valve local resistance coefficient.Sensitivity experiments on cycle and environmental temperature reveal that as the cycle increases,the marginal benefits of energy/water conservation decrease.In periods with minimal impact on fouling rate,energy/water conservation can be achieved by increasing the cycle while maintaining a low fouling rate.Overall,the proposed model has significant energy/water saving effects and can comprehensively optimize the CCWS through its incorporation of fouling and cycle optimization.

Pressure fluctuation and its influencing factors in circulating water pump

In order to investigate the effect of sampling frequency and time on pressure fluctuations, the three-dimensional unsteady numerical simulations were conducted in a circulating water pump. Through comparison of turbulence models with hydraulic performance experiment, SST k-co model was confirmed to study the rational determination of sampling frequency and time better. The Fast Fourier Transform （FFT） technology was then adopted to process those fluctuating pressure signals obtained. On these bases, the characteristics of pressure fluctuations acting on the tongue were discussed. It is found that aliasing errors decrease at higher sampling frequency of 17 640 Hz, but not at a lower sampling frequency of 1 764 Hz. Correspondingly, an output frequency range ten-times wider is obtained at 17 640 Hz. Compared with 8R, when the sampling time is shorter, the amplitudes may be overvalued, and the frequencies and amplitudes of low-frequency fluctuations can not be well predicted. The frequencies at the tongue are in good agreement with the values calculated by formula and the frequency compositions less than the blade passing frequency are accurately predicted.

Optimization of circulating cooling water systems based on chance constrained programming

Recent research on deterministic methods for circulating cooling water systems optimization has been well developed. However, the actual operating conditions of the system are mostly variable, so the system obtained under deterministic conditions may not be stable and economical. This paper studies the optimization of circulating cooling water systems under uncertain circumstance. To improve the reliability of the system and reduce the water and energy consumption, the influence of different uncertain parameters is taken into consideration. The chance constrained programming method is used to build a model under uncertain conditions, where the confidence level indicates the degree of constraint violation. Probability distribution functions are used to describe the form of uncertain parameters. The objective is to minimize the total cost and obtain the optimal cooling network configuration simultaneously.An algorithm based on Monte Carlo method is proposed, and GAMS software is used to solve the mixed integer nonlinear programming model. A case is optimized to verify the validity of the model. Compared with the deterministic optimization method, the results show that when considering the different types of uncertain parameters, a system with better economy and reliability can be obtained(total cost can be reduced at least 2%).

Uncertainty Analysis for Ship-Bank Interaction Tests in A Circulating Water Channel

This paper presents a systematic model test program to assess the uncertainty of the ship-bank interaction forces,using the planar motion mechanism(PMM)system in a circulating water channel(CWC).Therefore,the uncertainties due to ship-bank distance and water depth are considered,and they are calculated via the partial differentials of the regression formulae based on the test data.The general part of the uncertainty analysis(UA)is performed according to the ITTC recommended procedure 7.5-02-06.04,while the uncertainty of speed is identified as the bias limit due to the flow velocity maldistribution in the CWC.In each example test for the UA of ship-bank interaction forces,12 repeated measurements were conducted.Results from the UA show that the contribution of water depth error and flow velocity maldistribution to the total uncertainty is noticeable,and the paper explains how they increase with the change of the test conditions.The present study will be useful in understanding the uncertainty regarding the ship-bank interaction force measurement in a CWC.

Laccase Immobilized on Mesoporous Silica Materials and Its Corrosion Inhibition Performance in Circulating Cooling Water System

Mesoporous SiO_2 microspheres were synthesized using the sol-gel method and were characterized by TEM, FT-IR and BET techniques. The diameter of the microspheres is about 100—150 nm, and the average mesopore diameter is 2.55 nm, while the specific surface area is 1 088.9 m2/g. Mesoporous SiO_2 microspheres adsorb glutaraldehyde and immobilize laccase by means of the aldehyde group in glutaral which can react with the amidogen of laccase. The immobilization conditions were optimized at a glutaraldehyde concentration of 0.75%, a crosslinking time of 8 h, a laccase concentration of 0.04 L/L and an immobilization time of 10 h. When diesel leakage concentration was 80 mg/L, the highest corrosion inhibition efficiency of immobilized laccase reached 49.23%, which was slightly lower than the corrosion inhibition efficiency of free laccase(59%). The diesel degradation ratio could reach up to 45%. It has been proved that the immobilized laccase could degrade diesel to inhibit corrosion.

Removal of kathon by UV-C activated hydrogen peroxide:Kinetics,mechanisms,and enhanced biodegradability assessment

Kathon(CMI-MI),a mixture of 5-chloro-2-methyl-4-isothiazolin-3-one(CMI)and 2-methyl-4-isothiazolin-3-one(MI),was extensively used in industry as a nonoxidizing biocide or disinfectant.However,it would show adverse effects on aquatic life when it is discharged into surface water.In this study,the removal performance,parameter influence,degradation products and enhancement of subsequent biodegradation of CMI-MI in UV/H_(2)O_(2)system were systematically investigated.The degradation rate of CMI-MI could reach 90%under UV irradiation for 20 min when the dosage of H_(2)O_(2)was 0.3 mmol·L^(–1).The DOC(dissolved organic carbon)mineralization rate of CMI-MI could reach 35%under certain conditions([H_(2)O_(2)]=0.3 mmol·L^(–1),UV irradiation for 40 min).kobs was inversely proportional to the concentration of CMI-MI and proportional to the concentration of H_(2)O_(2).The degradation rate of CMIMI was almost unchanged in the pH range from 4 to 10.Except the presence of CO_(3)^(2-)inhibited the removal rate of CMI-MI,SO_(4)^(2-),Cl^(-),NO_(3)^(-),and NH_(4)^(+) did not interfere with the degradation of CMI-MI in the system.It was found that UV/H_(2)O_(2)system had lower energy consumption and more economic advantage compared with UV/PS system by comparing the EEO(electric energy per order)values under the same conditions.Two main organic products were identified,namely HCOOH and CH_(3)NH_(2).There’s also the formation of Cl^(-)and SO_(4)^(2-).After UV and UV/H_(2)O_(2)photolysis,the biochemical properties of CMI-MI solution were obviously improved,especially the UV/H_(2)O_(2)treatment effect was better,indicating that UV/H_(2)O_(2)technology is expected to combine with biotechnology to remove CMI-MI effectively and environmentally friendly from wastewater.

A modified Hoek-Brown failure criterion considering the damage to reservoir bank slope rocks under water saturation-dehydration circulation

After water is impounded in a reservoir, rock mass in the hydro-fluctuation belt of the reservoir bank slope is subject to water saturation- dehydration circulation （WSDC）. To quantify the rate of change of rock mechanical properties, samples from the Longtan dam area were measured with uniaxial compression tests after different numbers （1, 5, 10, 15, and 20） of simulated WSDC cycles. Based on the curves derived from these tests, a modified Hock- Brown failure criterion was proposed, in which a new parameter was introduced to model the cumulative damage to rocks after WSDC. A case of an engineering application was analyzed, and the results showed that the modified Hock-Brown failure criterion is useful. Under similar WSDC-influenced engineering and geological conditions, rock mass strength parameters required for analysis and evaluation of rock slope stability can be estimated according to this modified Hoek-Brown failure criterion.

On the heat budget and water mass exchange in the Andaman Sea

The characteristics of the T/S structures,water mass exchange and deep circulation in the Andaman Sea are investigated based on the simulation from a high-resolution general circulation model(MITgcm).The results show that,below 1000 m,the water mass is saltier,warmer and more homogeneous in the Andaman Sea than that in the Bay of Bengal,attributing to the strong vertical mixing at the depth of^1800 m.The water mass exchange between the Andaman Sea and the Bay of Bengal goes through three major channels,which manifests itself as follows:the northern channel(Preparis Channel)is the main passage of water mass transport from the Bay of Bengal to the Andaman Sea,whereas the Middle Channel(the south of Andaman Islands and the north of Nicobar Islands)has an opposite transport;the southern channel(Great Channel)features with a four-layer water exchange which results in the least net transport among the three channels;all the transports through the three channels have an intra-annual variation with a period of half a year.At 1000-m depth,the entire Andaman Sea is occupied by a cyclonic circulation in January and July while by an anticyclonic one in April and October.The semiannual cycle found in both the deep circulation and water mass exchange is likely associated with the downwelling eastward-propagating Kelvin waves induced by the semiannual westerly component in the equatorial Indian Ocean during intermonsoon seasons.

The Studies of Regional Water Circulation Patterns in the Yerqiang River Basin

Based on the characteristic of ‘one river one oasis’ in the arid areas, the Yerqiang River Basin, which is the largest irrigated area of Xinjiang, is taken as an example in this paper, and the regional water circulation pattern is investigated through the analysis of 60 groups of isotope data in the basin. From the phreatic evaporation data analysis of different soils, we study the law of phreatic evaporation, complete the research of the main consumption path of the groundwater, and improve the assessment precision of water resources. The transformation mount of regional water resources are predicted by calculation, which provides a scientific basis for water resources assessment and allocation in arid regions, and offers a new method for the study of regional water circulation patterns.

Exploration on compound water circulation system to solve water resources problems of North China Plain

In order to solve water resources problems in the North China Plain, this paper explored human-nature compound water circulation system from three aspects including urban flood control, surface drainage and saline water in the central and eastern of the North China Plain. Results show that:(1) The technical methods have achieved zero increase in rainwater runoff in urban areas,(2) surface drainage depletion problems can be solved through abandoned water and river water separation method,(3) and technical method through promoting rainwater infiltration would be used to solve problem of saline water in the central and eastern parts. This research provides a new perspective to the ultimate solutions to water resources problems in the North China Plain, and a fresh research direction for the development of hydro-geological science.

A STUDY ON FIELD WATER CIRCULATION PATTERN IN THE DRYLAND OF NORTHERN CHINA

Based on the observed data of soil moisture from locating experiments from 1986 to 1990, the pattern of field water circulation in dryland of northern China, where the mean annual precipitation is 300 600 mm, is studied in this paper using the method of water balance. The results show that water satisfying ratio of spring seeding crops is 83.7 90.8 percent and that of winter wheat is about 70 percent in these areas; about 80 90 percent of water consumption of spring seeding crops and about 60 70 percent of water consumption of winter wheat comes from precipitation during the growing period, the rest comes from the soil water storage before the seeding period. But the available soil water is not used thoroughly, about 30 70 percent of available soil water remains unused when the crops are harvested. At the fallow period, the amount of soil water lost by evaporation is very important, which takes up 57 68 percent of precipitation in winter wheat field and 73 244 percent in field of spring seeding crops. Thus restraining soil evaporation, raising the storage ratio of natural precipitation and the soil water utilization efficiency of crops, strengthening the circulation ability of soil water by adopting efficient measures of agricultural techniques, are the main ways for exploiting and developing the potential productivity of natural precipitation in these areas.

Reclamation and reuse of distributed wastewater and programming based on cost analysis

In order to improve the water environment of Songhua River,develop and maintain a healthy water cycle,the article has made theoretical and mathematical analyses of wastewater treatment and reuse.It proposes that the important link of sustainable utilization of urban water resources is wastewater treatment and reuse,and the main approach of sustainable utilization of water resources is water saving,wastewater reclamation and reuse.Through establishing the cost equation of recycle water system and optimizing it by Matlab,an optimal treatment scale of the city recycle distributed wastewater system is obtained.The principles of recycle water system in northern areas are put forward based on the research of sustainable utilization of water resource in Songbei district.The results can provide experiences and references for water saving,wastewater reclamation and reuse in northern cities of China.

Gravitational effect of water circulation in the northwest Yunnan

Water circulation is the main disturbance source against precise gravimetry measurement which is one of the principal means of geodynamic study. Some scientists studied the disturbance of water level changes in lakes andrivers and groundwater activities on gravity field.Taking water circulation as a whole and combining it with thehydrogeological conditions in northwest Yunnan mountainous area and the measured gravity data,this paperstudies the features, connections of water circulation in atmosphere,on surface and under ground and its effecton gravimetric data. The main conclusions are as follows: 1) The water circulation in atmosphere has little directdisturbance on gravity field 1 2 ) The change of lake water level may cause gravitational effect of (10- 20) × 10-8m. s-2 ; 3) In the NW Yunnan, types of the groundwater are various,and its changes are complicated, it isnecessary to study point by point. In general, its disturbance on gravity field in this region is about 10 × 10- 8m. s- 2, less than that in plain area.

A Numerical Study of Water Circulation in A Thermally Stratified Embayment

Princeton Ocean Model is used to study the response of Jervis Bay, NSW, Australia, to the local wind and remote shelf coastal trapped wave (CTW) forcings in summer seasons when the water column is stratified by the water temperature.The study has revealed that the response of bay to the wind forcing is the generation of the wind driven currents and the internal Kelvin waves (IKW). However, both temperature and flow sub-inertial oscillations in the bay are weaker than those from the observations and the correlation between the modeled and observed low frequency currents is low. In response to the forcing of CTWs on the adjacent shelf, IKWs are also established in the bay and amplitudes of sub-inertial oscillations of temperature and currents agree better with the observations. It can be concluded that sub-inertial baroclinic flows in the bay is dominantly forced by remote CTW on the shelf adjacent to Jervis Bay during thermally stratified summer seasons.

Heart of Landscape and Contribution of Building Environment: Discussions about Landscape Construction of Outdoor Environment Water Circulation System

Recently, the increasing concern about the environmental quality of human settlements makes people realize that the attractive environment given by natural ecology also deficiently needs the feedback and protection of nature in some forms so that the natural ecology can be endlessly cycled on its own. Taking the project of German Enterprise Center in Qingdao Sino-German Ecopark as an example, this paper discussed construction of outdoor environment water circulation system using the landscape building method.

Estimation of the Hydrodynamic Regime of the Water Movement under the Influence of the Atmospheric Processes in the Bering Sea and the Sea of Okhotsk

The given investigation presents the results of estimating the water circulation in the water area of the Bering Sea and the Sea of Okhotsks, considering the influence of various types of the atmospheric processes. To solve the given problem it is used a hydrodynamic model calculating the integral functions of the flow from the surface to the bottom. By results of calculations, the maps of the integral water circulation were built for the following types of atmospheric circulation： ＂north-western＂ and ＂okhotsk-aleutian＂. In accordance with the performed calculations for the water area being studied, the hydrodynamic structures are distinguished both non-depending and depending on the type of the atmospheric circulation. The non-depending structures are characterized by the cyclonic activity in the Bering Sea and the Sea of Okhotsk in whole. Hydrodynamic structures depending on types of the atmospheric circulation have their peculiarities in the spatial-temporal distribution.

Pacific-Indian interocean circulation of the Antarctic Intermediate Water around South Australia

On the basis of the salinity distribution of isopycnal（σ_0=27.2 kg/m^3） surface and in salinity minimum, the Antarctic Intermediate Water（AAIW） around South Australia can be classified into five types corresponding to five regions by using in situ CTD observations. Type 1 is the Tasman AAIW, which has consistent hydrographic properties in the South Coral Sea and the North Tasman Sea. Type 2 is the Southern Ocean（SO） AAIW, parallel to and extending from the Subantarctic Front with the freshest and coldest AAIW in the study area. Type 3 is a transition between Type 1 and Type 2. The AAIW transforms from fresh to saline with the latitude declining（equatorward）. Type 4, the South Australia AAIW, has relatively uniform AAIW properties due to the semienclosed South Australia Basin. Type 5, the Southeast Indian AAIW, progressively becomes more saline through mixing with the subtropical Indian intermediate water from south to north. In addition to the above hydrographic analysis of AAIW, the newest trajectories of Argo（Array for real-time Geostrophic Oceanography） floats were used to constructed the intermediate（1 000 m water depth） current field, which show the major interocean circulation of AAIW in the study area. Finally, a refined schematic of intermediate circulation shows that several currents get together to complete the connection between the Pacific Ocean and the Indian Ocean. They include the South Equatorial Current and the East Australia Current in the Southwest Pacific Ocean, the Tasman Leakage and the Flinders Current in the South Australia Basin, and the extension of Flinders Current in the southeast Indian Ocean.

循环水通道阻塞效应对自主水下航行器水动力系数估算的影响

The Reynolds-averaged Navier–Stokes(RANS)equation was solved using computational fluid dynamics to study the effect of the circulating tank wall on the hydrodynamic coefficient of an autonomous underwater vehicle(AUV).Numerical results were compared with the experimental results in the circulating water tank of Harbin Engineering University.The numerical results of the model with different scale ratios under the same water in the flume were studied to investigate the effect of blockage on the hydrodynamic performance of AUV in the circulating flume model test.The results show that the hydrodynamic coefficient is stable with the scale reduction of the model.The influence of blocking effect on AUV is given by combining theoretical calculation with experiment.

A Lagrangian mean theory on coastal sea circulation with inter-tidal transports I.Fundamentals

A brief review is made on the theory of the Lagrangian residual circulation and inter-tidal transports in a convectively weakly nonlinear system. In the review the emphasis is put on the systematical development of the theory and its weakness of convectively weakly nonlinear approximation. The fundamentals of a Lagrangian tidally-averaged theory on circulation with inter-tidal transport processes have been proposed for a general nonlinear coastal/estuarine system. The Lagrangian residual velocity is strictly de- fined, and it has been verified to be able to embody the velocity field of circulation. A new concept of the concentration for inter- tidal transport processes is presented. The concentration describing the inter-tidal transport processes should be a ＂Lagrangian inter-tidal concentration＂ defined and named, but not the Eulcrian tidally-averaged concentration used traditionally. The circulation described here contains a set of infinite temporal-spatial fields of velocity/concentration, each of which corresponds to a specific value of tidal phases varying continuously over one tidal cycle. When the convectively weakly nonlinear condition（ with a smaller order of eddy diffusion and sources） is approximately satisfied, a set of infinite temporal-spatial fields of velocity/concentration can be reduced to a single one.. the mass transport velocity/the Eulerian tidally averaged concentration as exhibited traditionally.