The performance of a rotating packed bed （RPter solutioB） with three kinds of packings was investigated using alcohol/wan under continuous distillation conditions at atmospheric pressure. The effects of average high...The performance of a rotating packed bed （RPter solutioB） with three kinds of packings was investigated using alcohol/wan under continuous distillation conditions at atmospheric pressure. The effects of average high gravity factor （β）, reflux ratio （R）, and feedstock flux （F） on mass-transfer in distillation were examined separately. Experimental results indicated that the total number of theoretical units （NTU） of RPB increased with β, R, and F.Of the three kinds of packings, the wave thread packing of stainless steel （Packing-Ⅲ）-had the best mass transfer efficiency with the height equivalent of a theoretical plate （HETP） of approximately 7.35 mm- 23.58 ram, whereas the corrugated disk pacing of stainless steel,（Packing Ⅰ） had the worst one with the HETP of about 13.4 mm-48.07 mm.Correlations were cleveloped to describe the mass transfer efficiency for packings Comparing.experimental data with the data calculated by correlation, the average deviate obtained for each packing was 0.72%, 1.98%, and 2.7%, respectively, implying that the accuracy of correlations developed was reasonable.展开更多
Continuous homogenous azeotropic distillation(CHAD) and pressure-swing distillation(PSD) are explored to separate a minimum-boiling azeotropic system of ethyl acetate and n-hexane. The CHAD process with acetone as the...Continuous homogenous azeotropic distillation(CHAD) and pressure-swing distillation(PSD) are explored to separate a minimum-boiling azeotropic system of ethyl acetate and n-hexane. The CHAD process with acetone as the entrainer and the PSD process with the pressures of 0.1 MPa and 0.6 MPa in two columns are designed and simulated by Aspen Plus. The operating conditions of the two processes are optimized via a sequential modular approach to obtain the minimum total annual cost(TAC). The computational results show that the partially heat integrated pressure-swing distillation(HIPSD) has reduced in the energy cost and TAC by 40.79% and 35.94%, respectively, than the conventional PSD, and has more greatly reduced the energy cost and TAC by 62.61% and 49.26% respectively compared with the CHAD process. The comparison of CHAD process and partially HIPSD process illustrates that the partially HIPSD has more advantages in averting the product pollution, energy saving, and economy.展开更多
The hydrochloric acid recovery from rare earth chloride solutions by continuous vacuum membrane distillation was first experimentally studied, then material balance of the process was calculated, and the equations whi...The hydrochloric acid recovery from rare earth chloride solutions by continuous vacuum membrane distillation was first experimentally studied, then material balance of the process was calculated, and the equations which mathematically stimulate the process were lastly achieved. The results indicate a given RE concentration in circular solutions means its constant HCl concentration during the continuous VMD process, furthermore, increasing RE concentration in feed solutions increases the processing capacity per membrane of the experimental set-up. When keeping constant RE concentration in feed solutions, increasing RE concentration in circular solutions decreases its HCl concentration, and HCl recovery ratio increases accordingly, however, processing capacity per membrane of the experimental set-up decreases at the same time. The mathematical results are in accordance with experimental results.展开更多
The integration of the photocatalytic effect into solar steam is highly desirable for addressing freshwater shortages and water pollution.Here,a ternary film structure for the adsorption and photothermal and photocata...The integration of the photocatalytic effect into solar steam is highly desirable for addressing freshwater shortages and water pollution.Here,a ternary film structure for the adsorption and photothermal and photocatalytic treatment of wastewater was designed by combining the technique of self-assembled carbon nano paper with a nitrogen composite titanium dioxide(N-TiO_(2))deposited on the surface of carbon nanotubes(CNT)using polyvinylidene fluoride(PVDF)as a substrate.The photogeneration of reactive oxygen species can be promoted by rapid oxygen diffusion at the three-phase interface,whereas the interfacial photothermal effect promotes subsequent free radical reactions for the degradation of rhodamine B(93%).The freshwater evaporation rate is 1.35 kg·m^(-2)·h^(-1)and the solar-to-water evaporation efficiency is 94%.Importantly,the N-TiO_(2)/CNT/PVDF(N-TCP)film not only effectively resists mechanical damage from the environment and maintains structural integrity,but can also be made into a large film for outdoor experiments in a large solar energy conversion device to collect fresh water from polluted water and degrade organic dyes in source water simultaneously,opening the way for applications in energy conversion and storage.展开更多
Based on the kinetic and thermodynamic equations, a comprehensive mathematical model for the con- tinuous esterification process of polyester polyols was developed, which was carried out in an innovational bub- bling ...Based on the kinetic and thermodynamic equations, a comprehensive mathematical model for the con- tinuous esterification process of polyester polyols was developed, which was carried out in an innovational bub- bling reactive distillation tower （BRDT） at atmospheric pressure. In this new type of reactor, direct esterification between ethylene glycol and adipic acid was accomplished efficiently and rapidly. A bench BRDT with the height of 2 m was applied for the esteriflcation process of l^oly （ethylene adlpate） （P＇EA）. In the continuous operation, Hn- ear oligomers were discharged from the bottom of the column, while water passed a few column trays and a pack- ing section as a condensation byproduct. The influence of major operating conditions on reactor performance was also simulated. Simulation results were in good agreement with experimental data, providing a strategy for devel- oping and optimizing this process.展开更多
Butyl-levulinate has been identified as a promising fuel candidate with high oxygen content. Its com- bustion in diesel engines yields very low soot and NOx emissions. It can be produced by the esterification of butan...Butyl-levulinate has been identified as a promising fuel candidate with high oxygen content. Its com- bustion in diesel engines yields very low soot and NOx emissions. It can be produced by the esterification of butanol and levulinic acid, which themselves are platform chemicals in a biorenewables-based chemical supply chain. Since the equilibrium of esterification limits the conversion in a conventional reactor, reactive distillation can be applied to overcome this limitation. The presence of the high-boiling catalyst sulfuric acid requires a further separation step downstream of the reactive distillation column to recover the catalyst for recycle. Optimal design specifications and an optimal operating point are determined using rigorous flowsheet optimization. The challenging optimization problem is solved by a favorable initialization strategy and continuous reformulation. The design identified has the potential to produce a renewable transportation fuel at reasonable cost.展开更多
Nonequilibrium stage model is a significant improvement in multicomponent separation process simulation,but more equations are involved and the solution of the model equations,which relies on an adequate initial guess...Nonequilibrium stage model is a significant improvement in multicomponent separation process simulation,but more equations are involved and the solution of the model equations,which relies on an adequate initial guess for convergence of the Newton method,is difficult.In this work,based on the concept of pseudo-transient continuation approach,we proposed a new pseudo-transient(PT)nonequilibrium method.The proposed method decouples the strongly coupled model equations by introducing dynamic equations for material and energy conservation,as well as transition equations.Thus,the steady-state solution of the nonequilibrium stage model can be obtained through a robust and fast integration process,and the initial guess issue in Newton method can be effectively avoided.Two simulation cases were used to demonstrate the advantages and applicability of the proposed PT nonequilibrium method.展开更多
基金the Specialized Research Fund for the Doctoral Program of Higher Education of China(20060110003)
文摘The performance of a rotating packed bed （RPter solutioB） with three kinds of packings was investigated using alcohol/wan under continuous distillation conditions at atmospheric pressure. The effects of average high gravity factor （β）, reflux ratio （R）, and feedstock flux （F） on mass-transfer in distillation were examined separately. Experimental results indicated that the total number of theoretical units （NTU） of RPB increased with β, R, and F.Of the three kinds of packings, the wave thread packing of stainless steel （Packing-Ⅲ）-had the best mass transfer efficiency with the height equivalent of a theoretical plate （HETP） of approximately 7.35 mm- 23.58 ram, whereas the corrugated disk pacing of stainless steel,（Packing Ⅰ） had the worst one with the HETP of about 13.4 mm-48.07 mm.Correlations were cleveloped to describe the mass transfer efficiency for packings Comparing.experimental data with the data calculated by correlation, the average deviate obtained for each packing was 0.72%, 1.98%, and 2.7%, respectively, implying that the accuracy of correlations developed was reasonable.
基金Supported by the Education Foundation of Chongqing(KJ1712307)the Application Technology Research and Developments Foundation of Fuling Technology Board(FLKJ,2016ABA1026)the Young Foundation of Yangtze Normal University(2015XJXM03)
文摘Continuous homogenous azeotropic distillation(CHAD) and pressure-swing distillation(PSD) are explored to separate a minimum-boiling azeotropic system of ethyl acetate and n-hexane. The CHAD process with acetone as the entrainer and the PSD process with the pressures of 0.1 MPa and 0.6 MPa in two columns are designed and simulated by Aspen Plus. The operating conditions of the two processes are optimized via a sequential modular approach to obtain the minimum total annual cost(TAC). The computational results show that the partially heat integrated pressure-swing distillation(HIPSD) has reduced in the energy cost and TAC by 40.79% and 35.94%, respectively, than the conventional PSD, and has more greatly reduced the energy cost and TAC by 62.61% and 49.26% respectively compared with the CHAD process. The comparison of CHAD process and partially HIPSD process illustrates that the partially HIPSD has more advantages in averting the product pollution, energy saving, and economy.
文摘The hydrochloric acid recovery from rare earth chloride solutions by continuous vacuum membrane distillation was first experimentally studied, then material balance of the process was calculated, and the equations which mathematically stimulate the process were lastly achieved. The results indicate a given RE concentration in circular solutions means its constant HCl concentration during the continuous VMD process, furthermore, increasing RE concentration in feed solutions increases the processing capacity per membrane of the experimental set-up. When keeping constant RE concentration in feed solutions, increasing RE concentration in circular solutions decreases its HCl concentration, and HCl recovery ratio increases accordingly, however, processing capacity per membrane of the experimental set-up decreases at the same time. The mathematical results are in accordance with experimental results.
基金Scientific Research Fund of Zhejiang Provincial Education Department(Y202250501)SRT Research Project of Jiaxing Nanhu University。
文摘The integration of the photocatalytic effect into solar steam is highly desirable for addressing freshwater shortages and water pollution.Here,a ternary film structure for the adsorption and photothermal and photocatalytic treatment of wastewater was designed by combining the technique of self-assembled carbon nano paper with a nitrogen composite titanium dioxide(N-TiO_(2))deposited on the surface of carbon nanotubes(CNT)using polyvinylidene fluoride(PVDF)as a substrate.The photogeneration of reactive oxygen species can be promoted by rapid oxygen diffusion at the three-phase interface,whereas the interfacial photothermal effect promotes subsequent free radical reactions for the degradation of rhodamine B(93%).The freshwater evaporation rate is 1.35 kg·m^(-2)·h^(-1)and the solar-to-water evaporation efficiency is 94%.Importantly,the N-TiO_(2)/CNT/PVDF(N-TCP)film not only effectively resists mechanical damage from the environment and maintains structural integrity,but can also be made into a large film for outdoor experiments in a large solar energy conversion device to collect fresh water from polluted water and degrade organic dyes in source water simultaneously,opening the way for applications in energy conversion and storage.
基金Supported by the National Natural Science Foundation of China （21176070）.
文摘Based on the kinetic and thermodynamic equations, a comprehensive mathematical model for the con- tinuous esterification process of polyester polyols was developed, which was carried out in an innovational bub- bling reactive distillation tower （BRDT） at atmospheric pressure. In this new type of reactor, direct esterification between ethylene glycol and adipic acid was accomplished efficiently and rapidly. A bench BRDT with the height of 2 m was applied for the esteriflcation process of l^oly （ethylene adlpate） （P＇EA）. In the continuous operation, Hn- ear oligomers were discharged from the bottom of the column, while water passed a few column trays and a pack- ing section as a condensation byproduct. The influence of major operating conditions on reactor performance was also simulated. Simulation results were in good agreement with experimental data, providing a strategy for devel- oping and optimizing this process.
基金funded by the Excellence Initiative of the German federal and state governments to promote science and research at German universities
文摘Butyl-levulinate has been identified as a promising fuel candidate with high oxygen content. Its com- bustion in diesel engines yields very low soot and NOx emissions. It can be produced by the esterification of butanol and levulinic acid, which themselves are platform chemicals in a biorenewables-based chemical supply chain. Since the equilibrium of esterification limits the conversion in a conventional reactor, reactive distillation can be applied to overcome this limitation. The presence of the high-boiling catalyst sulfuric acid requires a further separation step downstream of the reactive distillation column to recover the catalyst for recycle. Optimal design specifications and an optimal operating point are determined using rigorous flowsheet optimization. The challenging optimization problem is solved by a favorable initialization strategy and continuous reformulation. The design identified has the potential to produce a renewable transportation fuel at reasonable cost.
基金supported by the National Natural Science Foundation of China(21978203).
文摘Nonequilibrium stage model is a significant improvement in multicomponent separation process simulation,but more equations are involved and the solution of the model equations,which relies on an adequate initial guess for convergence of the Newton method,is difficult.In this work,based on the concept of pseudo-transient continuation approach,we proposed a new pseudo-transient(PT)nonequilibrium method.The proposed method decouples the strongly coupled model equations by introducing dynamic equations for material and energy conservation,as well as transition equations.Thus,the steady-state solution of the nonequilibrium stage model can be obtained through a robust and fast integration process,and the initial guess issue in Newton method can be effectively avoided.Two simulation cases were used to demonstrate the advantages and applicability of the proposed PT nonequilibrium method.
