Fluoride evaporation and crystallization behavior of CaF_2–CaO–Al_2O_3–(TiO_2) slag for electroslag remelting of Ti-containing steels

To elucidate the behavior of slag films in an electroslag remelting process, the fluoride evaporation and crystallization of CaF2–CaO–Al2O3–（TiO2） slags were studied using the single hot thermocouple technique. The crystallization mechanism of TiO2-bearing slag was identified based on kinetic analysis. The fluoride evaporation and incubation time of crystallization in TiO2-free slag are found to considerably decrease with decreasing isothermal temperature down to 1503 K. Fish-bone and flower-like CaO crystals precipitate in TiO2-free slag melt, which is accompanied by CaF2 evaporation from slag melt above 1503 K. Below 1503 K, only near-spherical CaF2 crystals form with an incubation time of less than 1 s, and the crystallization is completed within 1 s. The addition of 8.1wt% TiO2 largely prevents the fluoride evaporation from slag melt and promotes the slag crystallization. TiO2 addition leads to the precipitation of needle-like perovskite（CaTiO3） crystals instead of CaO crystals in the slag. The crystallization of perovskite（CaTiO3） occurs by bulk nucleation and diffusion-controlled one-dimensional growth.

The Influence of Pan Evaporation Conditions on Na Cl crystallization

1 Introduction Crystallization is one of important unit operations in the chemical production process,which requires not only the crystal product with high purity and yield,but also the available particle size of the crystal products to ensure product quality.Crystallization process is affected by

Identification of key factors governing chemistry in groundwater near the water course recharged by reclaimed water at Miyun County, Northern China

Reclaimed water was successfully used to recover the dry Chaobai River in Northern China, but groundwater may be polluted. To ensure groundwater protection, it is therefore critical to identify the governing factors of groundwater chemistry. Samples of reclaimed water, river and groundwater were collected monthly at Chaobai River from January to September in 2010. Fifteen water parameters were analyzed. Two kinds of reclaimed water were different in type （Na-Ca-Mg-Cl-HCO3 or Na-Ca-Cl-HCO3 ） and concentration of nitrogen. The ionic concentration and type in river were similar to reclaimed water. Some shallow wells near the river bed had the same type （Na-Ca-Mg-Cl-HCO3 ） and high concentration as reclaimed water, but others were consistent with the deep wells （Ca-Mg-HCO3 ）. Using cluster analysis, the 9 months were divided into two periods （dry and wet seasons）, and all samples were grouped into several spatial clusters, indicating different controlling mechanisms. Principal component analysis and conventional ionic plots showed that calcium, magnesium and bicarbonate were controlled by water-rock interaction in all deep and some shallow wells. This included the dissolution of calcite and carbonate weathering. Sodium, potassium, chloride and sulfate in river and some shallow wells recharged by river were governed by evaporation crystallization and mixing of reclaimed water. But groundwater chemistry was not controlled by precipitation. During the infiltration of reclaimed water, cation exchange took place between （sodium, potassium） and （calcium, magnesium）. Nitrification and denitrification both happened in most shallow groundwater, but only denitrification in deep groundwater.

Low Temperature Solvent Evaporation-induced Crystallization Synthesis of Nanocrystalline TiO_2 Photocatalyst

A novel and efficient methodology for obtaining highly active photocatalyst of bi phase TiO 2 with small particle size and high specific surface area was developed by solvent evaporation induced crystallization (SEIC) method at low temperature. The prepared TiO 2 powder was characterized with X ray diffraction (XRD), transmission electron microscopy (TEM) and BET surface areas. The photocatalytic activity was evaluated by the photocatalytic oxidation of acetone in air. The results showed that the photocatalytic activity of the TiO 2 powder prepared by this method approached that of Degussa P25. This may be attributed to the fact that the prepared TiO 2 powder had larger specific surface areas (265 m 2·g -1 ) and smaller crystallite size (about 5 nm), but relatively low crystallinity, as compared with Degussa P25.

EFFECT OF VACUUM ON THE CRYSTAL FORM AND MORPHOLOGY OF THE EVAPORATED FILM OF COPPER PHTHALOCYANINE

In a previous paper, we have reported the relationship between the crystallite orientation of the evaporated film of copper phthalacyanine （PcCu） （α-form） and the incident angle of molecular beam at 10-5 torr. In this paper, we shall show some research results about vacuum effects on the crystal forms and the morphology of the evaporat-