Mechanism of wet shotcrete interacting with rock in support systems

In order to have a good understanding of the behavior of wet shotcrete as a support element interacting with the rock mass,mechanism of wet shotcrete interacting with rock in support systems was analyzed through theoretical,numerical study and analytical analysis.A new model of distribution of rock stress state after wet shotcrete was applied,which includes shotcrete layer,composite layer,strengthening layer,plastic layer and elastic layer,and a full illustration of the rock mass stress state was given after shotcrete interacting with rock mass.At the same time,numerical analysis with FLAC gives a stress distribution along the monitor line,respectively,at the sidewall and roof of the tunnel.The displacement obviously decreases with the depth of rock,the tangential stress for tunnel supported by shotcrete is lower than that without shotcrete,and radial stress for tunnel supported by shotcrete is higher than that without shotcrete.It has been demonstrated by AIRY'S stress function,which gives a reasonable solution.Finally,the application of wet shotcrete in Jinfeng Gold Mine shows that the displacement of tunnel decreases obviously in sidewall and roof.

Stress spatial evolution law and rockburst danger induced by coal mining in fault zone

In order to explore the influence of coal mining disturbance on the rockburst occurring in fault zone, this research constructed a mechanical model for the evolution of fault stress, and analyzed the influence of the ratio of horizontal stress to vertical stress on the stability of fault, and the spatial distribution of the stress in fault zone as well as its evolution rule. Furthermore, the rockburst danger at different spatial areas of fault zone was predicated. Results show that: when both sides of the working face are mined out, the fault zone in the working face presents greater horizontal and vertical stresses at its boundaries but exhibits smaller stresses in its middle section; however, the ratio of horizontal stress to vertical stress is found to be greater at middle section and smaller at boundaries. As the working face advances towards the fault, the horizontal and vertical stresses of the fault firstly increases and then decreases; conversely,the ratio of horizontal stress to vertical stress keeps decreasing all the time. Therefore, if the fault zones are closer to the goaf and the coal wall, the stress ratio will be smaller, and the fault slip will be more prone to occur, therefore rockburst danger will be greater. This research results provide guidance for the rockburst prevention and hazard control of the coal mining in fault zone.