Effects of alkaline-electrolyzed and hydrogen-rich water,in a high-fat-diet nonalcoholic fatty liver disease mouse model

AIM To identify the effect of hydrogen-rich water(HRW) and electrolyzed-alkaline water(EAW) on high-fat-induced non-alcoholic fatty acid disease in mice.METHODS Mice were divided into four groups:(1) Regular diet(RD)/regular water(RW);(2) high-fat diet(HFD)/RW;(3) RD/EAW; and(4) HFD/EAW. Weight and body composition were measured. After twelve weeks, animals were sacrificed, and livers were processed for histology and reverse-transcriptase polymerase chain reaction. A similar experiment was performed using HRW to determine the influence and importance of molecular hydrogen(H2) in EAW. Finally, we compared the response of hepatocytes isolated from mice drinking HRW or RW to palmitate overload.RESULTS EAW had several properties important to the study:(1) pH = 11;(2) oxidation-reduction potential of-495 mV; and(3) H2 = 0.2 mg/L. However, in contrast to other studies, there were no differences between the groups drinking EAW or RW in either the RD or HFD groups. We hypothesized that the null result was due to low H2 concentrations. Therefore, we evaluated the effects of RW and low and high HRW concentrations(L-HRW = 0.3 mg H2/L and H-HRW = 0.8 mg H2/L, respectively) in mice fed an HFD. Compared to RW and L-HRW, H-HRW resulted in a lower increase in fat mass(46% vs 61%), an increase in lean body mass(42% vs 28%), and a decrease in hepatic lipid accumulation(P < 0.01). Lastly, exposure of hepatocytes isolated from mice drinking H-HRW to palmitate overload demonstrated a protective effect from H2 by reducing hepatocyte lipid accumulation in comparison to mice drinking regular water.CONCLUSION H2 is the therapeutic agent in electrolyzed-alkaline water and attenuates HFD-induced nonalcoholic fatty liver disease in mice.

Morphological and molecular response of small intestine to lactulose and hydrogen-rich water in female piglets fed Fusarium mycotoxins contaminated diet

Background: Following the intake of Fusarium mycotoxin-contaminated feed,small intestines may be exposed to high levels of toxic substances that can potentially damage intestinal functions in livestock.It is well known that Fusarium mycotoxins will lead a breakdown of the normally impeccable epithelial barrier,resulting in the development of a "leaky" gut.H2 administration with different methods has been proved definitely potentials to prevent serious intestinal diseases.The goal of this study is to investigate the roles of lactulose(LAC) and hydrogenrich water(HRW) in preventing intestinal dysfunction in piglets fed Fusarium mycotoxin-contaminated feed.Methods: A total of 24 female piglets were evenly assigned to 4 groups: negative control(NC) group,mycotoxincontaminated(MC) feed group,MC feed with LAC treatment(MC + LAC),and MC feed with HRW treatment(MC +HRW),respectively.Piglets in the NC group were fed uncontaminated control diet,while remaining piglets were fed Fusarium mycotoxin-contaminated diet.For the NC and MC groups,10 mL/kg body weight(BW) of hydrogen-free water(HFW) was orally administrated to piglets twice daily;while in the MC + LAC and MC + HRW groups,piglets were treated with the same dose of LAC solution(500 mg/kg BW) and HRW twice daily,respectively.On d 25,serum was collected and used for biochemical analysis.Intestinal tissues were sampled for morphological examination as well as relative genes and protein expression analysis.Results: Our data showed that Fusarium mycotoxins induced higher serum diamine oxidase(DAO) activities(P < 0.05),D-lactic acid levels(P < 0.01),and endotoxin status(P < 0.01),lower villus height(P < 0.01) and ratio of villus height to crypt depth(P < 0.05) in small intestine,greater apoptosis index and higher mRNA expression related to tight junctions(P < 0.05).In addition,the distribution and down-regulation of claudin-3(CLDN3) protein in the small intestinal was also observed.As expected,oral administrations of HRW and LAC were found to remarkably provide beneficial effects against Fusarium mycotoxin-induced apoptosis and intestinal leaking.Moreover,either HRW or LAC treatments were also revealed to prevent abnormal intestinal morphological changes,disintegrate tight junctions,and restore the expression and distribution of CLDN3 protein in the small intestinal mucosal layer in female piglets that were fed Fusarium mycotoxins contaminated diet.Conclusions: Our data suggest that orally administrations of HRW and LAC result in less Fusarium mycotoxininduced apoptosis and leak in the small intestine.Either HRW or LAC treatments could prevent the abnormal changes of intestinal morphology and molecular response of tight junctions as well as restore the distribution and expression of CLDN3 protein of small intestinal mucosa layer in female piglets that were fed Fusarium mycotoxins contaminated diet.

Selective catalytic methanation of CO in hydrogen-rich gases over Ni/ZrO_2 catalyst

Ni/ZrO2 catalysts were prepared by the incipient-wetness impregnation method and were investigated in activity and selectivity for the selective catalytic methanation of CO in hydrogen-rich gases with more than 20 vol% CO2. The result showed that Ni loadings significantly influenced the performance of Ni/ZrO2 catalyst. The 1.6 wt% Ni loading catalyst exhibited the highest catalytic activity among all the catalysts in the selective methanation of CO in hydrogen-rich gas. The outlet concentration of CO was less than 20 ppm with the hydrogen consumption below 7%, at a gas-hourly-space velocity as high as 10000 h-1 and a temperature range of 260 °C to 280 °C. The X-ray diffraction （XRD） and temperature programmed reduction （TPR） measurements showed that NiO was dispersed thoroughly on the surface of ZrO2 support if Ni loading was under 1.6 wt%. When Ni loading was increased to 3 wt% or above, the free bulk NiO species began to assemble, which was not favorable to increase the selectivity of the catalyst.

Hydrogen-rich saline protects against hepatic injury induced by ischemia-reperfusion and laparoscopic hepatectomy in swine

Background: Hydrogen-rich saline(HRS) has antioxidative, anti-inflammatory and anti-apoptotic properties. We investigated the effects of hydrogen on hepatic ischemia-reperfusion(I/R) and laparoscopic hepatectomy in swine. Methods: Twenty-one healthy Bama miniature pigs were randomly divided into the sham group, ischemia-reperfusion injury(IRI) group, HRS-5(5 m L/kg) group, and HRS-10(10 m L/kg) group. HRS was injected through the portal vein 10 min before reperfusion and at postoperative day 1, 2 and 3. The roles of HRS on oxidative stress, inflammatory response and liver regeneration were studied. Results: Compared with the IRI group, HRS treatment attenuated oxidative stress by increasing catalase activity and reducing myeloperoxidase. White blood cells in the HRS-10 group were reduced compared with the IRI group( P < 0.01). In the HRS-10 group, interleukin-1 beta, interleukin-6 and tumor necrosis factor alpha, C-reactive protein and cortisol were downregulated, whereas interleukin-10 was upregulated. In addition, HRS attenuated endothelial cell injury and promoted the secretion of angiogenic cytokines, including vascular endothelial growth factor, angiopoietin-1 and angiopoietin-2. HRS elevated the levels of hepatocyte growth factor, Cyclin D1, proliferating cell nuclear antigen, Ki-67 and reduced the secretion of transforming growth factor-beta. Conclusions: HRS treatment may exert a protective effect against I/R and hepatectomy-induced hepatic damage by reducing oxidative stress, suppressing the inflammatory response and promoting liver regeneration.

Hydrogen-rich saline protects against ultraviolet B radiation injury in rats

Exposure of skin to solar ultraviolet（UV） radiation induces photo-damage.Ultraviolet B（UVB） is the major component of UV radiation which induces the production of reactive oxygen species（ROS） and plays an impor-tant role in photo-damage.Hydrogen gas reduces ROS and alleviates inflammation.In this study,we sought to demonstrate that hydrogen-rich saline has the effect on skin injuries caused by UVB radiation.UVB radiation was irradiated on female C57BL/6 rats to induce skin injury.Hydrogen-rich saline and nitrogen-rich saline were ad-ministered to rats by intraperitoneal injection.Skin damage was detected by microscope after injury.UVB radia-tion had a significant affection in tumor necrosis factor alpha,interleukin（IL）-1β and IL-6 levels,tissue superox-ide dismutase,malondialdehyde and nitric oxide activity.Hydrogen-rich saline had a protective effect by altering the levels of these markers and relieved morphological skin injury.Hydrogen-rich saline protected against UVB radiation injury,possibly by reducing inflammation and oxidative stress.

The reason for the amelioration of N-methyl-N-nitrosourea-induced retinitis pigmentosa in rats by hydrogen-rich saline

AIM：To investigate the effects of hydrogen-rich saline（HRS）on microglia activation and Sirtuin type 1（Sirt1）in rats with N-methyl-N-nitrosourea（MNU）-induced retinitis pigmentosa（RP）.METHODS：Rats were divided into norm（N）group,model（M）group and HRS（H）group.Rats in M and H groups were given saline and HRS respectively prior to and after administration of MNU.At one day（d1）and d3 afterwards,electroretinogram and histological examination were performed to confirm the effects of HRS on retinal function and structure of MNU-induced RP.Immunofluorescence staining of anti-ionized calcium-binding adapter molecule 1（Iba1）,a maker of microglia cells,was performed,with quantitative real-time polymerase chain reaction（qRT-PCR）for its m RNA quantification.Moreover,Sirt1 m RNA and protein expression in the retinas were detected by Western blot and qRT-PCR.RESULTS：HRS preserved the retinal function and mitigated the reduction of photoreceptor degeneration in MNU-treated retinas.The presence of microglia cells was somewhat more obvious in H group than that in M group at d1.HRS suppressed the further activation of microglia cells,with the number of microglia cells less than that of M group at d3.Results of qRT-PCR of Iba1 were consistent with those of immunofluorescence staining,with the m RNA expression of Iba1 in H group more intensive than that of M group at d1（P〈0.05）,while less than that of M group at d3（P〈0.05）.Furthermore,the Sirt1 m RNA and protein expression decreased after MNU administration,while HRS mitigated the MNU-induced downregulation of Sirt1.CONCLUSION：HRS can effectively keep microglia activation induced by MNU to an appropriate extent,while upregulate Sirt1 in MNU-induced RP.

CO selective methanation in hydrogen-rich gas mixtures over carbon nanotube supported Ru-based catalysts

Series of carbon nanotube supported Ru-based catalysts were prepared by impregnation method and applied successfully for complete removal of CO by CO selective methanation from H2-rich gas stream conducted in a fixed-bed quartz tubular reactor at ambient pressure. It was found that the metal promoter, reduction temperature and metal loading affected the catalytic properties significantly. The most excellent performance was presented by 30 wt% Ru-Zr/CNTs catalyst reduced at 350 ℃. Since it decreased CO concentration to below 10 ppm from 12000 ppm by CO selective methanation at the temperature range of 180-240 ℃, and kept CO selectivity higher than 85% at the temperature below 200 ℃. Characterization using XRD, TEM, H2-TPR and XPS suggests that Zr modification of Ru/CNTs results in the weakening of the interaction between Ru and CNTs, a higher Ru dispersion and the oxidization of surface Ru. Amorphous and high dispersed Ru particles with small size were obtained for 30 wt% Ru-Zr/CNTs catalyst reduced at 350 ℃, leading to excellent catalytic performance in CO selective methanation.

Production of hydrogen-rich gas and multi-walled carbon nanotubes from ethanol decomposition over molybdenum modified Ni/MgO catalysts

A series of molybdenum modified Ni/MgO catalysts （Ni-Mo/MgO） with different loading ratios of Ni ： Mo were prepared by impregnation method. Ethanol decomposition to co-produce multi-walled carbon nanotubes and hydrogen-rich gas at temperatures of 600-800 ℃ was inves- tigated over the synthesized Ni-Mo/MgO catalysts. The results showed that the catalytic activity depended strongly on the reaction temperature and loading ratio of Ni ： Mo. According to the gaseous and solid products obtained, the reaction pathways for ethanol decomposition were suggested.

The role of CALYPSO in the discovery of high-T_c hydrogen-rich superconductors

Hydrogen-rich compounds are promising candidates for high-Tc or even room-temperature superconductors. The search for high-Tc hydrides poses a major experimental challenge because there are many known hydrides and even more unknown hydrides with unusual stoichiometries under high pressure. The combination of crystal structure prediction and first-principles calculations has played an important role in the search for high-Tc hydrides, especially in guiding experimental synthesis. Crystal structure AnaLYsis by Particle Swarm Optimization(CALYPSO) is one of the most efficient methods for predicting stable or metastable structures from the chemical composition alone. This review summarizes the superconducting hydrides predicted using CALYPSO. We focus on two breakthroughs toward room-temperature superconductors initiated by CALYPSO: the prediction of high-Tc superconductivity in compressed hydrogen sulfide and lanthanum hydrides, both of which have been confirmed experimentally and have set new record Tc values. We also address the challenges and outlook in this field.

Catalytic steam reforming of biomass over Ni-based catalysts: Conversion from poplar leaves to hydrogen-rich syngas

A series of Ni/SBA-15 catalysts with Ni contents from 5 wt%–20 wt%and CaO-12.5%Ni/SBA-15 catalysts with CaO contents from 1.4 wt%– 9.8 wt%have been prepared.The structure of the catalysts was characterized using X-ray diffraction（XRD）,N2 adsorption-desorption,transmission electron microscopy（TEM）and X-ray photoelectron spectroscopy（XPS）.The performance of catalytic steam reforming of the poplar leaves to the hydrogen-rich syngas was tested in a fixed-bed reactor.The results indicate that the 7.0wt%CaO-12.5wt%Ni/SBA-15 catalyst exhibits the best performance for the catalytic steam reforming of poplar leaves to hydrogen-rich syngas.The ratio of H2：CO can reach ca 5：1 in the hydrogen-rich syngas.The yield of H2 can reach 273.30 mL/g（poplar leaves）.In the CaO-Ni/SBA-15 catalyst,Ni active component mainly fills the role of catalytic steam reforming of the poplar leaves,and CaO active component mainly plays the role as water-gas shift and CO2 sorbent.

Synthesis of Mesoporous Cu-Mn-Al_2O_3 Materials and Their Applications to Preferential Catalytic Oxidation of CO in a Hydrogen-rich Stream

A series of mesoporous Cu-Mn-Al2O3（CMA） materials was synthesized at moderate temperature and their structures were characterized by XRD, N2 physical adsorption and TPR techniques. It was found that using metal complex ion[Cu（NH3） 4^2＋-Mn（NH3）6^2＋] as raw materials is easier to form good-structure mesoporous Cu-Mn-Al2O3 materials than using its nitrate salt [Cu（NO3）2-Mn（NO3）2]. The TPR tests results indicate that CuO and MnOx were homogeneously dispersed in the mesoporous materials. Their catalytic application to preferential catalytic oxidation of CO in a hydrogen-rich stream was studied. The activity varies in the order of CMA（1：1, molar ratio）〉 CMA（1：2）〉CMA（2：1）〉CMA（CP）〉CMA（1：0）≈CMA（0：1）. The CMA（1：0） and CMA（0：1） have lower activity compared to other samples, implying that there existed coordination effect between Cu-Mn in the samples. The selectivity varied in the order of CMA（0：1）≥CMA（1：2）〉CMA（1：1）〉CMA（2：1）〉CMA（1：0） at higher temperature （≥ 120 ℃）, indicating that increasing the Cu content enhanced the conversion of H2. The sample CMA（CP） made by coprecipitation method has a lower CO oxidation activity and selectivity than its counter-parts of mesoporous Cu-Mn-Al2O3 materials[CMA（1：2）], this attributed to the lower surface area of the former and poor interaction of CuO with MnOx.

CO Selective Oxidation in Hydrogen-Rich Gas over Copper-Series Catalysts

The performances of CO selective oxidation in hydrogen-rich gas over fourcatalytic systems of CuO/ZrO_2, CuO/MnO_2, CuO/CoO and CuO/CeO_2 were compared. The reducibility ofthese catalysts and the effect of CuO and CeO_2 molar ratio of CuO/CeO_2 catalysts on the activityof selective CO oxidation are investigated by XRD and TPR methods. The results show that thecatalysts with the exception of CuO/ZrO_2 have the interactions between CuO and CoO, CeO_2 or MnO_2,which result in a decrease in the reduction temperature. Among the catalysts studied, CuO/ZrO_2catalyst shows the lowest catalytic activity while CuO/CeO_2 catalyst exhibits the best catalyticperformance. The CuO(10%)/CeO_2 catalyst attains the highest CO conversion and selectivity at 140and 160℃. The addition of 9% H_2O in the reactant feed decreases the activity of CuO/CeO_2 catalystbut increases its CO selectivity.

Hydrogen-rich saline injection into the subarachnoid cavity within 2 weeks promotes recovery after acute spinal cord injury

Hydrogen can relieve tissue-damaging oxidative stress, inflammation and apoptosis. Injection of hydrogen-rich saline is an effective method for transporting molecular hydrogen. We hypothesized that hydrogen-rich saline would promote the repair of spinal cord injury induced by Allen＇s method in rats. At 0.5, 1, 2, 4, 8, 12 and 24 hours after injury, then once daily for 2 weeks, 0.25 mL/kg hydrogen-rich saline was infused into the subarachnoid space through a catheter. Results at 24 hours, 48 hours, 1 week and 2 weeks after injury showed that hydrogen-rich saline markedly reduced cell death, inflammatory cell infiltration, serum malondialdehyde content, and caspa se-3 immunoreactivity, elevated serum superoxide dismutase activity and calcitonin gene-related peptide immunoreactivity, and improved motor function in the hindlimb. The present study confirms that hydrogen-rich saline injected within 2 weeks of injury effectively contributes to the repair of spinal cord injury in the acute stage.

Study on the Possibility of Mixed Water as a Drinking Water<br/>—From the Viewpoint of the Formation of Hydrogen-Rich Water

In exploring an autonomous independent water supply system, authors have realized the importance of the sustainable water supply utilizing regional features in isolated islands. This paper is further study from the previous one. This time we have narrowed down the mixing rate of mixed water. In this study, the mixed water less than 0.74% (blood concentration) has been prepared first, and then divided it into five kinds of the mixing rate of mixed water. And we have compared and examined the characteristics of the mixed water from the viewpoint of the relationship between salinity and pH, ORP and that of Dissolved Hydrogen, and examined the possibility of mixed water as a drinking water. As a result, we have obtained the new findings that suggest the possibility.

Efficacy and tolerability of hydrogen carbonate-rich waterfor heartburn

AIM To investigate the efficacy and safety of mineralwater with a high content of hydrogen carbonate inpatients with heartburn.METHODS： This open, single-center, single-armclinical pilot study enrolled 50 patients, 18-64 yearsold, who had been suffering from heartburn at leasttwice a week for at least 3 mo before entering thestudy. Pharmacological treatment of heartburn was notpermitted, and patients with severe organic diseaseswere excluded. After a run-in period of one week, theparticipants received 1.5 L of the test water for thefollowing 6 wk; 300 mL with meals t.i.d., the remainderto be drunk throughout the day. During the trial, therewere five visits at the study center （screening, baseline,two interim visits and the final visit）. The efficacyendpoints included incidence and duration of heartburnepisodes per week by patient＇s self-assessment （heartburndiary） as well as changes in symptom severity asper symptom specific questionnaires [Reflux Disease Questionnaire （RDQ）; Quality of Life in Reflux andDyspepsia （QOLRAD）; Gastrointestinal Quality of LifeIndex] and overall health-related quality of life per SF-12（12-question short form） at each visit. At the end of thestudy, patients and investigators independently ratedthe overall efficacy of the test water on a 4-point Likertscale. Safety was assessed by evaluation of adverseevents （AEs）, vital signs （heart rate, blood pressure）and laboratory parameters. Changes from initial to finalexaminations were assessed by the non-parametricWilcoxon test; categorical variables were comparedusing the χ 2 test, and for more than 5 categories, by theU-test.RESULTS： Twenty-eight participants were men, 22women. The mean age of the patients in the fullanalysis set/intention-to treat population （FAS/ITT） was40.6 years. Forty-two participants completed the studyaccording to the study protocol and formed the perprotocolset （PP population）; 48 participants drank thewater at least once as requested and were analyzedas ITT population. The occurrence of heartburn wasstatistically significantly reduced at wk 6 in both the ITTand the PP populations. At wk 6, the mean number ofheartburn episodes/week decreased by 5.1 episodes（P 〈 0.001） and the mean duration of heartburnsymptoms by 19 min （ITT） （P = 0.002）. The frequencyof heartburn symptoms was reduced in 89.6% of thepatients （P 〈 0.001）, and the duration of symptoms in79.2% of patients （ITT） （P 〈 0.001）. All dimensions ofthe RDQ （heartburn, regurgitation, gastro-esophagealreflux disease symptoms, dyspepsia） showed asignificant improvement at 6 wk. Likewise, diseasespecificquality of life improved significantly （QOLRAD,GIQLI）. Overall, 89.4% of patients rated the efficacyof the test water as ＂good＂ or ＂very good＂, as did theinvestigators for 91.5% of the patients. There wereno serious AEs. After 6 wk, systolic and diastolic bloodpressure values decreased slightly but significantly [-3.5and -3.0 mmHg, respectively （P = 0.008 and P = 0,002）].Ninety-six percent of patients and investigators for thesame percentage of patients rated the tolerability of thewater as ＂good＂ or ＂very good＂.CONCLUSION： The data demonstrate effectiveness ofa hydrogen carbonate-rich mineral water in alleviatingheartburn frequency and severity, thereby improvingquality of life. The water has excellent tolerability.

富油煤研究进展与趋势

富油煤是集煤、油、气属性于一身的煤基油气资源,针对国内“相对富煤、缺油、少气”的能源禀赋,开发富油煤对缓解我国紧张的油气资源供应局势、实现煤炭的绿色开发和低碳利用具有重要的意义。以富油煤为主要关键词,通过CNKI和Web of Science数据库检索自1985-2023年底已公开发表的学术论文和专利,统计分析富油煤的发展历程和主要研究内容,梳理了富油煤研究的热点方向与前沿领域,展望了未来发展趋势。研究发现:富油煤热解、赋存特征及沉积环境、孔隙和分子结构、焦油产率预测、微生物降解、资源潜力及开发利用是当前富油煤研究热点内容。富油煤含有热解可生成油气的富氢结构,如脂肪结构的侧链与桥键及缩合芳香核周缘的弱键结构;富油煤多形成于陆相沉积物供应稳定、气候温暖湿润、强还原条件下的沉积环境;孔隙结构影响富油煤的热解反应效率、焦油析出和油气运移,而分子结构(主要为脂肪族氢含量和富氢弱键)决定了富油煤的生油潜力;富油煤通过微生物的水解、发酵、产氢产乙酸和产甲烷4个阶段向油气转化。随着地质选区技术瓶颈突破及多学科交叉与融合,富油煤富油性评价指标与预测方法、富氢组分的来源与定量判识、原位开发围岩封闭性及其评价方法、微生物降解与热解联作技术将成为今后研究的热点方向。研究成果为厘清当前富油煤的研究方向和未来走势奠定了基础。

全球天然氢气勘探开发利用进展及中国的勘探前景

在全球能源脱碳背景下,天然氢气作为一种一次能源,因其零碳、可再生的优点而备受关注,但中国目前还未开展专门针对天然氢气的勘探工作。通过介绍全球已知高含量天然氢气(体积分数大于10%)气藏的主要形成地质环境及成因类型,系统总结了天然氢气富集的有利地质条件,并结合国外天然氢气的勘探开发现状,评价了中国天然氢气的勘探前景。研究结果表明:(1)全球高含量天然氢气主要发育于蛇绿岩带、裂谷和前寒武系富铁地层中,且以无机成因为主,富铁矿物的蛇纹石化过程是天然氢气最主要的成因来源,其次为地球深部脱气和水的辐解。(2)优质的氢源与良好的运移通道是氢气富集的前提,而盖层的封盖能力是天然氢气能否成藏的关键要素;天然氢气作为伴生气时,传统盖层对其具备封盖能力,但当其含量较高时,传统盖层可能难以形成有效封盖;裂谷环境、蛇绿岩发育区以及断裂发育的前寒武系富铁地层是富氢气藏的勘探有利区。(3)国外多个国家和地区已制定了天然氢气的勘探开发和利用计划,其中,马里已实现天然氢气的商业开采,美国、澳大利亚也已成功钻探天然氢气勘探井。(4)中国高含量氢气区与富氢地质条件高度匹配,天然氢气勘探前景良好,郯庐断裂带及周缘裂陷盆地区、阿尔金断裂带及两侧盆地区、三江构造带—龙门山断裂带及周缘盆地区的天然氢气勘探潜力较大;中国应尽快开展天然氢气普查工作,加强氢气成藏过程研究和潜力评价,并进行勘探技术、开采分离技术和储运技术的攻关,为天然氢气的大规模开发利用做好技术储备。

Fe-Ca-Ce催化生物质热解制备富氢合成气——以山楂药渣为例

以山楂药渣作为原料,在固定床反应器中研究了热解温度和Fe、Fe-Ca、Fe-Ca-Ce催化剂及负载量对药渣热解的影响规律,并研究了浸渍法和共沉淀法对热解气体产率的影响.研究结果表明,热解温度从500℃升高至700℃,H_(2)由10.40 mL/g升高至27.64 mL/g,当Fe负载量为w=7%时,H_(2)产率由27.64 mL/g增加至46.16 mL/g,在Fe中引入Ca有效提高了H_(2)的产率,Ca的负载量增加至w=2.0%时,H_(2)产率增加至69.53 mL/g.采用共沉淀法制备Fe和Fe-Ca催化剂有利于降低CO_(2)产率,而在Fe-Ca中引入Ce后H_(2)产率从69.53 mL/g减少至50.18 mL/g.

低碳氢冶金炼铁技术进展及包钢氢能炼铁技术途径探讨

钢铁工业是国民经济发展的支柱型产业,钢铁工业的节能降碳是实现国家“碳达峰、碳中和”发展目标的重中之重。文章简要介绍了主流低碳氢冶金炼铁技术的种类及特点,阐述了国内外低碳氢冶金炼铁技术的进展及现状。高炉富氢还原技术和氢基竖炉直接还原技术是最主要的低碳氢冶金炼铁技术。其中,高炉富氢还原技术降碳能力有限,可作为钢铁行业短期低碳氢冶金炼铁技术的发展方向,如结合碳捕集利用封存(CCUS)技术,可进一步降低CO_(2)排放量。氢基竖炉直接还原技术从源头上摆脱了化石能源的应用,与传统“高炉-转炉”生产流程相比,可降碳80%以上,是钢铁工业工艺技术变革必然发展趋势。包钢积极响应国家绿色低碳发展战略及内蒙古五大任务,积极布局绿色低碳氢能炼铁技术于白云鄂博中贫矿的氢基矿相转化、高炉富氢还原及氢基竖炉直接还原技术,钢铁生产过程低碳绿色化明显提高。

低碳炼铁技术探讨

本文从减碳潜力的角度分析探讨了富氢碳循环氧气高炉技术和氢基竖炉直接还原技术的应用前景。以富氢碳循环氧气高炉技术为代表的长流程低碳冶炼技术降低碳排放量的理论极限约50%,有助于我国钢铁工业现阶段实现较大的减碳效果,而采用富氢气体作为还原剂的竖炉工艺,在技术层面已具备进一步提高氢气比例的能力,甚至可以将氢气比例提高到100%,通过化学反应、反应热力学和反应动力学等机理分析,探讨了MIDREX和ENERGIRON工艺不同参数选择的本质原因。在还原气相同时,MIDREX工艺和ENERGIRON工艺的竖炉内气体中H_(2)/CO不同,是由重整方式不同决定的,H_(2)/CO越高越符合氢冶金的需求;竖炉内压力越高,还原速度越快,还原气体利用率越高,可以提高单位容积竖炉的产量,减小设备总重量;气体入炉温度主要由炉内气体成分决定,为充分发挥H_(2)的还原能力,同时避免炉内粘结的发生,气体入炉温度选择在950℃左右,H_(2)比例高,气体入炉温度可以适当提高。