Facile Preparation of Dopamine-Modified Magnetic Zinc Ferrite Immobilized Lipase for Highly Efficient Synthesis of OPO Functional Lipid

1,3-Dioleoyl-2-palmitoylglycerol(OPO)has been a hotspot of functional oils research in recent years,but due to the high cost of sn-1,3 specific lipase in enzymatic synthesis and the lack of biocatalyst stability,large-scale industrial application is difficult.In this study,the prepared magnetic ZnFe_(2)O_(4) was functionalized with dopamine to obtain ZnFe_(2)O_(4)@PDA,and the nano-biocatalyst ZnFe_(2)O_(4)@PDA@RML was prepared by immobilizing sn-1,3 specific lipase of Rhizomucor miehei lipase(RML)via a cross-linking method.The existence of RML on ZnFe_(2)O_(4)@PDA was confirmed by XRD,FTIR,SEM,and TEM.This strategy proved to be simple and effective because the lipase immobilized on magnetic nanoparticles could be quickly recovered using external magnets,enabling reuse of the lipase.The activity,adaptability to a high temperature,pH value,and operational stability of immobilized RML were superior to those of free RML.After optimizing the synthesis conditions,the OPO yield was 42.78%,and the proportion of PA at the sn-2 position(PA-Sn2)was 54.63%.After the first four cycles,the activity of ZnFe_(2)O_(4)@PDA@RML was not significantly affected.The magnetically immobilized lipase has good thermal stability,long-term storage stability,reusability,and high catalytic activity.It can be used as a green and efficient biocatalyst to synthesize the OPO functional lipid.

Effective desalination and anti-biofouling performance via surface immobilized MWCNTs on RO membrane

Desalination is considered a viable method to overcome the issue of water scarcity either from waste water or seawater. For this purpose, this study employed a facile approach to develop surface immobilized oxidized-MWCNTs(o-MWCNTs) onto crosslinked polyvinyl alcohol(PVA) membrane. Firstly, modified polysulphone substrate was synthesized on to which crosslinked PVA layer was spread onto it. PVA layer act as active layer for surface immobilization of o-MWCNTs in varying concentration. The functional group analysis, morphology and roughness of membranes surface was conducted out using FTIR, SEM and AFM respectively. The results showed that modified membranes, immobilized o-MWCNTs enhanced the salt rejection(Na_(2)SO_(4)) upto 99.8%. After contacting with Escherichia coli and Staphylococcus aureus for 2.5 h the bacteria mortalities of the fabricated membrane could reach 96.9%. Furthermore, the antibiofouling tests showed that OP-MWCNTs(1-5) modified membranes have higher anti-biofouling property than the control membrane.

Enhanced production of cytidine 5'-monophosphate using biocatalysis of di-enzymes immobilized on amino-functionalized sepharose

Cytidine 5'-monophosphate(5'-CMP)is an essential nucleotide for additives.In this study,enhanced production of 5'-CMP was realized by the transformation of cytidine using co-immobilized di-enzymes,uridine-cytidine kinase(UCK)and acetate kinase(AcK).The immobilization yield of the enzyme had a clear correlation with the surface charges as zeta potential(ξ).Among them,ε-polylysinefunctionalized sepharose(SA-EPL,ξ=9.31 m V)showed high immobilization yield(78.8%),which was4.9-fold than that of nitrilotriacetic acid functionalized sepharose(SA-NTA,ξ=-12.6 m V).The residual activity of affinity co-immobilized enzyme(EPL-Ni/EPL@Ac K-UCK)was higher than 70.6%after recycled 10 times.Thus,this study provides an effective approach for the production of 5'-CMP with the advantages of low adenosine 5'-triphosphate(ATP)consumption,reduced side reactions,and improved reusability by co-immobilized UCK and Ac K on the functionalized Sepharose.

Preparation of Ionic Liquids Immobilized on FMIL-101 Catalysts for Conversion of CO_(2)to Propylene Carbonate

Metal-organic frameworks(MOFs)have attracted considerable research attention as a new type of porous material for catalytic applications.Herein,2,5-dihydroxyterephthalic acid was proposed to replace conventional terephthalic acid and reacted with chromic nitrate nonahydrate to synthesize a functional metal–organic framework(FMIL-101).This was then used to immobilize various compound ionic liquids to prepare three ionic liquids immobilized on FMIL-101 catalysts,namely,FMIL-101-[HeMIM]Cl/(ZnBr_(2))_(2),FMIL-101-[CeMIM]Cl/(ZnBr_(2))_(2),and FMIL-101-[AeMIM]Br/(ZnBr_(2))_(2).After characterization by Fourier-transform infrared spectroscopy,X-ray diffraction,ultraviolet spectroscopy,thermogravimetry,specific surface area analysis,and scanning electron microscopy,the catalysts were used to mediate cycloaddition reactions between carbon dioxide(CO_(2))and propylene oxide.The effects of reaction temperature,reaction pressure,reaction time,and catalyst dosage on the catalytic performance were investigated.The results revealed that the FMIL-101-supported CIL catalysts afforded the target product propylene carbonate with good catalytic performance and thermal stability.The optimal catalyst,FMIL-101-[CeMIM]Cl/(ZnBr_(2))_(2),displayed a propylene oxide conversion of 98.64%and a propylene carbonate selectivity of 96.63%at a reaction temperature of 110℃,a reaction pressure of 2.0 MPa,a catalyst dosage of 2.0%relative to propylene oxide,and a reaction time of 2.5 h.In addition,the conversion and selectivity of the catalyst decreased slightly after four cycles.Additionally,the catalyst decreased slightly in catalytic performance after being recycled four times.

Changes in calcium accumulation and utilization efficiency and their impact on recycling,immobilization,and export across the oil palm cycle

Effective calcium(Ca)management is crucial for optimizing oil palm cultivation and enhancing crop yield.This study aimed to gain insights into the dynamics of Ca concentration,accumulation,exportation,immobilization,and recycling in various oil palm organs relative to plant age.The experiment was conducted at the Agropalma enterprise site in the northeastern region of Para State,Brazil,evaluating seven plant age treatments:2,3,4,5,6,7,and 8 years old.Employing a completely randomized design with four replications.The results demonstrated an age-related increase in Ca concentration in petioles,rachis,arrows,male inflorescences,peduncles,and fruits.Furthermore,Ca accumulation exhibited an upward trend in all organs with progressing plant age.Notably,the study revealed an enhanced Ca use efficiency across all plant organs in correlation with the age of oil palm cultivation.These findings underscore the dynamic nutritional demands of oil palm,influencing Ca immobilization,cycling,and export throughout its developmental stages.

Recent advances in immobilized enzymes on nanocarriers

Recent progress in nanotechnology has provided high-performance nanomaterials for enzyme immobilization.Nanobiocatalysts combining enzymes and nanocarriers are drawing increasing attention because of their high catalytic performance,enhanced stabilities,improved enzyme-substrate affinities,and reusabilities.Many studies have been performed to investigate the efficient use of cellulose nanocrystals,polydopamine-based nanomaterials,and synthetic polymer nanogels for enzyme immobilization.Various nanobiocatalysts are highlighted in this review,with the emphasis on the design,preparation,properties,and potential applications of nanoscale enzyme carriers and nanobiocatalysts.

Effect Research of Immobilized Algae-bacteria Removal Ammonia Nitrogen of Aquaculture Wastewater and Proposed Model

Applied Immobilized algae bacteria (ABI) to remove ammonia of freshwater aquaculture wastewater. Temperature (T),PH,light intensity (I),dissolved oxygen (DO) and filling rate five factors plays important role in the process of ammonia nitrogen removal ,related data between ammonia removal and five factors was received through multi-factor orthogonal test,and established relations model between the five factor and nitrogen removal. The results show that five-factors had significant effect on AR,and the best combinations for removing AR was temperature 30 ℃,pH=7.0,light intensity 6 000 lux,dissolved oxygen 5.0 mg/L and the fill rate 10%. According to the experimental data,equation model was proposed and coefficient of determination R2 =0.864 8,P<0.05. Samples T-test was done between the model predictions and the actual measured values.Test results showed that the significant difference of overall mean value sig. (2-tailed) was 0.978 (P>0.05),it Shows that had no significant difference between model predictions and the actual measured value,and model had a high degree of fitting.

IMMOBILIZED ASPERGILLUS ORYZAE CELLS AND THEIR ACTIVITIES

Aminoacylase was immobilized on the mycelium cells of Aspergillus oryzae by using ethylenediamine, gelatin and glutylalhyde. The proper immobilized condition was studied by orthogonal experimental design. The immobilized cells with excellent activity and stability for optically resoluting N acetyl DL alanine were obtained. The effects of pH, temperature, ion concentration and substrate concentration on the reactive activity of immobilized cells were studied. The continuous optical resolution of N acetyl DL alanine was investigated respectively in an immobilized cells column (ICC) and in a novel couple immobilized cells bed & membrane reactor(CICBMR). The results indicate that the immobilized cells are suitable for industrial applications.

Decolorization of reactive dyes by laccase immobilized in alginate/gelatin blent with PEG

To achieve effective decolorization of reactive dyes,laccase immobilization was investigated.Laccase 0.2%(m/V)(Denilite IIS) was trapped in beads of alginate/gelatin blent with polyethylene glycol(PEG),and then the supporters were activated by cross-linking with glutaraldehyde.The results of repeated batch decolorization showed that gelatin and appropriate concentration of glutaraldehyde accelerated the decolorization of Reactive Red B-3BF(RRB);PEG had a positive effect on enzyme stability and led to an inc...

Biodegradation of phenol by free and immobilized Acinetobacter sp.strain PD12

A new phenol-degrading bacterium with high biodegradation activity and high tolerance of phenol, strain PD 12, was isolated from the activated sludge of Tianjin Jizhuangzi Wastewater Treatment Facility in China. This strain was capable of removing 500 mg phenol/L in liquid minimal medium by 99.6% within 9 h and metabolizing phenol at concentrations up to 1100 mg/L. DNA sequencing and homologous analysis of 16S rRNA gene identified PD12 to be an Acinetobacter sp. Polyvinyl alcohol （PVA） was used as a gel matrix to immobilize Acinetobacter sp. strain PDI2 by repeated freezing and thawing. The factors affecting phenol degradation of immobilized cells were investigated, and the results showed that the immobilized cells could tolerate a high phenol level and protected the bacteria against changes in temperature and pH. Storage stability and reusability tests revealed that the phenol degradation functions of immobilized cells were stable after reuse for 50 times or storing at 4℃ for 50 d. These results indicate that immobilized Acinetobacter sp. strain PD 12 possesses a good application potential in the treatment of phenol-containing wastewater.

Comparison of Di-n-methyl Phthalate Biodegradation by Free and Immobilized Microbial Cells

To compare the biodegradation of di-n-methyl pathalate by free and immobilized microbial cells. Methods The enrichment and isolation technique was used to isolate the microorganism. The PAV-entrapment method was utilized to immobilize the microorganisms. The scanning electron microscophy (SEM) was used to observe the growth and distribution of microbial cells immobilized inside the PVA bead gels. The GC/MS method was used to identify the main intermediates of DMP degradation. Results The microbial cells could grow quite well in PVA gel. The metabolic pathway did not change before and after immobilization of the microbial cells. The degradation rate of immobilized cells was higher than that of free cells. Conclusion The immobilized microbial cells possess advantages than free cells when applied to the biodegradation of toxic organic pollutants.

Biosorption characteristics of unicellular green alga Chlorella sorokiniana immobilized in loofa sponge for removal of Cr(Ⅲ)

Loofa sponge （LS） immobilized biomass of Chlorella sorokiniana （LSIBCS）, isolated from industrial wastewater, was investigated as a new biosorbent for the removal of Cr（Ⅲ） from aqueous solution. A comparison of the biosorption of Cr（Ⅲ） by LSIBCS and free biomass of C. sorokiniana （FBCS） from 10-300 mg Cr（Ⅲ）/L aqueous solutions showed an increase in uptake of 17.79% when the microalgal biomass was immobilized onto loofa sponge. Maximum biosorption capacity for LSIBCS and FBCS was found to be 69.26 and 58.80 mg Cr（Ⅲ）/g biosorbent, respectively, whereas the amount of Cr（Ⅲ） ions adsorbed onto naked LS was 4.97 mg/g. The kinetics of Cr（Ⅲ） biosorption was extremely rapid and equilibrium was established in about 15 and 20 min by LSIBCS and FBCS, respectively. The biosorption equilibrium was well defined by Langmuir adsorption isotherm model. The biosorption kinetics followed the pseudo-second order kinetic model. The biosorption was found to be pH dependent and the maximum sorption occurred at the solution pH 4.0. Desorption studies showed that 98% of the adsorbed Cr（Ⅲ） could be desorbed with 0.1 mol/L HNO3, while other desorbing agents were less effective in the order： EDTA 〉 H2SO4 〉 CH3COOH 〉 HCl. The regenerated LSIBCS retained 92.68% of the initial Cr（Ⅲ） binding capacity up to five cycles of reuse in continuous flow-fixed bed columns. The study revealed that LSIBCS could be used as an effective biosorbent for the removal of Cr（Ⅲ） from wastewater.

Biodegradation of benzo[a]pyrene in soil by Mucor sp.SF06 and Bacillus sp.SB02 co-immobilized on vermiculite

Two indigenous microorganisms, Bacillus sp. SB02 and Mucor sp. SF06, capable of degrading polycyclic aromatic hydrocarbons （PAHs） were co-immobilized on vermiculite by physical adsorption and used to degrade benzo[a] pyrene （BaP）. The characteristics of BaP degradation by both free and co-immobilized microorganism were then investigated and compared. The removal rate using the immobilized bacterial-fungal mixed consortium was higher than that of the freely mobile mixed consortium. 95.3% of BaP was degraded using the co-immobilized system within 42 d, which was remarkably higher than the removal rate of that by the free strains. The optimal amount of inoculated co-immobilized system for BaP degradation was 2%. The immobilized bacterial-fungal mixed consortium also showed better water stability than the free strains. Kinetics of BaP biodegradation by co-immobilized SF06 and SB02 were also studied. The results demonstrated that BaP degradation could be well described by a zero-order reaction rate equation when the initial BaP concentration was in the range of 10--200 mg/kg. The scanning electronic microscope （SEM） analysis showed that the co-immobilized microstructure was suitable for the growth of SF06 and SB02. The mass transmission process of co-immobilized system in soil is discussed. The results demonstrate the potential for employing the bacterial-fungal mixed consortium, co-immobilized on vermiculite, for in situ bioremediation of BaP.

Comparison of four supports for adsorption of reactive dyes by immobilized Aspergillus fumigatus beads

Four materials, sodium carboxymethylcellulose （Na-CMC）, sodium alginate （SA）, polyvinyl alcohol （PVA）, and chitosan （CTS）, were prepared as supports for entrapping fungus Aspergillusfumigatus. The adsorption of synthetic dyes, Reactive Brilliant Blue KN- R, and Reactive Brilliant Red K-2BP, by these immobilized gel beads and plain gel beads was evaluated. The adsorption efficiencies of Reactive Brilliant Red K-2BP and Reactive Brilliant Blue KN-R by CTS immobilized beads were 89.1% and 93.5% in 12 h, respectively. The adsorption efficiency by Na-CMC immobilized beads was slightly lower than that of mycelial pellets. But the dye culture mediums were almost completely decolorized in 48 h using the above-mentioned two immobilized beads （exceeding 95%）. The adsorption efficiency by SA immobilized beads exceeded 92% in 48 h. PVA-SA immobilized beads showed the lowest adsorption efficiency, which was 79.8% for Reactive Brilliant Red K-2BP and 92.5% for Reactive Brilliant Blue KN-R in 48 h. Comparing the adsorption efficiency by plain gel beads, Na-CMC plain gel beads ranked next to CTS ones. SA and PVA-SA plain gel beads hardly had the ability of adsorbing dyes. Subsequently, the growth of mycelia in Na-CMC and SA immobilized beads were evaluated. The biomass increased continuously in 72 h. The adsorption capacity of Reactive Brilliant Red K-2BP and Reactive Brilliant Blue KN-R by Na-CMC immobilized beads was 78.0 and 86.7 mg/g, respectively. The SEM micrographs show that the surface structure of Na-CMC immobilized bead is loose and finely porous, which facilitates diffusion of the dyes.

Production of laccase by Coriolus versicolor and its application in decolorization of dyestuffs: (Ⅱ) Decolorization of dyes by laccase containing fermentation broth with or without self-immobilized mycelia

The capability of decolorization for commercial dyes by Coriolus versicolor fermentation broth containing laccase with or without immobilized mycelium was evaluated. With cell free fermentation broth containing laccase, high decolorization ratio was achieved for acid orange 7, but not for the other dyes concerned. The immobilized mycelium was proved to be more efficient than the cell free system. All the four dyestuffs studied were found being decolourized with certain extent by immobilized mycelium. The repeated batch decolorization was carried out with satisfactory results. The experimental data showed that the continuous decolorization of wastewater from a printing and dyeing industry was possible by using the self immobilized C. Versicolor.

Copper biosorption on immobilized seaweed biomass:Column breakthrough characteristics

The biosorption of copper by the brown seaweed Sargassum baccularia, immobilized onto polyvinyl alcohol （PVA） gel beads, was investigated with fixed-bed experiments. Laboratory-scale column tests were performed to determine breakthrough curves with varying flow rates and feed concentrations. A theoretical fixed-bed model, known as the Bohart-Adams equation, was evaluated in simulating the experimental breakthrough curves. The Bohart-Adams model qualitatively predicted the breakthrough trends. PVA- immobilized seaweed biomass beads were amenable to efficient regeneration with aqueous solution containing the chelating agent ethylenediaminetetraacetic acid （EDTA）. The biosorbent retained most of its original uptake capacity over three cycles of use. The excellent reusability of the biosorbent could lead to the development of a viable metal remediation technology.

Removal of Nitrogen, Phosphorus, and Organic Pollutants From Water Using Seeding Type Immobilized Microorganisms

Objective To study the possibility of removing nitrogen, phosphorus, and organic pollutants using seeding type immobilized microorganisms. Methods Lakes P and M in Wuhan were chosen as the objects to study the removal of nitrogen, phosphorus, and organic pollutants with the seeding type immobilized microorganisms. Correlations between the quantity of heterotrophic bacteria and the total nitrogen （TN）, total phosphorus （TP）, and total organic carbon （TOC） in the two lakes were studied. The dominant bacteria were detected, inoculated to the sludge and acclimated by increasing nitrogen, phosphorus and decreasing carbon source in an intermittent, time-controlled and fixed-quantity way. The bacteria were then used to prepare the seeding type immobilized microorganisms, selecting diatomite as the adsorbent cartier. The ability and influence factors of removing nitrogen, phosphorus, and organic pollutant from water samples by the seeding type immobilized microorganisms were studied. Results The coefficients of the heterotrophic bacterial quantity correlated with TOC, TP, and TN were 0.9143, 0.8229, 0.7954 in Lake P and 0.9168, 0.7187, 0.6022 in Lake M. Ten strains of dominant heterotrophic bacteria belonging to Pseudomonas, Coccus, Aeromonas, Bacillus, and Enterobateriaceae, separately, were isolated. The appropriate conditions for the seeding type immobilized microorgansims in purifying the water sample were exposure time=24 h, pH=7.0-8.0, and quantity of the immobilized microorganisms=0.75-1g/50 mL. The removal rates of TOC, TP, and TN under the above conditions were 80.2%, 81.6%, and 86.8%, respectively. Conclusion The amount of heterotrophic bacteria in the two lakes was correlated with TOC, TP, and TN. These bacteria could be acclimatized and prepared for the immobilized microorganisms which could effectively remove nitrogen, phosphorus, and mixed organic pollutants in the water sample.

Repeated-Batch and Continuous Production of L-Lactic Acid by Rhizopus oryzae Immobilized in Calcium Alginat Beads:ReactorPerformance and Kinetic Model

Repeated-batch and continuous production of L-lactic acid by immobilized Rhizopusoryzae with calcium alginate entrapment method in a three-phase fluidized-bed bioreactor was stud-ied.The operation conditions were optimized.The productivity based on total reactor volume wasabout 3 times higher than that with free cells in a traditional stirred tank bioreactor.A mathemat-ical model was proposed and the model predictions were in good agreement with the experimentaldat.

Studies on Manganese Peroxidase Immobilized in Gelatin-containing Microemulsion-based Gels

The immobilized technique of manganese peroxidase(MnP) in gelatin-containing microemulsion-based gels and the effects of storage time and reuse times on its catalytic activity were studied. The results show that the MnP immobilized together with Mn 2+ and H_2O_2 could effectively oxidize syringaldazine in n-heptane. The immobilized MnP still had a high catalytic activity after one-month storage under a freezing condition. The reuse times have a relation to the amount of the immobilized H_2O_2. When the amount of the immobilized H_2O_2 is sufficient, the microemulsion-based gels containing MnP could be used many times.

Zwitterionic polymer-coated porous poly(vinyl acetate–divinyl benzene)microsphere: A new support for enhanced performance of immobilized lipase

Enzyme immobilization has attracted great attention for improving the performance of enzymes in industrial applications.This work was designed to create a new support for Candida rugosa lipase(CRL)immobilization.A porous poly(vinyl acetate–divinyl benzene)microsphere coated by a zwitterionic polymer,poly(maleic anhydride-alt-1-octadecene)and N,N-dimethylethylenediamine derivative,was developed for CRL immobilization via hydrophobic binding.The catalytic activity,reaction kinetics,stabilities and reusability of the immobilized CRL were investigated.It demonstrated the success of the zwitterionic polymer coating and subsequent CRL immobilization on the porous microsphere.The immobilized lipase(p2-MS-CRL)reached27.6 mg·g^-1 dry carrier and displayed a specific activity 1.5 times higher than free CRL.The increase of Vmax and decrease of Kmwere also observed,indicating the improvement of catalytic activity and enzyme-substrate affinity of the immobilized lipase.Besides,p2-MS-CRL exhibited significantly enhanced thermal stability and pH tolerance.The improved performance was considered due to the interfacial activation regulated by the hydrophobic interaction and stabilization effect arisen by the zwitterionic polymer coating.This study has thus proved the advantages of the zwitterionic polymer-coated porous carrier for lipase immobilization and its potential for further development in various enzyme immobilizations.