Experimental and CFD Study on the Role of Fluid Flow Pattern on Membrane Permeate Flux

This paper reports a study on the role of fluid flow pattern and dynamic pressure on the permeate flux through a micro filtration membrane in laboratory scale.For this purpose,a dead-end membrane cell equipped with a marine type impeller was used.The impeller was set to rotate in the clockwise and counter clockwise directions with the same angular velocities in order to illustrate the effect of rotation direction on permeate flux.Consequently, permeate fluxes were measured at various impeller rotational speeds.The computational fluid dynamics（CFD）predicted dynamic pressure was related to the fluxes obtained in the experiments.Using the CFD modeling,it is proven that the change in dynamic pressure upon the membrane surface has direct effect on the permeate flux.

Impacts of weaning age on dietary needs of whey permeate for pigs at 7 to 11 kg body weight

Background:Whey permeate is an effective lactose source for nursery pigs and the most benefits are obtained when pigs are at 7 to 11 kg BW.Altering weaning ages could cause different length of early-weaner phases until 7 kg BW and thus it would influence the dietary need of whey permeate during 7 to 11 kg BW of pigs.This study aimed to evaluate if weaning ages would affect the dietary needs of whey permeate for optimum growth performance of pigs at 7 to 11 kg BW.Methods:A total of 1,632 pigs were weaned at d 21(d 21.2±1.3)or d 25(d 24.6±1.1)after birth.All pigs had a common early-weaner feeds until they reached 7 kg BW.When pigs reached 7 kg BW within a weaning age group,they were allotted in a randomized complete block design(2×4 factorial).Two factors were weaning age groups(21 and 25 d of age)and varying whey permeate levels(7.50%,11.25%,15.00%,and 18.75%).Data were analyzed using the GLM and NLIN procedures of SAS for slope-ratio and broken-line analyses to determine the growth response to whey permeate and optimal daily whey permeate intake for the growth of the pigs weaned at different ages.Results:Pigs weaned at 21 d of age had a common diet for 11 d to reach 7 kg BW whereas pigs weaned at 25 d of age needed 2 d.The G:F of pigs weaned at 25 d of age responded to increased daily whey permeate intake greater(P<0.05)than pigs weaned at 21 d of age.Breakpoints were obtained(P<0.05)at 88 and 60 g/d daily whey permeate intake or 17.0%and 14.4%of whey permeate for G:F of pigs weaned at 21 and 25 d of age,respectively.Conclusion:Pigs weaned at an older age with a short early-weaner phase had a greater growth response to whey permeate intake compared with pigs weaned at a younger age with a long early-weaner phase.Altering weaning ages affected dietary needs of whey permeate for optimum growth performance of pigs from 7 to 11 kg BW.

Simultaneous recovery of phosphorus and nitrogen from liquid digestate by vacuum membrane distillation with permeate fractional condensation

A vacuum membrane distillation(VMD)process with permeate fractional condensation on membrane downstream has been developed for simultaneous recovery of phosphorus and nitrogen from liquid digestate.The polytetrafluoroethylene(PTFE)membrane flux could reach 6000 g·m-2·h-1 with the rejection efficiency of total phosphorus(TP)over 0.99,under the condition of flowrate being 120 L·h-1 and temperature being 40°C.Membrane fouling occurred with a film of organics and microorganism deposited on the surface of the membrane.Membrane flux could be reversed after the membrane was rinsed by water.Higher feed temperature and flowrate could improve the membrane flux,while hardly affect the rejection efficiency of total phosphorus.The concentration of TP could reach 1600 mg·L-1 after membrane distillation,which is about 5 times of that in initial liquid digestate.On the downstream of the membrane,some of the permeate vapor was condensed under the vacuum condition and most of water was collected here.The remaining vapor enriched with total nitrogen(TN)was compressed and pumped to the atmospheric condition to condense.The TN concentration in atmospheric condensate was as high as 7000 mg·L-1 with the process separation factor for ammonia being enhanced to 114.

Antifungal Activity against <i>Aspergillus parasiticus</i>of Supernatants from Whey Permeates Fermented with Kefir Grains

Aspergillus parasiticus, a common fungal contaminant in food, produces aflatoxin B1, which is classified as human carcinogen. Kefir is an ancient fermented beverage obtained by the fermentation of different substrates with kefir grains. A very important waste produced by the dairy cheese industry is the whey permeate, which nowadays is a strong ambient contaminant. The aim of this work was to assess the effect of whey permeates fermented with kefir grains against A. parasiticus growth, aflatoxin B1 biosynthesis, and the kefir microorganisms protection against the cell damage produced by aflatoxin B1. It was observed that kefir-cell-free-supernatants (CFS) produced fungal inhibition. A fungicidal effect was observed with 65% v/v of CFS in the culture medium (final pH 4.55 and total undissociated lactic and acetic acid concentration 34.08 mM). Under these conditions, aflatoxin production was not detected. Finally, it was found that non-viable kefir microorganisms protected HepG2 cells from the damage produced by aflatoxin B1.

Application of Whey Permeate Fermented with Kefir Grains for the Shelf-Life Improvement of Food and Feed

Fungal contamination by Aspergillus parasiticus and A. flavus causes negative effects on the production of food cereals. Kefir is an ancient fermented beverage obtained by the fermentation of different substrates with kefir grains. An important waste produced by the dairy cheese industry is the whey permeate, which nowadays is a strong ambient contaminant. The aim of this work was the standardization of the whey permeate fermenting conditions with kefir grains, the assessment of the antifungal activity of the cell-free-supernatants (CFS) from these fermentations and to compare it with that obtained with CFS of milk fermented with kefir grains. Finally, we studied if the addition of kefir fermented whey permeate to food (bread) and feed (poultry) could produce shelf life improvement. The optimal condition to obtain CFS with fungicidal effect was a fermentation with 10% w/v of kefir grains, at 30°C, for 24 hours until a pH 3.7. We found that CFS from whey permeate caused fungal inhibition, whereas CFS of kefir grains grown in milk showed lower antifungal activity. Additionally, the addition of kefir-fermented whey permeates in food (bread) and feed (poultry) improved their resistance to fungal contamination. This is the first report about the application of kefir-fermented whey permeate to improve the shelf life, suggesting its potential use as a biopreservative.

A METHOD FOR DETERMINATION OF CONCENTRATION OF ATOMIC HYDROGEN PERMEATED IN MULTI-LAYER STRUCTURE WALL OF HYDROGENATION REACTORS

It was proposed how the concentration distribution was calculated in the treble lager wall of hgdrogenation reactor according to the principle of hydrogen diffusion at the steady state in this paper. Based on the steady hydrogen permeation current density i∞ measund with the hydrogen probe at a given temperature, the hydmpen concentrationson the key interfaces and hydrogen distribution at any given mdial profile in the single, double or treble layer wall of hydrogenation reactor could be found by applying the presented equations throoph suitable parmeters ioput. The theoretical bases were provided for developing the nondestructive probing technique of the concentration of atomic hydmpen in the wallS of hydrogenation reactors.

Dewatering of Scenedesmus obliquus Cultivation Substrate with Microfiltration:Potential and Challenges for Water Reuse and Effective Harvesting

In the microalgae harvesting process,which includes a step for dewatering the algal suspension,directly reusing extracted water in situ would decrease the freshwater footprint of cultivation systems.Among various algae harvesting techniques,membrane-based filtration has shown numerous advantages.This study evaluated the reuse of permeate streams derived from Scenedesmus obliquus(S.obliquus)biomass filtration under bench-scale and pilot-scale conditions.In particular,this study identified a series of challenges and mechanisms that influence the water reuse potential and the robustness of the membrane harvesting system.In a preliminary phase of this investigation,the health status of the initial biomass was found to have important implications for the harvesting performance and quality of the permeate stream to be reused;healthy biomass ensured better dewatering performance(i.e.,higher water fluxes)and higher quality of the permeate water streams.A series of bench-scale filtration experiments with different combinations of cross-flow velocity and pressure values were performed to identify the operative conditions that would maximize water productivity.The selected conditions,2.4 m·s^(-1)and 1.4 bar(1 bar=105 Pa),respectively,were then applied to drive pilot-scale microfiltration tests to reuse the collected permeate as a new cultivation medium for S.obliquus growth in a pilot-scale photobioreactor.The investigation revealed key differences between the behavior of the membrane systems at the two scales(bench and pilot).It indicated the potential for beneficial reuse of the permeate stream as the pilot-scale experiments ensured high harvesting performance and growth rates of biomass in permeate water that were highly similar to those recorded in the ideal cultivation medium.Finally,different nutrient reintegration protocols were investigated,revealing that both macro-and micro-nutrient levels are critical for the success of the reuse approach.

Electrifying Ba_(0.5)Sr_(0.5)Co_(0.8)Fe_(0.2)O_(3-δ) for focalized heating in oxygen transport membranes

Industry decarbonization requires the development of highly efficient and flexible technologies relying on renewable energy resources,especially biomass and solar/wind electricity.In the case of pure oxygen production,oxygen transport membranes(OTMs)appear as an alternative technology for the cryogenic distillation of air,the industrially-established process of producing oxygen.Moreover,OTMs could provide oxygen from different sources(air,water,CO_(2),etc.),and they are more flexible in adapting to current processes,producing oxygen at 700^(-1)000℃.Furthermore,OTMs can be integrated into catalytic membrane reactors,providing new pathways for different processes.The first part of this study was focused on electrification on a traditional OTM material(Ba_(0.5)Sr_(0.5)Co_(0.8)Fe_(0.2)O_(3-δ)),imposing different electric currents/voltages along a capillary membrane.Thanks to the emerging Joule effect,the membrane-surface temperature and the associated O_(2) permeation flux could be adjusted.Here,the OTM is electrically and locally heated and reaches 900℃on the surface,whereas the surrounding of the membrane was maintained at 650℃.The O_(2)permeation flux reached for the electrified membranes was~3.7 NmL min^(-1)cm^(-2),corresponding to the flux obtained with an OTM non-electrified at 900℃.The influence of depositing a porous Ce_(0.8)Tb_(0.2)O_(2-δ) catalytic/protective layer on the outer membrane surface revealed that lower surface temperatures(830℃)were detected at the same imposed electric power.Finally,the electrification concept was demonstrated in a catalytic membrane reactor(CMR)where the oxidative dehydrogenation of ethane(ODHE)was carried out.ODHE reaction is very sensitive to temperature,and here,we demonstrate an improvement of the ethylene yield by reaching moderate temperatures in the reaction chamber while the O_(2) injection into the reaction can be easily fine-tuned.

The effect of reactive plasticizer on viscoelastic and mechanical properties of solid rocket propellants based on different types of HTPB resin

Conventional plasticizers deteriorate mechanical and viscoelastic properties of the propellants due to their migration upon aging and long-term storage,which affects reliability and safety properties during exploitation.To address this issue,conventional plasticizer,dioctyl adipate(DOA),is replaced by reactive one,castor oil(CO).In addition,three different types of HTPB were used to obtain propellants with designed viscoelastic and mechanical properties.The CO increased propellants viscosity,without a significant impact on the propellant processability,regardless to the type of prepolymer.Conversely,mechanical properties were different depending on the type of resin,which were further analyzed by gel permeation chromatography(GPC).Addition of CO formed a denser polymer network and shifted T_(g) to higher values,compared to the compositions with DOA.The tensile strength of CO-containing propellants was lower at +20℃ and +50℃ compared to the reference compositions,while the strain at maximum load and strain at break were significantly increased with pronounced plastic deformation,especially for samples at -30℃.The inclusion of CO in the propellants composition gives more room for adjusting a wide range of mechanical properties.

Determination of 14 Organophosphorus Pesticide Residues in Mutton by Gel Permeation Chromatography-Gas Chromatography-Mass Spectrometry(GPC-GC-MS)

[Objectives]This study was conducted to purify mutton samples by gel permeation chromatography(GPC).[Methods]Fourteen organophosphorus pesticide residues in samples were qualitatively and quantitatively analyzed by gas chromatography-mass spectrometry(GC-MS)in selective ion scanning mode(SIM).[Results]The organophosphorus pesticide standard solutions showed good linearity in the mass concentration range of 0.1-10.0μg/ml with correlation coefficients(r)not lower than 0.999,and the detection limits(S=3 N)ranged from 0.01 to 0.05 mg/kg.The average recovery values were in the range of 80.2%-99.7%,with relative standard deviations(RSDs,n=3)in the range of 1.8%-6.3%,at the addition levels of 0.5,1.0 and 2.0 mg/kg.[Conclusions]The method is simple,sensitive and accurate,and can be used for the determination of organophosphorus pesticide residues in mutton.

Dissecting Multiple Arabidopsis CC-NBS-LRR Proteins Structure and Localization

NBS-LRR (nucleotide binding sites and leucine rich repeat) protein plays a crucial role as sentries and as defense activators in plants. The structure and function of NBS-LRR proteins are closely related. Previous articles have announced that the activated ZAR1 (HopZ-Activated Resistance 1) forms a pentamer in the plasma membrane, which is a calcium permeable channel that can trigger plant immune signaling and cell death. However, the structure of galore NBS-LRRs in Arabidopsis is not yet clear. The functional sites of distinct NBS-LRR in cells may vary. In addition, identifying pathogens and activating defense regions may occur in different subcellular compartments. Therefore, dissecting the specific structure and positioning of NBS-LRRs is an indispensable step in understanding their functions. In this article, we exploit AlphaFold to predict the structure of some designed NBS-LRRs, and utilize Agroinfiltration transient expression system, combined with biochemical fractionation, to dissect the localization of these NBS-LRR receptors from Arabidopsis. Structural data indicates that the identified NBS-LRRs share analogous conformation. Membrane fractionation assay demonstrates these NBS-LRRs are mainly associated with the membrane. These data show that the Ca2+-permeable channel activity may be evolutionarily conserved in NBS-LRR of Arabidopsis, and this study provides some reference clues for analyzing the structure and localization patterns of other plant immune receptors.

Research Progress on Application of Borneol As Permeation Enhancer in Functional Cosmetics

Borneol, as a traditional natural permeation enhancer, has been widely used to promote the transdermal absorption of active ingredients. In this review, the mechanism of borneol in promoting permeation by destroying the highly ordered lipid structure of the lipid layer and by destroying the hydrogen-bond network was described. The application of borneol in promoting the transdermal absorption of the active ingredients of traditional Chinese medicine and chemical drugs was introduced. The application of borneol as a natural ingredient added to functional cosmetics was summarized, and its effects on skin-spot treatment, acne skin care, eczema skin care, skin repair and anti-oxidation were introduced. Finally, the possible problems in the application of borneol in cosmetics were put forward, and the application prospect of borneol in the development of cosmetics was given.

The efficacy study of trinity permeation synergism on anti-aging

Background:More and more consumers are paying attention to skin rejuvenation.However,there is a lack of a non-invasive and efficient solution.Objective:To evaluate the efficacy of a trinity permeation synergism(TPS),which consists of a firming essence,an atomizer and a photoelectric penetrator,for facial anti-aging efficacy.Material and methods:In this work,in vitro cell experiments and human efficacy study were used to evaluate the firming and anti-wrinkle effects.Cell experiments were used to verify the effect of the firming essence on the cell proliferation,migration,and anti-inflammation in keratinocytes(HaCaT),and on the gene expression levels of type I and type III collagen(Col-1 and Col-3)and type I matrix metalloproteinase(MMP-1)in human skin fibroblasts(HSF).After in vitro test,60 women aged 35–60 years were enrolled in the randomized test,of which 30 subjects were randomly selected to be the experimental group and treated with the TPS system,while the left 30 subjects were treated with the firming essence only considered as control.After 28 days,skin elasticity,skin redness value,and skin wrinkles were measured to evaluate the efficacy of the TPS system.Results:Cell experiments showed that the firming essence can significantly improve the proliferation and the migration of HaCaT cells.It also promoted the expression level of Col-1 and Col-3 gene,and inhibited the expression level of MMP-1 gene in HSF cells.After confirming the efficacy of firming essence,the efficacy benefit of the TPS was further studied.The 28-day tests show that combined use firming essence with atomizer and penetrator can significantly increase skin elasticity,reduce skin hemoglobin value and skin wrinkles on Day 28.Moreover,all the mentioned improvements are significantly better than that in the control group.Conclusion:Through efficient delivery in the whole process,TPS boosts the efficacy of active components in the firming essence.TPS offers an efficient,non-invasive,and convenient way for enhanced facial rejuvenation efficacy.

An Overview of Soil Improvement through Ground Grouting

Soil is an essential component of what surrounds us in nature, providing as the basis for our infrastructure and construction. However, soil is not always suitable for construction due to a variety of geotechnical issues such as inadequate bearing capacity, excessive settlement, and liquefaction susceptibility. Through improving the engineering qualities of soil, such as strength, permeability, and stability, ground grouting is a specific geotechnical method used. Using a fluid grout mixture injected into the subsurface, holes are filled and weak or loose strata are solidified as the material seeps into the soil matrix. The approach’s adaptability in addressing soil-related issues has made it more well-known in the fields of civil engineering and construction. In the end, this has improved groundwater management, foundation support, and overall geotechnical performance.

Improvement of hydrogen permeation barrier performance by iron sulphide surface films

Fe–S compounds with hexagonal crystal structure are potential hydrogen permeation barrier during H2S corrosion. Hexagonal system Fe–S films were prepared on carbon steel through corrosion and CVD deposition, and the barrier effect of different Fe–S films on hydrogen permeation was tested using electrochemical hydrogen permeation method. After that, the electrical properties of Fe–S compound during phase transformation were measured using thermoelectric measurement system. Results show that the mackinawite has no obvious barrier effect on hydrogen penetration, as a p-type semiconductor, and pyrrhotite (including troilite) has obvious barrier effect on hydrogen penetration,as an n-type semiconductor. Hydrogen permeation tests showed peak permeation performance when the surface was deposited with a continuous film of pyrrhotite (Fe_(1–x)S) and troilite. The FeS compounds suppressed hydrogen permeation by the promotion of the hydrogen evolution reaction, semiconducting inversion from p-to n-type, and the migration of ions at the interface.

Gas-and plasma-driven hydrogen permeation behavior of stagnant eutectic-solid GaInSn/Fe double-layer structure

Gas-driven permeation(GDP)and plasma-driven permeation(PDP)of hydrogen gas through Ga In Sn/Fe are systematically investigated in this work.The permeation parameters of hydrogen through Ga In Sn/Fe,including diffusivity,Sieverts'constant,permeability,and surface recombination coefficient are obtained.The permeation flux of hydrogen through Ga In Sn/Fe shows great dependence on external conditions such as temperature,hydrogen pressure,and thickness of liquid Ga In Sn.Furthermore,the hydrogen permeation behavior through Ga In Sn/Fe is well consistent with the multilayer permeation theory.In PDP and GDP experiments,hydrogen through Ga In Sn/Fe satisfies the diffusion-limited regime.In addition,the permeation flux of PDP is greater than that of GDP.The increase of hydrogen plasma density hardly causes the hydrogen PDP flux to change within the test scope of this work,which is due to the dissolution saturation.These findings provide guidance for a comprehensive and systematic understanding of hydrogen isotope recycling,permeation,and retention in plasma-facing components under actual conditions.

Effect of slag composition on corrosion resistance of high chromia refractory bricks for industrial entrained-flow gasifier

The slag composition corresponding to different coals varies significantly,which directly affects the operation of industrial entrained-flow gasifier and the service life of refractory bricks.In this study,the corrosion resistance of several typical coal slags for gasification on high chromia refractory bricks was comparatively investigated by static laboratory crucible tests and thermodynamic simulations.The results demonstrated that the corrosion degree of high chromia refractory bricks by different coal slags was high-Ca/Na slag>high-Fe slag>high-Si/Al slag.The surface structure of the refractory was relatively flat after corrosion by high-Si/Al slag,and the primary corrosion reaction was the partial dissolution of the matrix by the slag.High-Fe slag was prone to the precipitation of iron phases as well as the formation of(Mg,Fe)(Al,Cr)_(2)O_(4)composite spinel layer at the slag/refractory interface.The high-Ca/Na slag was susceptible to react with the refractory to yield a low melting point phase,which led to the destruction of the matrix structure of the refractory and an isolated distribution of particles.In addition,the monoclinic ZrO_(2) in the refractory reacted with CaO in the slag to formed calcium zirconate,which loosened its phase toughening effect,was the primary factor that aggravated the refractory corrosion.

Research Progress on Application of Borneol as Permeation Enhancer in Functional Cosmetics

Borneol,as a traditional natural permeation enhancer,has been widely used to promote the transdermal absorption of active ingredients.The mechanism of borneol in promoting permeation by destroying the highly ordered lipid structure of the lipid layer and by destroying the hydrogen-bond network was described.The application of borneol in promoting the transdermal absorption of the active ingredients of traditional Chinese medicine and chemical drugs was introduced.The application of borneol as a natural ingredient added to functional cosmetics was summarized,and its effects on skin-spot treatment,acne skin care,eczema skin care,skin repair and anti-oxidation were introduced.Finally,the possible problems in the application of borneol in cosmetics were put forward,and the application prospect of borneol in the development of cosmetics was given。

凝胶渗透色谱和气相色谱-质谱法测定动物食品中27种有机氯和15种拟除虫菊酯类农药残留量

A GC-MS method for the determination of 27 organochlorine pesticides and 15 Pyrethroid pesticides in animal food is established.The method was based on Gel Permeation chromatography combined with solid-phase extraction for sample preparation.Rapid qualitative and quantitative analyses was carried out by gas chromatography-mass spectrometry under the selective-ion monitoring mode.The experimental results showed that the correlation coefficients were better than 0.99,the recoveries for spiked standards were 70%-104%,the relative standard deviations were 2.1%-15.9%.

Study on ternary polymerization of toluene diisocyanate

For the production of reactive polyurethane cross-linkinger and curing agents, 2, 4-diisocyanate toluene （TDI） terpolymer, which possesses the rigid structures of hexatomic ring and three reactive functional groups, was synthesized and characterized by the Fourier transform infrared （FFIR）, the gel permeation chromatography （GPC） and the chemical analysis methods. The reaction conditions were studied and optimized. A tracking research on the polymerization process of TDI was taken by using the GPC. The formation processes of the terpolymer, oligomers and higher-polymers were also dealt with. Results show that the TDI terpolymer can be prepared in the presence of Cat-3 catalyst and at the reaction temperature of （60 ±2）℃. The reaction time is short, its outcomes have narrow molecular weights distribution, namely molecular weights from 530 to 550, Mw/Mn =1.10, and the mass fraction of NCO is （25. 0 ± 0. 5）%. With the reaction time prolonging, however, TDI can be further higher-polymedzed to form higher-polymers. Benzoyl chloride （0. 4%, mass fraction）, as the stabilizing agent, can effectively inhibit the occurrence of higher-polymerization. The obtained TDI terpolymer can be stable for more than half a year.