A new procedure of determining optimal C/N (the rate of carbon source to nitrogen source) of mixed distillers' grains for combined bacteria synergic fermentation is established. At the same time an improved method...A new procedure of determining optimal C/N (the rate of carbon source to nitrogen source) of mixed distillers' grains for combined bacteria synergic fermentation is established. At the same time an improved method evaluating bacteria growth, called method of dry cell weighing by filtering is developed. For each combination of C and N, their initial and residual contents before and after fermentation respectively are determined. Then followed the calculation of utilization of C and N sources by the compound bacteria. The optimal C/N is finally located from among the utilization of C and N of several combinations and the weight of produced mass of oven dried thallus. The conditions of fermentation are: inoculum size 10%, temperature 30 0℃, rotational speed 170 r/min, shake culture time 48h. The best results obtained from orthogonal experiments are: maximum mass of oven dried thallus is 14 693g in a liter liquid medium, maximum utilization rate of carbon source is 98 13% and maximum utilization rate of nitrogen is 78 14%. Optimal C/N is 5 1.展开更多
The effect of popping and fermentation on protein quality of three different varieties of amaranth grains cultivated in Ethiopia was evaluated. Total lysine content of the grains was higher than that of commonly avail...The effect of popping and fermentation on protein quality of three different varieties of amaranth grains cultivated in Ethiopia was evaluated. Total lysine content of the grains was higher than that of commonly available cereals but close to that of legumes. Methionine and cysteine contents in the grains were also higher than that found in cereal and legume proteins. Percentage of total indispensable amino acids, excluding tryptophan, was 43% - 49%, which was higher than WHO reference pattern (31%). Popping resulted in 36% and 37% reduction in total lysine and cysteine contents, respectively, whereas fermentation reduced cysteine, lysine and methionine contents by 16%, 20% and 20%, respectively. From the free amino acids, histidine was the major indispensable amino acid but threonine was not detected. During popping, all free amino acids, except threonine, were reduced. On the other hand, fermentation significantly increased (p < 0.01) most amino acids except arginine, which was significantly decreased (p < 0.01), and tyrosine and glutamic acid, for which no change was observed. Popping decreased in vitro protein digestibility (IVPD) by 8.3% - 17.1% while fermentation increased IVPD by 4.8% - 7.5%. Substitution of amaranth for wheat and/or maize during complementary food formulation could contribute much to the daily requirements of indispensable amino acids of young children.展开更多
Background: Brewers' spent grain(BSG) typically contains 20% – 29% crude protein(CP) with high concentrations of glutamine, proline and hydrophobic and non-polar amino acid, making it an ideal material for produc...Background: Brewers' spent grain(BSG) typically contains 20% – 29% crude protein(CP) with high concentrations of glutamine, proline and hydrophobic and non-polar amino acid, making it an ideal material for producing valueadded products like bioactive peptides which have antioxidant properties. For this study, protein was extracted from BSG, hydrolyzed with 1% alcalase and flavourzyme, with the generated protein hydrolysates(AlcH and FlaH)showing antioxidant activities. This study evaluated the effects of AlcH and FlaH on gas production, ruminal fermentation characteristics, nutrient disappearance, microbial protein synthesis and microbial community using an artificial rumen system(RUSITEC) fed a high-grain diet.Results: As compared to the control of grain only, supplementation of FlaH decreased(P < 0.01) disappearances of dry matter(DM), organic matter(OM), CP and starch, without affecting fibre disappearances;while AlcH had no effect on nutrient disappearance. Neither AlcH nor FlaH affected gas production or VFA profiles, however they increased(P < 0.01) NH_3-N and decreased(P < 0.01) H_2 production. Supplementation of FlaH decreased(P < 0.01)the percentage of CH_4 in total gas and dissolved-CH_4(dCH_4) in dissolved gas. Addition of monensin reduced(P < 0.01) disappearance of nutrients, improved fermentation efficiency and reduced CH_4 and H_2 emissions.Total microbial nitrogen production was decreased(P < 0.05) but the proportion of feed particle associated(FPA) bacteria was increased with FlaH and monensin supplementation. Numbers of OTUs and Shannon diversity indices of FPA microbial community were unaffected by AlcH and FlaH;whereas both indices were reduced(P < 0.05) by monensin. Taxonomic analysis revealed no effect of AlcH and FlaH on the relative abundance(RA) of bacteria at phylum level, whereas monensin reduced(P < 0.05) the RA of Firmicutes and Bacteroidetes and enhanced Proteobacteria. Supplementation of FlaH enhanced(P < 0.05) the RA of genus Prevotella, reduced Selenomonas, Shuttleworthia, Bifidobacterium and Dialister as compared to control;monensin reduced(P < 0.05) RA of genus Prevotella but enhaced Succinivibrio.Conclusions: The supplementation of FlaH in high-grain diets may potentially protect CP and starch from ruminal degradation, without adversely affecting fibre degradation and VFA profiles. It also showed promising effects on reducing CH_4 production by suppressing H_2 production. Protein enzymatic hydrolysates from BSG using flavourzyme showed potential application to high value-added bio-products.展开更多
This study aimed to enhance acid production rate and yield of citrus vinegar, and improve the quality of liquid fermented with fruit juice. [ Method] The saccharification process of citrus vinegar was investigated pre...This study aimed to enhance acid production rate and yield of citrus vinegar, and improve the quality of liquid fermented with fruit juice. [ Method] The saccharification process of citrus vinegar was investigated preliminarily with fruit-grain mixed fermentation method using liquor starters as saccharif- erous agents. [Result] The results indicated that the optimal glutinous rice saccharification conditions were as follows： fruit-grain ratio 3： 1, Aspergillus niger- Monascus purpureus ratio 3： 1, saccharifieafion temperature 60℃, and saccharification time 2.5 h. Under the optimized saccharification conditions, reducing sugar content in saceharified glutinous rice reached 146.43 mg/ml; after fermentation, alcohol content in fermentation broth was 6%, amino nitrogen content was 0.44 mg/ml, and acid yield was 3.1 g/L. [ Conclusion] Citrus vinegar brewed based on the optimized technological conditions exhibited better sensory and physico-chemical properties than that brewed with pure juice.展开更多
文摘A new procedure of determining optimal C/N (the rate of carbon source to nitrogen source) of mixed distillers' grains for combined bacteria synergic fermentation is established. At the same time an improved method evaluating bacteria growth, called method of dry cell weighing by filtering is developed. For each combination of C and N, their initial and residual contents before and after fermentation respectively are determined. Then followed the calculation of utilization of C and N sources by the compound bacteria. The optimal C/N is finally located from among the utilization of C and N of several combinations and the weight of produced mass of oven dried thallus. The conditions of fermentation are: inoculum size 10%, temperature 30 0℃, rotational speed 170 r/min, shake culture time 48h. The best results obtained from orthogonal experiments are: maximum mass of oven dried thallus is 14 693g in a liter liquid medium, maximum utilization rate of carbon source is 98 13% and maximum utilization rate of nitrogen is 78 14%. Optimal C/N is 5 1.
文摘The effect of popping and fermentation on protein quality of three different varieties of amaranth grains cultivated in Ethiopia was evaluated. Total lysine content of the grains was higher than that of commonly available cereals but close to that of legumes. Methionine and cysteine contents in the grains were also higher than that found in cereal and legume proteins. Percentage of total indispensable amino acids, excluding tryptophan, was 43% - 49%, which was higher than WHO reference pattern (31%). Popping resulted in 36% and 37% reduction in total lysine and cysteine contents, respectively, whereas fermentation reduced cysteine, lysine and methionine contents by 16%, 20% and 20%, respectively. From the free amino acids, histidine was the major indispensable amino acid but threonine was not detected. During popping, all free amino acids, except threonine, were reduced. On the other hand, fermentation significantly increased (p < 0.01) most amino acids except arginine, which was significantly decreased (p < 0.01), and tyrosine and glutamic acid, for which no change was observed. Popping decreased in vitro protein digestibility (IVPD) by 8.3% - 17.1% while fermentation increased IVPD by 4.8% - 7.5%. Substitution of amaranth for wheat and/or maize during complementary food formulation could contribute much to the daily requirements of indispensable amino acids of young children.
基金financially supported by the Agriculture and Agri-Food Canada(AAFC) Growing forward program (GF2#1542)。
文摘Background: Brewers' spent grain(BSG) typically contains 20% – 29% crude protein(CP) with high concentrations of glutamine, proline and hydrophobic and non-polar amino acid, making it an ideal material for producing valueadded products like bioactive peptides which have antioxidant properties. For this study, protein was extracted from BSG, hydrolyzed with 1% alcalase and flavourzyme, with the generated protein hydrolysates(AlcH and FlaH)showing antioxidant activities. This study evaluated the effects of AlcH and FlaH on gas production, ruminal fermentation characteristics, nutrient disappearance, microbial protein synthesis and microbial community using an artificial rumen system(RUSITEC) fed a high-grain diet.Results: As compared to the control of grain only, supplementation of FlaH decreased(P < 0.01) disappearances of dry matter(DM), organic matter(OM), CP and starch, without affecting fibre disappearances;while AlcH had no effect on nutrient disappearance. Neither AlcH nor FlaH affected gas production or VFA profiles, however they increased(P < 0.01) NH_3-N and decreased(P < 0.01) H_2 production. Supplementation of FlaH decreased(P < 0.01)the percentage of CH_4 in total gas and dissolved-CH_4(dCH_4) in dissolved gas. Addition of monensin reduced(P < 0.01) disappearance of nutrients, improved fermentation efficiency and reduced CH_4 and H_2 emissions.Total microbial nitrogen production was decreased(P < 0.05) but the proportion of feed particle associated(FPA) bacteria was increased with FlaH and monensin supplementation. Numbers of OTUs and Shannon diversity indices of FPA microbial community were unaffected by AlcH and FlaH;whereas both indices were reduced(P < 0.05) by monensin. Taxonomic analysis revealed no effect of AlcH and FlaH on the relative abundance(RA) of bacteria at phylum level, whereas monensin reduced(P < 0.05) the RA of Firmicutes and Bacteroidetes and enhanced Proteobacteria. Supplementation of FlaH enhanced(P < 0.05) the RA of genus Prevotella, reduced Selenomonas, Shuttleworthia, Bifidobacterium and Dialister as compared to control;monensin reduced(P < 0.05) RA of genus Prevotella but enhaced Succinivibrio.Conclusions: The supplementation of FlaH in high-grain diets may potentially protect CP and starch from ruminal degradation, without adversely affecting fibre degradation and VFA profiles. It also showed promising effects on reducing CH_4 production by suppressing H_2 production. Protein enzymatic hydrolysates from BSG using flavourzyme showed potential application to high value-added bio-products.
基金Supported by Project for Agro-scientific Research in the Public Interest of Science and Technology Department of Zhejiang Province(2012C22092)
文摘This study aimed to enhance acid production rate and yield of citrus vinegar, and improve the quality of liquid fermented with fruit juice. [ Method] The saccharification process of citrus vinegar was investigated preliminarily with fruit-grain mixed fermentation method using liquor starters as saccharif- erous agents. [Result] The results indicated that the optimal glutinous rice saccharification conditions were as follows： fruit-grain ratio 3： 1, Aspergillus niger- Monascus purpureus ratio 3： 1, saccharifieafion temperature 60℃, and saccharification time 2.5 h. Under the optimized saccharification conditions, reducing sugar content in saceharified glutinous rice reached 146.43 mg/ml; after fermentation, alcohol content in fermentation broth was 6%, amino nitrogen content was 0.44 mg/ml, and acid yield was 3.1 g/L. [ Conclusion] Citrus vinegar brewed based on the optimized technological conditions exhibited better sensory and physico-chemical properties than that brewed with pure juice.
