Deep eutectic solvents for separation and purification applications in critical metal metallurgy:Recent advances and perspectives

Solvent extraction,a separation and purification technology,is crucial in critical metal metallurgy.Organic solvents commonly used in solvent extraction exhibit disadvantages,such as high volatility,high toxicity,and flammability,causing a spectrum of hazards to human health and environmental safety.Neoteric solvents have been recognized as potential alternatives to these harmful organic solvents.In the past two decades,several neoteric solvents have been proposed,including ionic liquids(ILs)and deep eutectic solvents(DESs).DESs have gradually become the focus of green solvents owing to several advantages,namely,low toxicity,degradability,and low cost.In this critical review,their classification,formation mechanisms,preparation methods,characterization technologies,and special physicochemical properties based on the most recent advancements in research have been systematically described.Subsequently,the major separation and purification applications of DESs in critical metal metallurgy were comprehensively summarized.Finally,future opportunities and challenges of DESs were explored in the current research area.In conclusion,this review provides valuable insights for improving our overall understanding of DESs,and it holds important potential for expanding separation and purification applications in critical metal metallurgy.

The combination of 1-octyl-3-methylimidazolium tetrafluorborate with TBAB or THF on CO2 hydrate formation and CH4 separation from biogas

[C_8min] BF_4 was used in this work to combine with TBAB or THF for the investigation about thermodynamic and kinetic additives on CO_2 and CH_4/CO_2 hydrates. The results show that [C_8min] BF_4 has the inhibition effect on the equilibrium of hydrate formation. About the kinetic study, [C_8 min] BF_4 could improve the rate of CO_2 hydrate formation and increase the gas uptake in hydrate phase. At the same time, the combination of TBAB and [C8 min] BF_4 could increase the mole friction of CH_4 in residual gas comparing with the data in THF solution. CH_4 separation efficiency was strongly enhanced. Since that the size of CO_2 and CH_4 molecules are similar, CH_4 and CO_2 could form the similar hydrate, so the recovery of CH_4 from biogas decreases lightly. The CH_4 content in biogas can purified from 67 mol% to 77 mol% after one-stage hydrate formation. In addition, the combination of THF and[C_8 min] BF_4 do not have obvious promoting effect on CH_4 separation comparing with the gas separation results in pure THF solution.

Selective depression mechanism of combination of lime and sodium humate on arsenopyrite in flotation separation of Zn-As bulk concentrate

Lime(CaO)and sodium humate(NaHA)were used as the combined depressant for arsenopyrite pre-treated by CuSO_(4) and butyl xanthate.Micro-flotation tests show that the combined depressant CaO and NaHA achieved the selective depression of arsenopyrite.Closed-circuit lab-scale test results indicate that the synergistic effect of CaO+NaHA achieved a satisfactory flotation separation of sphalerite and arsenopyrite,for which the Zn grade and recovery of Zn concentrate were 51.21%and 92.21%,respectively.Contact angle measurements,adsorption amount measurements and X-ray photoelectron spectroscopy analysis indicate that the dissolved calcium species(mainly as Ca(2+))were adsorbed on the mineral surfaces,thereby promoting NaHA adsorption.Moreover,the surface of the arsenopyrite absorbed more amount of calcium species and NaHA than that of the sphalerite,thereby accounting for the strong hydrophilic surface of arsenopyrite.The adsorption of NaHA on arsenopyrite was mainly chemical adsorption through its carboxyl groups and Ca atoms,whereas that on sphalerite surface was relatively weak.

Separation and Purification of Recombinant Hirudin Variant 3 from Bacillus subtilis

[ Objective] The research aimed to get the optimized separation and purification conditions of the hirudin produced from Bacillus subtilis DB403 （pUBH5）. [Method] Through the systemic pretreatment, preliminary chromatography and fine chromatography. [Result]The optimized separation and purification conditions were that： Supernatant was treated by trichloroacetic acid, then by ultrafiltration desalt and anion exchange chromatography. Strong anion Q F. F. was better than weak anion DEAE F.F. The proper balanced solution was Tris-HCI （ pH 8.0）. The proper conductivity was 6 ms/cm. The maximum applied sample was 240 ATU/ml to matrix of strong anion Q F. F. This optimized procedure was magnified in strong anion exchange HiPrep 16/10Q with the 90% recovery and 70.2% purity. The purification of gel filtration of Sephacryl S-100 to hirudin was not relative to flow rate within certain scope. The application size of sample was 10 ml. The purity checked by HPLC was 95.1%, and the recovery was 93%, and the band of SDS-PAGE was single. [ Conclusion] The research provided the reference of the further industrialization separation and purification of hiruin.

A new combination process of distillation with salt extraction for separating organic solvent-water azeotropes

A novel process which can purify the organic solvents from their azeotropes with water is proposed. In this process,water can be drained off both from bottom and overhead of tower at the same time,and the organic solvent is concentrated in the tower and accumulated in the middle vessel at last. So the progress is time-shortened and energy-saving. The product purity is 99. 8% and the product yield is more than 99.5%. Simulation of liquid-liquid equilibrium (LLE) and the equipment operation data agree well with the experiment.

Back to the drawing board:Overview of the next generation of combination therapy for inflammatory bowel disease

Inflammatory bowel disease(IBD)is entering a potentially new era of combined therapeutics.Triantafillidis et al provide an insightful review of the current state of combination therapy,with a focus on the use of a combined biologic and immunomodulator,as well as emerging data on the future potential of dual-biologic therapy(DBT).While current evidence for DBT is limited,encouraging safety profiles and ongoing trials suggest a brighter future for this approach.The importance of controlled trials should be stressed in establishing new treatment paradigms.Ongoing prospective randomized trials of DBT and perhaps future combinations of biologics and small molecule therapies will hopefully guide the next generation of IBD care.

Role of tannin pretreatment in flotation separation of magnesite and dolomite

Flotation separation of magnesite and its calcium-containing carbonate minerals is a difficult problem.Recently,new regulat-ors have been proposed for magnesite flotation decalcification,although traditional regulators such as tannin,water glass,sodium carbon-ate,and sodium hexametaphosphate are more widely used in industry.However,they are rarely used as the main regulators in research because they perform poorly in magnesite and dolomite single-mineral flotation tests.Inspired by the limonite presedimentation method and the addition of a regulator to magnesite slurry mixing,we used a tannin pretreatment method for separating magnesite and dolomite.Microflotation experiments confirmed that the tannin pretreatment method selectively and largely reduces the flotation recovery rate of dolomite without affecting the flotation recovery rate of magnesite.Moreover,the contact angles of the tannin-pretreated magnesite and dolomite increased and decreased,respectively,in the presence of NaOl.Zeta potential and Fourier transform infrared analyses showed that the tannin pretreatment method efficiently hinders NaOl adsorption on the dolomite surface but does not affect NaOl adsorption on the magnesite surface.X-ray photoelectron spectroscopy and density functional theory calculations confirmed that tannin interacts more strongly with dolomite than with magnesite.

Direct capture and separation of CO_(2) from air

Direct air capture(DAC)has attracted increasing interest and investment over the past few years.There are a fast-growing number of companies that entered the field and demonstrated DAC carbon removal setups and potential.However,current DAC methods are still based on solid absorbents or alkali solutions approaches which have low capture efficiency and low energy efficiency.This highlight proposed a promising CO_(2) capture technology,an electric energy driven closed-loop system for the direct removal of CO_(2) from ambient air which are based on two individual technologies:Polyam-N-Cu hybrid system promoted CO_(2) capture with ocean as anthropogenic CO_(2) sink and a chloride-mediated electrochemical pH swing system to remove CO_(2) from oceanwater.

Combination treatment of inflammatory bowel disease:Present status and future perspectives

The treatment of patients with inflammatory bowel disease(IBD),especially those with severe or refractory disease,represents an important challenge for the clinical gastroenterologist.It seems to be no exaggeration to say that in these patients,not only the scientific background of the gastroenterologist is tested,but also the abundance of“gifts”that he should possess(insight,intuition,determ-ination,ability to take initiative,etc.)for the successful outcome of the treatment.In daily clinical practice,depending on the severity of the attack,IBD is treated with one or a combination of two or more pharmaceutical agents.These combin-ations include not only the first-line drugs(e.g.,mesalazine,corticosteroids,antibiotics,etc)but also second-and third-line drugs(immunosuppressants and biologic agents).It is a fact that despite the significant therapeutic advances there is still a significant percentage of patients who do not satisfactorily respond to the treatment applied.Therefore,a part of these patients are going to surgery.In recent years,several small-size clinical studies,reviews,and case reports have been published combining not only biological agents with other drugs(e.g.,immunosuppressants or corticosteroids)but also the combination of two biologi-cal agents simultaneously,especially in severe cases.In our opinion,it is at least a strange(and largely unexplained)fact that we often use combinations of drugs in a given patient although studies comparing the simultaneous administration of two or more drugs with monotherapy are very few.As mentioned above,there is a timid tendency in the literature to combine two biological agents in severe cases unresponsive to the applied treatment or patients with severe extraintestinal manifestations.The appropriate dosage,the duration of the administration,the suitable timing for checking the clinical and laboratory outcome,as well as the treatment side-effects,should be the subject of intense clinical research shortly.In this editorial,we attempt to summarize the existing data regarding the already applied combination therapies and to humbly formulate thoughts and suggestions for the future application of the combination treatment of biological agents in a well-defined category of patients.We suggest that the application of biomarkers and artificial intelligence could help in establishing new forms of treatment using the available modern drugs in patients with IBD resistant to treatment.

Phase separation and transcriptional regulation in cancer development

Liquid-liquid phase separation,a novel biochemical phenomenon,has been increasingly studied for its medical applications.It underlies the formation of membrane-less organelles and is involved in many cellular and biological processes.During transcriptional regulation,dynamic condensates are formed through interactions between transcriptional elements,such as transcription factors,coactivators,and mediators.Cancer is a disease characterized by uncontrolled cell proliferation,but the precise mechanisms underlying tumorigenesis often remain to be elucidated.Emerging evidence has linked abnormal transcriptional condensates to several diseases,especially cancer,implying that phase separation plays an important role in tumorigenesis.Condensates formed by phase separation may have an effect on gene transcription in tumors.In the present review,we focus on the correlation between phase separation and transcriptional regulation,as well as how this phenomenon contributes to cancer development.

Erlotinib combination with a mitochondria-targeted ubiquinone effectively suppresses pancreatic cancer cell survival

BACKGROUND Pancreatic cancer is a leading cause of cancer-related deaths.Increased activity of the epidermal growth factor receptor(EGFR)is often observed in pancreatic cancer,and the small molecule EGFR inhibitor erlotinib has been approved for pancreatic cancer therapy by the food and drug administration.Nevertheless,erlotinib alone is ineffective and should be combined with other drugs to improve therapeutic outcomes.We previously showed that certain receptor tyrosine kinase inhibitors can increase mitochondrial membrane potential(Δψm),facilitate tumor cell uptake ofΔψm-sensitive agents,disrupt mitochondrial homeostasis,and subsequently trigger tumor cell death.Erlotinib has not been tested for this effect.AIM To determine whether erlotinib can elevateΔψm and increase tumor cell uptake ofΔψm-sensitive agents,subsequently triggering tumor cell death.METHODSΔψm-sensitive fluorescent dye was used to determine how erlotinib affectsΔψm in pancreatic adenocarcinoma(PDAC)cell lines.The viability of conventional and patient-derived primary PDAC cell lines in 2D-and 3D cultures was measured after treating cells sequentially with erlotinib and mitochondria-targeted ubiquinone(MitoQ),aΔψm-sensitive MitoQ.The synergy between erlotinib and MitoQ was then analyzed using SynergyFinder 2.0.The preclinical efficacy of the twodrug combination was determined using immune-compromised nude mice bearing PDAC cell line xenografts.RESULTS Erlotinib elevatedΔψm in PDAC cells,facilitating tumor cell uptake and mitochondrial enrichment ofΔψm-sensitive agents.MitoQ triggered caspase-dependent apoptosis in PDAC cells in culture if used at high doses,while erlotinib pretreatment potentiated low doses of MitoQ.SynergyFinder suggested that these drugs synergistically induced tumor cell lethality.Consistent with in vitro data,erlotinib and MitoQ combination suppressed human PDAC cell line xenografts in mice more effectively than single treatments of each agent.CONCLUSION Our findings suggest that a combination of erlotinib and MitoQ has the potential to suppress pancreatic tumor cell viability effectively.

Advances in depressants for flotation separation of Cu–Fe sulfide minerals at low alkalinity:A critical review

The flotation separation of Cu–Fe sulfide minerals at low alkalinity can be achieved using selective depressants.In the flotation system of Cu–Fe sulfide minerals,depressants usually preferentially interact with the pyrite surface to render the mineral surface hydrophilic and hinder the adsorption of the collector.This review summarizes the advances in depressants for the flotation separation of Cu–Fe sulfide minerals at low alkalinity.These advances include use of inorganic depressants (oxidants and sulfur–oxygen compounds),natural polysaccharides (starch,dextrin,konjac glucomannan,and galactomannan),modified polymers (carboxymethyl cellulose,polyacrylamide,lignosulfonate,and tricarboxylate sodium starch),organic acids (polyglutamic acid,sodium humate,tannic acid,pyrogallic acid,salicylic acid,and lactic acid),sodium dimethyl dithiocarbamate,and diethylenetriamine.The potential application of specific inorganic and organic depressants in the flotation separation of Cu–Fe sulfide minerals at low alkalinity is reviewed.The advances in the use of organic depressants with respect to the flotation separation of Cu–Fe sulfide minerals are comprehensively detailed.Additionally,the depression performances and mechanisms of different types of organic depressants on mineral surfaces are summarized.Finally,several perspectives on depressants vis-à-vis flotation separation of Cu–Fe sulfide minerals at low alkalinity are proposed.

Recent progress in ternary mixed matrix membranes for CO_(2) separation

Mixed matrix membranes(MMMs)could combine the advantages of both polymeric membranes and porousfillers,making them an effective alternative to conventional polymer membranes.However,interfacial incompatibility issues,such as the presence of interfacial voids,hardening of polymer chains,and blockage of micropores by polymers between common MMMsfillers and the polymer matrix,currently limit the gas sep-aration performance of MMMs.Ternary phase MMMs(consisting of afiller,an additive,and a matrix)made by adding a third compound,usually functionalized additives,can overcome the structural problems of binary phase MMMs and positively impact membrane separation performance.This review introduces the structure and fabrication processes for ternary MMMs,categorizes various nanofillers and the third component,and summarizes and analyzes in detail the CO_(2) separation performance of newly developed ternary MMMs based on both rubbery and glassy polymers.Based on this separation data,the challenges of ternary MMMs are also discussed.Finally,future directions for ternary MMMs are proposed.

Advances in extracellular vesicle-based combination therapies for spinal cord injury

Spinal cord injury is a severe insult to the central nervous system that causes persisting neurological deficits.The currently available treatments involve surgical,medical,and rehabilitative strategies.However,none of these techniques can markedly reverse neurological deficits.Recently,extracellular vesicles from various cell sources have been applied to different models of spinal cord injury,thereby generating new cell-free therapies for the treatment of spinal cord injury.However,the use of extracellular vesicles alone is still associated with some notable shortcomings,such as their uncertainty in targeting damaged spinal cord tissues and inability to provide structural support to damaged axons.Therefore,this paper reviews the latest combined strategies for the use of extracellular vesicle-based technology for spinal cord injury,including the combination of extracellular vesicles with nanoparticles,exogenous drugs and/or biological scaffold materials,which facilitate the targeting ability of extracellular vesicles and the combinatorial effects with extracellular vesicles.We also highlight issues relating to the clinical transformation of these extracellular vesicle-based combination strategies for the treatment of spinal cord injury.

Microporous carbon nanofibers prepared by combining electrospinning and phase separation methods for supercapacitor

Microporous carbon nanofibers (MCNFs) derived from polyacrylonitrile nanofibers were fabricated via electrospinning technology and phase separation in the presence of polyvinylpyrrolidone (PVP). PVP together with a mixed solvent of N, N-Dimethylformamide and dimethyl sulfoxide was used as pore forming agent. The influences of PVP content in casting solution on the structure and electrochemical performance of the MCNFs were also investigated. The highest capacitance of 200 F/g was obtained on a three-electrode system at a scan rate of 0.5 A/g. The good performance was owing to the high specific surface area and the large amount of micro-pores, which enhanced the absorption and the transportation efficiency of electrolyte ion during charge/discharge process. This research indicated that the combination of electrospinning and phase separation technology could be used to fabricate microporous carbon nanofibers as electrode materials for supercapacitors with high specific surface area and outstanding electrochemical performance. (C) 2016 Science Press and Dalian Institute of Chemical Physics, Chinese Academy of Sciences. Published by Elsevier B.V. and Science Press. All rights reserved.

Separation of Eu^3＋ Using a Novel Dispersion Combined Liquid Membrane with P507 in Kerosene as the Carrier

The separation of Eu^3 ＋is studied with a dispersion combined liquid membrane（DCLM）,in which polyvinylidene fluoride membrane（PVDF）is used as the liquid membrane support,dispersion solution containing HCl solution as the stripping solution,and 2-ethyl hexyl phosphonic acid-mono-2-ethyl hexyl ester（P507）dissolved in kerosene as the membrane solution.The effects of pH value,initial concentration of Eu3 ＋and different ionic strength in the feed phase,volume ratio of membrane solution to stripping solution,concentration of HCl solution, concentration of carrier,different stripping agents in the dispersion phase on the separation are investigated.The optimum condition for separation of Eu3 ＋is that concentration of HCl solution is 4.0 mol·L 1,concentration of carrier is 0.16 mol·L 1,and volume ratio of membrane solution to stripping solution is 30︰30 in the dispersion phase, and pH value is 4.2 in the feed phase.The ionic strength has no significant effect on separation of Eu3 ＋.Under the optimum condition,when the initial concentration of Eu3 ＋is 0.8×10 4mol·L 1,the separation percentage of Eu 3＋is 95.3%during the separation time of 130 min.The kinetic equation is developed in terms of the law of mass diffusion and the theory of interface chemistry.The diffusion coefficient of Eu3 ＋in the membrane and the thickness of diffusion layer between feed phase and membrane phase are obtained and their values are 1.48×10 7m 2·s 1and 36.6μm,respectively.The results obtained are in good agreement with literature data.

CFD studies on the separation performance of a new combined gas–solid separator used in TMSR-SF

In order to comply with discharge standards, a gas–solid separator is used to remove solid particles from the thorium molten salt reactor-solid fuel (TMSR-SF) system. As a key component, it directly determines system energy efficiency. However, current gas–solid separators, based on activated carbon adsorption technology, result in high pressure drops and increased maintenance costs. In the present study, a new combined gas–solid separator was developed for the TMSR-SF. Based on a simplified computational fluid dynamics (CFD) model, the gas–solid twophase flow and the motion trajectory of solid particles were simulated for this new separator using commercial ANSYS 16.0 software. The flow and separation mechanism for this structure were also been discussed in terms of their velocity effects and pressure field distributions, and then the structure was optimized based on the influence of key structural parameters on pressure and separation efficiency. The results showed that the standard k–ε model could be achieved and accurately simulated the new combined separator. In this new combined gas–solid separator, coarse particles are separated in the first stage using rotating centrifugal motion, and then fine particles are filtered in the second stage, giving a separation efficiency of up to 96.11%. The optimum blade inclination angle and numbers were calculated to be 45° and four, respectively. It implicated that the combined separator could be of great significance in a wide variety of applications.

The flow behavior of droplet adsorption on a liquid-liquid interface accompanied by cross-linking reaction and phase separation in a microchannel

The adsorption process of droplets on the liquid-liquid interface and phase separation process can regulate the spatial distribution of the fluid system,which are crucial for chemical engineering.However,the cross-linking reaction,which is widely used in the field of polymers,can change the physical properties of the fluids and affect the flow behavior accordingly.A configuration of microchannels is designed to conveniently generate uniform droplets in one phase of the parallel flow.The flow behavior of the adsorption process of sodium alginate droplets on the liquid-liquid interface is investigated,and the subsequent process of phase separation is studied.In the process of droplet adsorption,the crosslinking reaction occurs synchronously,which makes the droplet viscosity and the elasticity modules of the droplet surface increase,thus affecting the dynamics of the adsorption process and the equilibrium shape of the droplet.The variation of the adsorption length with time is divided into three stages,which all conform to power law relationship.The exponents of the second and third stages deviate from the results of the Tanner's law.The flow pattern maps of droplet adsorption and phase separation are drawn,and the operating ranges of complete adsorption and complete separation are provided.This study provides a theoretical basis for further studying the flow behavior of droplets with cross-linking reaction in a microchannel.

Environmental,economic and exergy analysis of separation of ternary azeotrope by variable pressure extractive distillation based on multi-objective optimization

In this work,the ternary azeotrope of tert-butyl alcohol/ethyl acetate/water is separated by extractive distillation(ED)to recover the available constituents and protect the environment.Based on the conductor like shielding model and relative volatility method,ethylene glycol was selected as the extractant in the separation process.In addition,in view of the characteristic that the relative volatility between components changes with pressure,the multi-objective optimization method based on nondominated sorting genetic algorithm II optimizes the pressure and the amount of solvent cooperatively to avoid falling into the optimal local solution.Based on the optimal process parameters,the proposed heat-integrated process can reduce the gas emissions by 29.30%.The heat-integrated ED,further coupled with the pervaporation process,can reduce gas emission by 42.36%and has the highest exergy efficiency of 47.56%.In addition,based on the heat-integrated process,the proposed two heat pump assisted heat-integrated ED processes show good economic and environmental performance.The double heat pump assisted heat-integrated ED can reduce the total annual cost by 28.78%and the gas emissions by 55.83%compared with the basis process,which has a good application prospect.This work provides a feasible approach for the separation of ternary azeotropes.

Flotation separation of scheelite from calcite using luteolin as a novel depressant

This paper proposes luteolin(LUT)as a novel depressant for the flotation-based separation of scheelite and calcite in a sodium oleate(NaOL)system.The suitability of LUT as a calcite depressant is confirmed through micro-flotation testing.At pH=9,with LUT concentration of 50 mg·L^(-1) and NaOL concentration of 50 mg·L^(-1),scheelite recovery reaches 80.3%.Calcite,on the other hand,exhibits a recovery rate of 17.6%,indicating a significant difference in floatability between the two minerals.Subsequently,the surface modifica-tions of scheelite and calcite following LUT treatment are characterized using adsorption capacity testing,Zeta potential analysis,Fourier transform infrared spectroscopy(FT-IR),X-ray photoelectron spectroscopy(XPS),and atomic force microscopy(AFM).The study in-vestigates the selective depressant mechanism of LUT on calcite.Adsorption capacity testing and Zeta potential analysis demonstrate sub-stantial absorption of LUT on the surface of calcite,impeding the further adsorption of sodium oleate,while its impact on scheelite is min-imal.FT-IR and XPS analyses reveal the selective adsorption of LUT onto the surface of calcite,forming strong chemisorption bonds between the hydroxyl group and calcium ions present.AFM directly illustrates the distinct adsorption densities of LUT on the two miner-al types.Consequently,LUT can effectively serve as a depressant for calcite,enabling the successful separation of scheelite and calcite.