A new kind of solvent for deacidification of distillate oils was introduced in this paper. After successful laboratory study this technology had been applied in commercial scale successfully. Compared to traditional c...A new kind of solvent for deacidification of distillate oils was introduced in this paper. After successful laboratory study this technology had been applied in commercial scale successfully. Compared to traditional caustic wash of distillate oils, this technology has a lot of merits, such as the broad range of distillates to be processed, low caustic consumption, recycle of deacidifying agent, absence of waste caustic discharge, and low equipment revamp expenses, which can have promising perspectives for exploitation and application of this technology.展开更多
Sudan Khartoum Refinery Co. has selected a unique route featuring delayed coking of crude in connection with the highly sour and high-calcium heavy crude extracted from Sudanese oil block No. 6.The crude oil after pre...Sudan Khartoum Refinery Co. has selected a unique route featuring delayed coking of crude in connection with the highly sour and high-calcium heavy crude extracted from Sudanese oil block No. 6.The crude oil after pretreatment for calcium removal is subjected to coking for removal of acids and metals with the coker products being further processed. The crude oil extracted from Sudanese oil block No. 6contains as high as 13 mg KOH/g of crude in addition to a calcium content of 1600 ppm. This article makes an analysis on problems related with the operation of commercial delayed coking unit for processing of highly sour crude and bring forth measures to solve these problems. The liquid yield resulted from coking of crude oil can reach 82m%, and the petroleum coke can meet the quality requirement for class 3B petroleum coke.展开更多
This article refers to the commercial application assessment of the novel S-RHT catalysts.The application outcome has shown that the catalysts loading was reduced with its performance kept at the original level at the...This article refers to the commercial application assessment of the novel S-RHT catalysts.The application outcome has shown that the catalysts loading was reduced with its performance kept at the original level at the initial and middle stages of operation. The performance of catalysts at the end of operation was analyzed, and factors affecting the performance of the novel catalysts at the end of run were identified to facilitate further improvement of the said catalysts.展开更多
This article summarizes the block process flow scheme for the 8.0 Mt/a refining project at Hainan Refining and Chemical Company, Ltd., highlighting a green route for processing sour heavy oils, and the enlarged scale ...This article summarizes the block process flow scheme for the 8.0 Mt/a refining project at Hainan Refining and Chemical Company, Ltd., highlighting a green route for processing sour heavy oils, and the enlarged scale of production with Chinese content. The refinery is targeted at hydrotreating of process streams, integration and intensified design of process units, clean gasoline and diesel production, centralized recovery and utilization of light ends and optimization of sulphur recovery systems.展开更多
Taking squid as raw material, the effects of frying temperature and frying time on the quality of squid chips were studied under the conditions of normal pressure frying and high-temperature hot-air frying respectivel...Taking squid as raw material, the effects of frying temperature and frying time on the quality of squid chips were studied under the conditions of normal pressure frying and high-temperature hot-air frying respectively. And the best processing technology of squid chips was determined. The results showed that crispy squid chips can be obtained by frying the squid after vacuum freeze-drying, and the best processing technology of squid chips is to treat the material by hot air drying at 160℃ for 4 min after pretreatment, seasoning, protease treatment, pre-freezing and freeze-drying. The squid chips made by this technology have a flavor of frying, tightly-shrunken surface tissue, a little browning, less hardness, crispness and no greasy taste.展开更多
Two novel ashless and non-phosphorus S, B-containing morpholine derivatives, MBOC and MBOD, were prepared and their tribological behaviors in rapeseed oil （RSO） were evaluated using a four-ball tester. Thermal degra...Two novel ashless and non-phosphorus S, B-containing morpholine derivatives, MBOC and MBOD, were prepared and their tribological behaviors in rapeseed oil （RSO） were evaluated using a four-ball tester. Thermal degradation tests were conducted to identify their thermal stabilities using a thermo-gravimetric analyzer. The worn surfaces of the steel balls were investigated by scanning electron microscopy （SEM）. The results indicated that the additives possessed high thermal stabilities and good load-carrying capacities. Moreover, they both had good anti-wear and friction reducing property at a relatively high concentration （1.5 m%） and under all test loads. The results of XPS analyses illustrated that the prepared compounds as additives in RSO could form a protective film containing inorganic sulfide, sulfate, oxidized compounds and organic nitrogen-containing compounds on the metal surface during the sliding process.展开更多
This article focuses on the hydrocracking technology for upgrading the quality of tail oil and the first commercial application of the RN-32V/RHC- 1 catalysts in the 1.0 Mt/a hydrocracker at the Yangzi Petrochemical C...This article focuses on the hydrocracking technology for upgrading the quality of tail oil and the first commercial application of the RN-32V/RHC- 1 catalysts in the 1.0 Mt/a hydrocracker at the Yangzi Petrochemical Company, which was started up successfully in September 2008. One month after start-up of the hydrocracking unit, an evaluation opera- tion has been conducted fbr assessing the catalysts performance. The technical calibration results showed that the RN- 32V/RHC-1 catalysts had high activity, and the product yield distribution was reasonable. The hydrocracker can provide abundant feedstocks for the downstream aromatic production unit and ethylene production unit.展开更多
This article refers to the first commercial application of upflow residuum hydrotreating serial catalyst, developed by Fushun Research Institute of Petroleum and Petrochemicals (FRIPP), in the residuum hydrotreating u...This article refers to the first commercial application of upflow residuum hydrotreating serial catalyst, developed by Fushun Research Institute of Petroleum and Petrochemicals (FRIPP), in the residuum hydrotreating unit at Shengli refinery of Qilu Petrochemical Company. This catalyst features large pore volume and large pore diameter. The production practice for more than one year has revealed that the domestic upflow residuum hydrotreating catalyst has shown good performance and stability over the whole period of operation despite its high activity at the start of run, and has basically reached the level of similar imported catalyst.展开更多
The RHT technology is developed by Research Institute of Petroleum Processing (RIPP) for residuum hydrotreating in order to produce good quality RFCC feed. The advantages of the RHT series catalysts are presented in t...The RHT technology is developed by Research Institute of Petroleum Processing (RIPP) for residuum hydrotreating in order to produce good quality RFCC feed. The advantages of the RHT series catalysts are presented in this article, based on the results of activity tests and a 9500 hours service life test in pilot plants and the assessment on a commercial application.展开更多
The 40kt/a sulfur recovery unit for tail gas treating applying the reduction-absorption-recycling (RAR) technology is aimed at regeneration of the rich amine solution and recovery of sulfur to operate in tandem with t...The 40kt/a sulfur recovery unit for tail gas treating applying the reduction-absorption-recycling (RAR) technology is aimed at regeneration of the rich amine solution and recovery of sulfur to operate in tandem with the 1.2Mt/a diesel hydrofining unit. The process unit calibration data have revealed that the recovery of total sulfur reaches 99.86%, which is 6.65 percentage points higher than that before application of the RAR technology. The SO2 content in vented tail gas is 0.27 t/d, which is much less than the latest emission standard prescribed by the State. The factors that can affect the unit operation have been analyzed and corresponding measures have been suggested including the necessity to improve the control over the reaction temperature in the tail gas hydrogenation unit.展开更多
文摘A new kind of solvent for deacidification of distillate oils was introduced in this paper. After successful laboratory study this technology had been applied in commercial scale successfully. Compared to traditional caustic wash of distillate oils, this technology has a lot of merits, such as the broad range of distillates to be processed, low caustic consumption, recycle of deacidifying agent, absence of waste caustic discharge, and low equipment revamp expenses, which can have promising perspectives for exploitation and application of this technology.
文摘Sudan Khartoum Refinery Co. has selected a unique route featuring delayed coking of crude in connection with the highly sour and high-calcium heavy crude extracted from Sudanese oil block No. 6.The crude oil after pretreatment for calcium removal is subjected to coking for removal of acids and metals with the coker products being further processed. The crude oil extracted from Sudanese oil block No. 6contains as high as 13 mg KOH/g of crude in addition to a calcium content of 1600 ppm. This article makes an analysis on problems related with the operation of commercial delayed coking unit for processing of highly sour crude and bring forth measures to solve these problems. The liquid yield resulted from coking of crude oil can reach 82m%, and the petroleum coke can meet the quality requirement for class 3B petroleum coke.
文摘This article refers to the commercial application assessment of the novel S-RHT catalysts.The application outcome has shown that the catalysts loading was reduced with its performance kept at the original level at the initial and middle stages of operation. The performance of catalysts at the end of operation was analyzed, and factors affecting the performance of the novel catalysts at the end of run were identified to facilitate further improvement of the said catalysts.
文摘This article summarizes the block process flow scheme for the 8.0 Mt/a refining project at Hainan Refining and Chemical Company, Ltd., highlighting a green route for processing sour heavy oils, and the enlarged scale of production with Chinese content. The refinery is targeted at hydrotreating of process streams, integration and intensified design of process units, clean gasoline and diesel production, centralized recovery and utilization of light ends and optimization of sulphur recovery systems.
文摘Taking squid as raw material, the effects of frying temperature and frying time on the quality of squid chips were studied under the conditions of normal pressure frying and high-temperature hot-air frying respectively. And the best processing technology of squid chips was determined. The results showed that crispy squid chips can be obtained by frying the squid after vacuum freeze-drying, and the best processing technology of squid chips is to treat the material by hot air drying at 160℃ for 4 min after pretreatment, seasoning, protease treatment, pre-freezing and freeze-drying. The squid chips made by this technology have a flavor of frying, tightly-shrunken surface tissue, a little browning, less hardness, crispness and no greasy taste.
基金the PLA General Logistics Department(No.[2006]357)the Hunan Science Program,P R China(06FJ4112)
文摘Two novel ashless and non-phosphorus S, B-containing morpholine derivatives, MBOC and MBOD, were prepared and their tribological behaviors in rapeseed oil （RSO） were evaluated using a four-ball tester. Thermal degradation tests were conducted to identify their thermal stabilities using a thermo-gravimetric analyzer. The worn surfaces of the steel balls were investigated by scanning electron microscopy （SEM）. The results indicated that the additives possessed high thermal stabilities and good load-carrying capacities. Moreover, they both had good anti-wear and friction reducing property at a relatively high concentration （1.5 m%） and under all test loads. The results of XPS analyses illustrated that the prepared compounds as additives in RSO could form a protective film containing inorganic sulfide, sulfate, oxidized compounds and organic nitrogen-containing compounds on the metal surface during the sliding process.
文摘This article focuses on the hydrocracking technology for upgrading the quality of tail oil and the first commercial application of the RN-32V/RHC- 1 catalysts in the 1.0 Mt/a hydrocracker at the Yangzi Petrochemical Company, which was started up successfully in September 2008. One month after start-up of the hydrocracking unit, an evaluation opera- tion has been conducted fbr assessing the catalysts performance. The technical calibration results showed that the RN- 32V/RHC-1 catalysts had high activity, and the product yield distribution was reasonable. The hydrocracker can provide abundant feedstocks for the downstream aromatic production unit and ethylene production unit.
文摘This article refers to the first commercial application of upflow residuum hydrotreating serial catalyst, developed by Fushun Research Institute of Petroleum and Petrochemicals (FRIPP), in the residuum hydrotreating unit at Shengli refinery of Qilu Petrochemical Company. This catalyst features large pore volume and large pore diameter. The production practice for more than one year has revealed that the domestic upflow residuum hydrotreating catalyst has shown good performance and stability over the whole period of operation despite its high activity at the start of run, and has basically reached the level of similar imported catalyst.
文摘The RHT technology is developed by Research Institute of Petroleum Processing (RIPP) for residuum hydrotreating in order to produce good quality RFCC feed. The advantages of the RHT series catalysts are presented in this article, based on the results of activity tests and a 9500 hours service life test in pilot plants and the assessment on a commercial application.
文摘The 40kt/a sulfur recovery unit for tail gas treating applying the reduction-absorption-recycling (RAR) technology is aimed at regeneration of the rich amine solution and recovery of sulfur to operate in tandem with the 1.2Mt/a diesel hydrofining unit. The process unit calibration data have revealed that the recovery of total sulfur reaches 99.86%, which is 6.65 percentage points higher than that before application of the RAR technology. The SO2 content in vented tail gas is 0.27 t/d, which is much less than the latest emission standard prescribed by the State. The factors that can affect the unit operation have been analyzed and corresponding measures have been suggested including the necessity to improve the control over the reaction temperature in the tail gas hydrogenation unit.
