型钢热轧开坯过程金属变形分析

型钢热轧开坯是高温坯料在低温轧辊作用下的金属变形过程,高温下金属材料的变形抗力随温度和应变速率变化明显,而且变形中塑性功和接触面摩擦以及坯料和轧辊间的热传导、和空气对流换热、辐射散热等,将导致坯料温度场的变化。因此,利用有限元法分析变形过程时,必须同时计算温度场和位移场。采用Mises屈服准则和弹/粘塑性材料模型,推导了采用等向强化假设的材料物性关系中的塑性矩阵、温度修正矩阵、应变速率修正矩阵的具体表达式。分析了多道次H型钢孔型轧制的开坯过程,总结了坯料在孔型中的变形规律,通过和H型钢生产现场数据的对比验证了结果的准确性。

Influence of features of natural soft clay on behaviour of embankment

The influence of different features of natural soft clays,namely anisotropy,destructuration and viscosity,on modelling the time-dependent behaviour of Murro embankment was investigated.The newly developed elasto-viscoplastic models were enhanced for determining viscosity parameters in a straightforward way and adopted for the finite element analysis.The same set of common parameters determined from conventional triaxial and oedometer tests was employed for all models,with additional parameters required for representing different soil features.The finite element predictions by using models coupled with BIOT's consolidation theory were compared with each other and with field data for settlement,horizontal displacement and excess pore pressures.In addition,the stress paths under the embankment loading were also compared with each other to improve the understanding of the effect of different soil features.All simulations demonstrate that all three features significantly influence the predictions.As a consequence,accounting for soil features needs to be carefully considered when they are applied to a construction site.

Model Test and Numerical Analysis on Long-Term Mechanical Properties of Stepped Reinforced Retaining Wall

Model tests and numerical analyses of stepped reinforced retaining wall were performed to investigate the effects of rheology of backfill and creep of geogrids on the long-term performance of the structure.The geogrid tensions,soil pressures,wall deformations and foundation pressure were measured during model construction and loading.A visco-elasto-plastic model and an empirical nonlinear visco-elastic model were utilized to simulate the stresses and deformations of geogrid-reinforced earth-retaining wall under long-term loads.By comparing test data with numerical results,it is shown that the foundation pressure distribution is nonlinear,and the lateral constraint of geogrids for backfill can cause a redistribution of foundation pressure.The curve of soil pressure is outside convex at each step initially,and it is close to the distribution for the case of vertical wall subsequently.The variation trend of geogrid tensions at different heights is obtained.Moreover,the failure mechanism and development mode of potential slip surface in retaining wall are proposed.

A triaxial creep model for coal containing gas and its stability analysis

Triaxial creep tests on CCG specimens were systematically performed using aself-made creep seepage experimental apparatus for determining the creep law of CCG.An improved triaxial creep model of CCG was established on the basis of a Nishiharamodel and another visco-elasto-plastic model,parameters of which were fitted on test data.Furthermore,the creep model is validated according to the result of triaxial creep experiments,and the outcome shows that the proposed triaxial creep model can properly characterizethe properties of various creep deformation phases of CCG,especially the acceleratingcreep phase.At the same time,the instability conditions of CCG were presentedbased on the discussion of the improved model's stability in terms of stability theories ofdifferential equation solution.

Uniqueness of rate-dependency, creep and stress relaxation behaviors for soft clays

This work focuses on the uniqueness of rate-dependency, creep and stress relaxation behaviors for soft clays under one-dimensional condition. An elasto-viscoplastic model is briefly introduced based on the rate-dependency of preconsolidation pressure. By comparing the rate-dependency formulation with the creep based formulation, the relationship between rate-dependency and creep behaviors is firstly described. The rate-dependency based formulation is then extended to derive an analytical solution for the stress relaxation behavior with defining a stress relaxation coefficient. Based on this, the relationship between the rate-dependency coefficient and the stress relaxation coefficient is derived. Therefore, the uniqueness between behaviors of rate-dependency, creep and stress relaxation with their key parameters is obtained. The uniqueness is finally validated by comparing the simulated rate-dependency of preconsolidation pressure, the estimated values of secondary compression coefficient and simulations of stress relaxation tests with test results on both reconstituted Illite and Berthierville clay.

Visco-elastoplastic damage constitutive model for compressed asphalt mastic

In order to describe the three-stage creep behavior of compressed asphalt mastic, a visco-elastoplastic damage constitutive model is proposed in this work. The model parameters are treated as quadratic polynomial functions with respect to stress and temperature. A series of uniaxial compressive creep experiments are performed at various stress and temperature conditions in order to determine these parameter functions, and then the proposed model is validated by comparison between the predictions and experiments at the other loading conditions. It is shown that very small permanent deformation at low stress and temperature increases rapidly with elevated stress or temperature and the damage may initiate in the stationary stage but mainly develops in the accelerated stage. Compared with the visco-elastoplastic models without damage, the predictions from the proposed model is in better agreement with the experiments, and can better capture the rate-dependency in creep responses of asphalt mastic especially below its softening point of 47 ℃

An elastic-viscous-plastic model for overconsolidated clays

The influences of time on clays are discussed first,and the concept of the instant normal compression line is proposed by analyzing the existing theories and experimental results.Based on the creep law,the relationship between the aging time and the overconsolidation parameter is built.With the reloading equation of the UH model(unified hardening model for overconsolidated clays) used to calculate the instant compression deformation,a one-dimensional stress-strain-time relationship is proposed.Furthermore,the evolution of this relationship is analyzed,and the characteristic rate that is a function of the overconsolidation parameter is defined.Then a three-dimensional elastic-viscous-plastic constitutive model is suggested by incorporating equivalent time into the current yield function of the UH model.The new model can describe not only creep,rate effect and other viscous phenomena,but also shear dilatancy,strain softening and other behaviors of overconsolidated clays.Besides,compared with the modified Cam-clay model it requires only one additional parameter(the coefficient of secondary compression) to consider the creep law.Finally,because the proposed model can be changed into the UH model under instantaneous loading,the elastic-plastic and elastic-viscous-plastic frameworks are unified.