物质流的网络合成技术研究进展

首先综述了换质网络综合技术的设计方法与理论基础 ,即夹点设计法与数学规划法。并简要叙述了物质流网络综合技术在水处理 ,废水处理 ,炼厂氢管理等方面的最新应用研究进展 ,指出该技术研究的发展对于化学工业的清洁生产有着重要的意义。

A Simultaneous Optimization Method for the Structure and Compo-sition Differences of a Mass Exchange Network

This article presents a new method to calculate the composition differences （e） for tar g.etin.g the minimum total annualized cost （TAC） of a mass exchange network （MEN）,which is based on the combination of composition interval diagram （CID） with mathematical programming.The total cost target consists of the capital cost of the process units and the operating cost for mass separating agents （MS.As）. The value of total cost varies considerablv with the composition differences, so the values of e should be optimized in order to obtain minimum TAC of a MEN. This articleconsiders ε as a set of unequal variables for each equilibrium equation of a rich-lean stream pair, employing them to build the CID and mathematical model, which optimizes the structure and composition differences simultaneously. Two examples are applied to illustrate the proposed method and the results demonstrate that the approach introduced by this article is simpler and more convenient than the methods in previous literatures.

Minimization of the Flowrate of Fresh Water and Corresponding Regenerated Water in Water-using System with Regeneration Reuse

A sequential three-step programming method is proposed for determining the minimum flowrate of fresh water and corresponding regenerated water in water-using system of single contaminant with regeneration reuse. In step 1, a programming with the objective of min fws is used to determine the minimum flowrate of fresh water, in which the mathematical representation is a mixed integer nonlinear programming (MINLP1). Then under the same constraints with step 1, a programming with the objective of min freg in step 2 and a programming with the objective of min Cr in step 3 are subsequently used to determine the minimum flowrate of regenerated water and the minimum inlet concentration to regeneration process corresponding to the minimum flowrate of fresh water based on step 1. The method is easy to apply because we only need to change the objective function but keep the constraints constant to go along the following steps after step 1. In addition, the relationship between the fresh water flowrate required, fws and inlet concentration to regeneration process, Cr, is investigated. It is found that there exist three relationships between fws and Cr, which indicate three possibilities for C\>: below the pinch, above the pinch or at the pinch. Therefore, a new conclusion is drawn, which differs from that 'regeneration of water at pinch minimizes fresh water flowrate' derived in literature and indicates that in some cases, regeneration at other point also minimizes fresh water flowrate.

Synthesis of Multi-component Mass-exchange Networks

This paper presents a superstructure-based formulation for the synthesis of mass-exchange networks (MENs) considering multiple components. The superstructure is simplified by directly using the mass separation agents (MSA) from their sources, and therefore the automatic synthesis of the multi-component system involved in the MENs can be achieved without choosing a 'key-component' either for the whole process or the mass exchangers. A mathematical model is proposed to carry out the optimization process. The concentrations, flow rates, matches and unit operation displayed in the obtained network constitute the exact representation of the mass exchange process in terms of all species in the system. An example is used to illustrate and demonstrate the application of the proposed method.

State Space Approach to Mass Exchange Network Synthesis

State space approach is an effective method to mass-exchange network (MEN) synthesis. By decomposing the network into two interactive parts, a distribution network and a process operator, the synthesis problem can be formulated into a mixed integer nonlinear programming (MINLP) model. In this article, a generalized state space model based on typical MEN is established and verified in two cases. A new asymmetrical operator and cost index are also adopted to speed up the solution process. The results demonstrate the efficiency of the proposed approach.

The retromer component SNX6 interacts with dynactin p150Glued and mediates endosome-to-TGN transport

The retromer is a protein complex that mediates retrograde transport of transmembrane cargoes from endosomes to the trans-Golgi network （TGN）. It is comprised of a cargo-selection subcomplex of Vps26, Vps29 and Vps35 and a membrane-binding coat subcomplex of sorting nexins （SNXs）. Previous studies identified SNX1/2 as one of the components of the SNX subcomplex, and SNX5/6 as candidates for the second SNX. How the retromer-associated cargoes are recognized and transported by molecular motors are largely unknown. In this study, we found that one of SNX1/2＇s dimerization partners, SNX6, interacts with the p150Gued subunit of the dynein/dynactin motor complex. We present evidence that SNX6 is a component of the retromer, and that recruitment of the motor complex to the membrane-associated retromer requires the SNX6-pl50Gued interaction. Disruption of the SNX6-pl50Glued interaction causes failure in formation and detachment of the tubulovesicular sorting structures from endosomes and results in block of CI-MPR retrieval from endosomes to the TGN. These observations indicate that in addition to SNX1/2, SNX6 in association with the dynein/dynactin complex drives the formation and movement of tubular retrograde intermediates.

Combined mass and heat exchange network synthesis based on stage-wise superstructure model

Integrating multiple systems into one has become an important trend in Process Systems Engineering research field since there is strong demand from the modern industries. In this study, a stage-wise superstructurebased method is proposed to synthesize a combined mass and heat exchange network(CM&HEN) which has two parts as the mass exchange network(MEN) and heat exchange network(HEN) involved. To express the possible heat exchange requirements resulted from mass exchange operations, a so called "indistinct HEN superstructure(IHS)", which can contain the all potential matches between streams, is constructed at first. Then, a non-linear programming(NLP) mathematical model is established for the simultaneous synthesis and optimization of networks. Therein, the interaction between mass exchange and heat exchange is modeling formulated.The NLP model has later been examined using an example from literature, and the effectiveness of the proposed method has been demonstrated with the results.

Transmission Mechanism Based on Burst Filling in Hybrid Optical Burst/Circuit Switching Networks

Hybrid optical switching networks make full use of the advantages of Optical Circuit Switching(OCS)and Optical Burst Switching(OBS).In parallel hybrid optical switching networks,edge nodes choose a switching mode for traffic and no longer change.The inflexible decision making of the traffic transfer mode leads to low resource utilization when the arrival rate of the OCS traffic is lower than the capacity of the light path.In this paper,a new transmission scheme is proposed to improve resource utilization for hybrid optical switching networks.When the traffic arrival rate of the light path is lower than the transmission rate of the light path,the OCS traffic flow is reshaped at the edge nodes to generate a series of voids.Then,several message packets are sent along the light path to inform the core nodes of the voids of the light paths that represent the unused bandwidth resources.To improve the resource utilization,the voids can be filled with data bursts by core nodes.The simulation results show that the new scheme can effectively reduce the burst loss rate and improve the link utilization of the hybrid optical switching network on the premise of a providing service quality guarantee for OCS traffic.