The microstructure and mechanical properties of Mg-10.1Gd-3.74Y-0.25Zr （mass fraction, %） alloy （GW104 alloy） cast by metal mould casting （MMC） and lost foam casting （LFC） were evaluated, respectively. It is r...The microstructure and mechanical properties of Mg-10.1Gd-3.74Y-0.25Zr （mass fraction, %） alloy （GW104 alloy） cast by metal mould casting （MMC） and lost foam casting （LFC） were evaluated, respectively. It is revealed that different forming modes do not influence the phase composition of as-cast alloy. In the as-cast specimens, the microstructures are similar and composed of α-Mg solid solution, eutectic compound of α-Mg＋Mg 24 （Gd, Y） 5 and cuboid-shaped Mg 5 （Gd, Y） phase; whereas the average grain size of the alloy produced by metal mould casting is smaller than that by lost foam casting. The eutectic compound of the alloy is completely dissolved after solution treatment at 525 ℃for 6 h, while the Mg 5 （Gd, Y） phase still exists after solution treatment. After peak-ageing, the lost foam cast alloy exhibits the maximum ultimate tensile strength of 285 MPa, and metal mould cast specimen 325 MPa at room temperature, while the tensile yield strengths of them are comparable. It can be concluded that GW104 alloy cast by lost foam casting possesses similar microstructure and evidently lower mechanical strength compared with metal mould cast alloy, due to slow solidification rate and proneness to form shrinkage porosities during lost foam casting process.展开更多
Through the research on stress metamorphism character of the II1 coal seam in Ludian gliding structure, the stress effecting factors of metamorphism and hydrocarbon generation process of tectonic coal were studied. It...Through the research on stress metamorphism character of the II1 coal seam in Ludian gliding structure, the stress effecting factors of metamorphism and hydrocarbon generation process of tectonic coal were studied. It is shown that different tectonic stress has different coal evolution effects. Compared with tensional stress, compressive stress, which has apparent anisotropic characteristics, has greater stimulative effect against the increase of coal metamorphic degree, the abscission of functional group and side chains of basic structural unit, and the formation of gas primarily composed of methane.展开更多
This article presents the results of dividing the hydrogeological structure zones in aquifer of Cai Phan Rang river basin, Ninh Thuan province, Viet Nam, and the relationship between parameters of hydrogeological stru...This article presents the results of dividing the hydrogeological structure zones in aquifer of Cai Phan Rang river basin, Ninh Thuan province, Viet Nam, and the relationship between parameters of hydrogeological structure zones with water storage capacity of hydrogeological structure. Research results divided hydrogeological structure of Cai Phan Rang River Basin into four zones, including three zones with depression bedrock and one zone with slope bedrock, and the results assessed： （1） specific discharge of exploitation well is proportional to zone area of hydrogeological structure; （2） specific discharge of exploitation well is inversely proportional to slope of bedrock surface, slope of water level in zone and area of drainage surface of hydrogeological structure zone; （3） water level fluctuation in zone is proportional to slope of bedrock surface, slope of water level in zone and inversely proportional to distribution area of zone; （4） total mineralization of water is proportional to bedrock surface slope and water level slope in zone, and inversely proportional to drainage surface area of zone and volume of structural depression. Research results are practical significance in solutions proposal to increase exploitation capacity for various water use purposes.展开更多
Based on the particularities of gas outbursts,i.e.,low gas bearing capacity and low gas pressure in the "Three Soft" coal seam in western Henan,we applied the theories of plate tectonics and regional structu...Based on the particularities of gas outbursts,i.e.,low gas bearing capacity and low gas pressure in the "Three Soft" coal seam in western Henan,we applied the theories of plate tectonics and regional structural evolution to investigate the mechanism of this seam and its impact on the coal seam gas formation.Our investigation revealed that coal and gas outbursts are distributed in a strip in a NW direction,with a number of high-penetration mines scattered towards the south side and low-gas mines largely located on the north side.We analyzed the statistics of 38 gas explosions and the rock-coal sturdiness number coefficient f of 167 sampling sites in the region and found the gas outburst mechanism that features a "low indicator outburst phenomenon".The mechanism is characterized by structural coal as its core,a low gas bearing capacity,low gas pressure and sturdiness coefficient f mostly less than 0.3.Our research results provide a theoretical foundation for effective control of gas disasters.展开更多
For a variable speed large scale wind turbine, the vibration issues become a key problem that cannot be ignored in the turbine＇s life cycle. Wind turbine tower vibration will cause superfluous mechanical loads. To re...For a variable speed large scale wind turbine, the vibration issues become a key problem that cannot be ignored in the turbine＇s life cycle. Wind turbine tower vibration will cause superfluous mechanical loads. To resolve the vibration issue, a method for constructng the energy function V is proposed to meet the demands of safe operation. The Lyapunov theorem has been em- bedded in a wind turbine control algorithm, proving the theoretical feasibility of stability control based on function V. Accord- ing to an analysis of this complex nonlinear model for the wind turbine, the general method of constructing an energy function suitable for a wind turbine is presented explicitly. The feasibility of applying an energy function to wind turbine vibration con- trol is verified experimentally using a 3.0-MW direct drive wind turbine model. The experimental results indicate that the dy- namic performance of the tested wind turbine model with energy function control is significantly better than that of the uncon- trolled structure in terms of the reduction of nacelle acceleration, velocity, and displacement response.展开更多
基金Project(2007CB613704)supported by the National Basic Research Program of China
文摘The microstructure and mechanical properties of Mg-10.1Gd-3.74Y-0.25Zr （mass fraction, %） alloy （GW104 alloy） cast by metal mould casting （MMC） and lost foam casting （LFC） were evaluated, respectively. It is revealed that different forming modes do not influence the phase composition of as-cast alloy. In the as-cast specimens, the microstructures are similar and composed of α-Mg solid solution, eutectic compound of α-Mg＋Mg 24 （Gd, Y） 5 and cuboid-shaped Mg 5 （Gd, Y） phase; whereas the average grain size of the alloy produced by metal mould casting is smaller than that by lost foam casting. The eutectic compound of the alloy is completely dissolved after solution treatment at 525 ℃for 6 h, while the Mg 5 （Gd, Y） phase still exists after solution treatment. After peak-ageing, the lost foam cast alloy exhibits the maximum ultimate tensile strength of 285 MPa, and metal mould cast specimen 325 MPa at room temperature, while the tensile yield strengths of them are comparable. It can be concluded that GW104 alloy cast by lost foam casting possesses similar microstructure and evidently lower mechanical strength compared with metal mould cast alloy, due to slow solidification rate and proneness to form shrinkage porosities during lost foam casting process.
文摘Through the research on stress metamorphism character of the II1 coal seam in Ludian gliding structure, the stress effecting factors of metamorphism and hydrocarbon generation process of tectonic coal were studied. It is shown that different tectonic stress has different coal evolution effects. Compared with tensional stress, compressive stress, which has apparent anisotropic characteristics, has greater stimulative effect against the increase of coal metamorphic degree, the abscission of functional group and side chains of basic structural unit, and the formation of gas primarily composed of methane.
文摘This article presents the results of dividing the hydrogeological structure zones in aquifer of Cai Phan Rang river basin, Ninh Thuan province, Viet Nam, and the relationship between parameters of hydrogeological structure zones with water storage capacity of hydrogeological structure. Research results divided hydrogeological structure of Cai Phan Rang River Basin into four zones, including three zones with depression bedrock and one zone with slope bedrock, and the results assessed： （1） specific discharge of exploitation well is proportional to zone area of hydrogeological structure; （2） specific discharge of exploitation well is inversely proportional to slope of bedrock surface, slope of water level in zone and area of drainage surface of hydrogeological structure zone; （3） water level fluctuation in zone is proportional to slope of bedrock surface, slope of water level in zone and inversely proportional to distribution area of zone; （4） total mineralization of water is proportional to bedrock surface slope and water level slope in zone, and inversely proportional to drainage surface area of zone and volume of structural depression. Research results are practical significance in solutions proposal to increase exploitation capacity for various water use purposes.
基金support for this work,provided by the National Natural Science Foundation of China (No.50834005)
文摘Based on the particularities of gas outbursts,i.e.,low gas bearing capacity and low gas pressure in the "Three Soft" coal seam in western Henan,we applied the theories of plate tectonics and regional structural evolution to investigate the mechanism of this seam and its impact on the coal seam gas formation.Our investigation revealed that coal and gas outbursts are distributed in a strip in a NW direction,with a number of high-penetration mines scattered towards the south side and low-gas mines largely located on the north side.We analyzed the statistics of 38 gas explosions and the rock-coal sturdiness number coefficient f of 167 sampling sites in the region and found the gas outburst mechanism that features a "low indicator outburst phenomenon".The mechanism is characterized by structural coal as its core,a low gas bearing capacity,low gas pressure and sturdiness coefficient f mostly less than 0.3.Our research results provide a theoretical foundation for effective control of gas disasters.
文摘For a variable speed large scale wind turbine, the vibration issues become a key problem that cannot be ignored in the turbine＇s life cycle. Wind turbine tower vibration will cause superfluous mechanical loads. To resolve the vibration issue, a method for constructng the energy function V is proposed to meet the demands of safe operation. The Lyapunov theorem has been em- bedded in a wind turbine control algorithm, proving the theoretical feasibility of stability control based on function V. Accord- ing to an analysis of this complex nonlinear model for the wind turbine, the general method of constructing an energy function suitable for a wind turbine is presented explicitly. The feasibility of applying an energy function to wind turbine vibration con- trol is verified experimentally using a 3.0-MW direct drive wind turbine model. The experimental results indicate that the dy- namic performance of the tested wind turbine model with energy function control is significantly better than that of the uncon- trolled structure in terms of the reduction of nacelle acceleration, velocity, and displacement response.
