Due to the environmental policies and economic reasons,the water used in some flotation operations of complex sulfide ores is recirculated,causing the ion concentration of some species to increase over time,affecting ...Due to the environmental policies and economic reasons,the water used in some flotation operations of complex sulfide ores is recirculated,causing the ion concentration of some species to increase over time,affecting the flotation of the minerals of interest.In this work,an experimental and thermodynamic analysis of the synthetic solutions was presented with a high content of calcium and sulfate ions.The study focused on evaluating the use of two aluminum compounds for the precipitation of Ca^(2+)and SO_(4)^(2−)in the form of ettringite.The amorphous aluminum hydroxide was found to be more efficient than the crystalline one,giving rise to 83%calcium and 91%sulfate removal.The XRD analysis of the solids showed the main reaction product of ettringite,accompanied by small amounts of calcite,due to the absorption of atmospheric carbon dioxide.The final solution after the chemical treatment showed residual calcium and sulfate concentrations below 200 mg/L.Finally,the kinetics of calcium removal appeared to correspond to a second order reaction with respect to calcium concentration,with an apparent activation energy of 53.48 kJ/mol,which may suggest that the ettringite precipitation process is governed by the chemical reaction.展开更多
An experiment was conducted to examine the role of Mn in P fixation through comparing with Al and Fe. Hydroxides and oxides of Al, Fe and Mn were prepared in lab under opened and closed conditions to react with phosph...An experiment was conducted to examine the role of Mn in P fixation through comparing with Al and Fe. Hydroxides and oxides of Al, Fe and Mn were prepared in lab under opened and closed conditions to react with phosphate. The newly formed Mn hydroxide showed the strongest P-fixing abilityl even several times higher than Fe hydroxide, but became the lowest rapidly due to ageing when exposed to air. Mn oxide showed the lowest p-fixing ability. Therefore, a sound consideration on P fixation should be based on both quantities and p-fixing abilities of the compounds of Fe, Al and Mn. The importance of Mn on P availability should receive more attention especially under oxidation-reduction dynamic conditions.展开更多
Plasma electrolytic oxidation(PEO) of brass was carried out in aluminate electrolytes with the addition of NaH2PO4(S1) and Na2SiO3(S2), respectively, with the aim to investigate the effect of additives on the coating ...Plasma electrolytic oxidation(PEO) of brass was carried out in aluminate electrolytes with the addition of NaH2PO4(S1) and Na2SiO3(S2), respectively, with the aim to investigate the effect of additives on the coating formation and corrosion resistance. For the PEO in S1 electrolyte, a mixed layer of AlPO4and Al2O3is formed at the initial stage, which leads to fast plasma discharges and formation of black coatings with the compositions of Al2O3,CuO, Cu2O and ZnO. However, in S2 electrolyte, plasma discharges are delayed and the coatings show a reddish color due to more Cu2O. Mott-Schottky tests show that the S1 coatings are p-type semiconductors;while the S2 coatings can be adjusted between n-type and p-type. Potentiodynamic polarization and electrochemical impedance spectroscopy(EIS) tests show that the PEO treatment can significantly improve the corrosion resistance of brass, with protection efficiency up to 91.50% and the largest charge transfer resistance of 59.95 kΩ·cm^(2) for the S1 coating.展开更多
文摘Due to the environmental policies and economic reasons,the water used in some flotation operations of complex sulfide ores is recirculated,causing the ion concentration of some species to increase over time,affecting the flotation of the minerals of interest.In this work,an experimental and thermodynamic analysis of the synthetic solutions was presented with a high content of calcium and sulfate ions.The study focused on evaluating the use of two aluminum compounds for the precipitation of Ca^(2+)and SO_(4)^(2−)in the form of ettringite.The amorphous aluminum hydroxide was found to be more efficient than the crystalline one,giving rise to 83%calcium and 91%sulfate removal.The XRD analysis of the solids showed the main reaction product of ettringite,accompanied by small amounts of calcite,due to the absorption of atmospheric carbon dioxide.The final solution after the chemical treatment showed residual calcium and sulfate concentrations below 200 mg/L.Finally,the kinetics of calcium removal appeared to correspond to a second order reaction with respect to calcium concentration,with an apparent activation energy of 53.48 kJ/mol,which may suggest that the ettringite precipitation process is governed by the chemical reaction.
文摘An experiment was conducted to examine the role of Mn in P fixation through comparing with Al and Fe. Hydroxides and oxides of Al, Fe and Mn were prepared in lab under opened and closed conditions to react with phosphate. The newly formed Mn hydroxide showed the strongest P-fixing abilityl even several times higher than Fe hydroxide, but became the lowest rapidly due to ageing when exposed to air. Mn oxide showed the lowest p-fixing ability. Therefore, a sound consideration on P fixation should be based on both quantities and p-fixing abilities of the compounds of Fe, Al and Mn. The importance of Mn on P availability should receive more attention especially under oxidation-reduction dynamic conditions.
基金supported by the National Natural Science Foundation of China (No. 51671084)the Postgraduate Scientific Research Innovation Project of Hunan Province, China (No. QL20210092)。
文摘Plasma electrolytic oxidation(PEO) of brass was carried out in aluminate electrolytes with the addition of NaH2PO4(S1) and Na2SiO3(S2), respectively, with the aim to investigate the effect of additives on the coating formation and corrosion resistance. For the PEO in S1 electrolyte, a mixed layer of AlPO4and Al2O3is formed at the initial stage, which leads to fast plasma discharges and formation of black coatings with the compositions of Al2O3,CuO, Cu2O and ZnO. However, in S2 electrolyte, plasma discharges are delayed and the coatings show a reddish color due to more Cu2O. Mott-Schottky tests show that the S1 coatings are p-type semiconductors;while the S2 coatings can be adjusted between n-type and p-type. Potentiodynamic polarization and electrochemical impedance spectroscopy(EIS) tests show that the PEO treatment can significantly improve the corrosion resistance of brass, with protection efficiency up to 91.50% and the largest charge transfer resistance of 59.95 kΩ·cm^(2) for the S1 coating.
