考虑推进过程的土压平衡盾构渗流场解析解及喷涌判别

考虑推进过程中盾构正面附加推力产生的超孔隙水压力,用解析的方法分析了盾构喷涌问题。将土舱渗流场划分成两个区域,利用叠加原理和分离变量法得到土舱水头显式级数解,将螺旋输送机内流场视为一维渗流,通过土舱与螺旋输送机交界面的连续条件确定盾构渗流场解析解。通过数值模拟结果验证了解的正确性,并进行了参数分析。参数分析表明:正常掘进状态下的盾构推力波动频率与渣土固结系数比值近似为0.1~10 m^(-2),可对应于渗透系数10^(-3)~10^(-5)cm/s,当比值大于20 m^(-2),可以忽略超孔隙水压力的影响,比值小于0.01 m^(-2)时,水压力分布近似稳态渗流状态,但比值在1 m^(-2)附近时,超孔隙水压力将存在显著的影响。结合已有的喷涌研究,给出了典型盾构在不同推力波动频率与土体固结系数比值下的临界渗透系数。通过对盾构喷涌实例进行对比,证明了解析解的喷涌判别是有效的。

Flooding Characteristics of Hydrofoil Impeller in a Two- and Three-phase Stirred Tank

The flooding characteristics of hydrofoil impeller were systematically investigated in a two-and three-phase 383 mm i.d. stirred tank operated on air, water and spherical glass beads. The volumetric solid concen-tration Cs was varied from 0 to 25%. And the superficial gas velocity Ug was at the range of 0-0.096 m·s-1. A fast and objective method for identifying flooding point NF is developed based on the statistical analysis of the pressure fluctuation signals. It is found, the effect of solid concentration on the flooding point NF depends on the gas velocity. At the lower gas velocity (Ug = 0.010 m·s-1), the solid concentration has only a minor effect. However, it displays a very significant effect on the flooding point NF at the medium and high gas velocity. The flooding point NF linearly increases with the gas velocity Ug, at lower solid concentration (Cs = 0, 10%). When Cs = 20%, the behavior of NF versus Ug becomes more complex. The correlations of the flooding characteristics in the slurry stirred tank are proposed by considering the solid concentration effect.

Pressure fluctuation and its influencing factors in circulating water pump

In order to investigate the effect of sampling frequency and time on pressure fluctuations, the three-dimensional unsteady numerical simulations were conducted in a circulating water pump. Through comparison of turbulence models with hydraulic performance experiment, SST k-co model was confirmed to study the rational determination of sampling frequency and time better. The Fast Fourier Transform （FFT） technology was then adopted to process those fluctuating pressure signals obtained. On these bases, the characteristics of pressure fluctuations acting on the tongue were discussed. It is found that aliasing errors decrease at higher sampling frequency of 17 640 Hz, but not at a lower sampling frequency of 1 764 Hz. Correspondingly, an output frequency range ten-times wider is obtained at 17 640 Hz. Compared with 8R, when the sampling time is shorter, the amplitudes may be overvalued, and the frequencies and amplitudes of low-frequency fluctuations can not be well predicted. The frequencies at the tongue are in good agreement with the values calculated by formula and the frequency compositions less than the blade passing frequency are accurately predicted.

Online dynamic measurement of saturation-capillary pressure relation in sandy medium under water level fluctuation

An online dynamic method based on electrical conductivity probe, tensiometer and datataker was presented to measure saturation-capillary pressure （S-p） relation in water-light nonaqueous phase liquid （LNAPL） two-phase sandy medium under water level fluctuation. Three-electrode electrical conductivity probe （ECP） was used to measure water saturation. Hydrophobic tensiometer was obtained by spraying waterproof material to the ceramic cup of commercially available hydrophilic tensiometer. A couple of hydrophilic tensiometer and hydrophobic tensiometer were used to measure pore water pressure and pore LNAPL pressure of the sandy medium, respectively. All the signals from ECP and tensiometer were collected by a data taker connected with a computer. The results show that this method can finish the measurement of S-R relation of a complete drainage or imbibition process in less than 60 min. It is much more timesaving compared with 10-40 d of traditional methods. Two cycles of water level fluctuation were produced, and four saturation-capillary pressure relations including two stable residual LNAPL saturations of the sandy medium were obtained during in 350 h. The results show that this method has a good durable performance and feasibility in the porous medium with complicated multiphase flow. Although further studies are needed on the signal stability and accuracy drift of the ECP, this online dynamic method can be used successfully in the rapid characterization of a LNAPL migration in porous media.

The feasibility experimental study of pumping and shunting pump under pressure in water injection station

At present in the process of water injection station operation, starting and stopping the pump caused system pressure fluctuations, and the fluctuations caused many problems about downstream injection wells. In order to eliminate the fluctuations and reduce problems, taking start pump, connect pump test under pressure in the water injection station installed the rotor frequency control system Changqing oil field developed. During the experiment, by progressively increasing the pressure pump to verify start pump with pressure feasibility test, the result shows when the pressure in the 0-25MPa pressure start and connect pump can be realized, and forecast the maximum pressure of the current start of the station with pressure pump. Start pump with pressure achieve the elimination of pressure fluctuations, provide the prerequisites about realizeing stable water injection pressure, and ultimately realize oil field water injection station to be automatic water injection laid a foundation.

Pressure fluctuation propagation of a pump turbine at pump mode under low head condition

Pressure fluctuation at the vaneless space and vanes passages is one of the most important problems for the stable operation of a pump turbine. The fluctuation appears in any operating condition. Much research has been done on the pressure fluctuation of hydraulic machinery. However, the details of pressure fluctuation propagation of the pump turbine at the pump mode have not been revealed. The modem pump turbine with high water head requires the runner to be ＂flat＂, which would induce pressure fluctuation more easily than the low head pump turbine. In this article, a high head pump turbine model is used as the re- search object. As the pressure fluctuation at off-design point is more serious than at the design point, the low head condition is chosen as the research condition. Pressure fluctuation at the vaneless space and vanes passages is predicted by the computa- tional fluid dynamics method based on k-co shear stress transport model. The experiment conducted on the test rig of the Har- bin Institute of Large Electrical Machinery is used to verify the simulation method. It proves that the numerical method is a feasible way to research the fluctuation under this operating condition. The pressure fluctuation along the passage direction is analyzed at time and frequency domains. It is affected mainly by the interaction between the runner and vanes. In the circumferential direction, the influence of the special stay vane on the pressure fluctuation is got. The amplitude in the high-pressure side passage of that vane is lower than that in the other side. The study provides a basic understanding of the pressure fluctua- tion of a pump turbine and could be used as a reference to improve the operation stability of it.

Influences of the Three Gorges Project on seismic activities in the reservoir area

Reservoir-induced earthquakes related with the construction of the Three Gorges Project have attracted great concerns of the public. Since the first water impoundment on May 25, 2003, a number of earthquakes have occurred during the water storage stages, in which the largest was the Badong M5.1 earthquake on December 16, 2013. In this paper, the relationships between seismic activities, b value, seismic parameters, and reservoir water level fluctuations are studied. In addition, based on the digital seismic waveform data obtained since 2000, the focal depth changes and focal mechanism characteristics before and after the water impoundment are studied as well. These provide us important information to understand the earthquake mechanisms. The results show that these earthquakes are typical reservoir-induced earthquakes, which are closely related to water infiltration, pore pressure, and water level fluctuations.The majority of the micro and small earthquakes are caused by karst collapse, mine collapse, bank reformation, superficial unloading, and so on. The larger earthquakes are related to the fault structures to some extent. Due to the persistent effects of water impoundment on the seismic and geological environments around the reservoir and water infiltration into the rocks, the influences on the crustal deformation field, gravity field, seepage field, and fault medium-softening action may vary gradually from a higher strength to a weaker one. Therefore, it is possible that small earthquakes and few medium earthquakes(M≤5.5) will occur in the reservoir area in the future.

Influence of Separated Vortex on Aerodynamic Noise of an Airfoil Blade

In order to clarify the mechanism by which aerodynamic noise is generated from separated flow around an airfoil blade,the relation between the attack angle and the aerodynamic noise of the blade was analyzed using a wind tunnel experiment and a CFD code.In the case of rear surface separation,the separated vortex which has a large-scale structure in the direction of the blade chord is transformed into a structure that concentrates at the trailing edge with an increase in the attack angle.The aerodynamic noise level then becomes small according to the vortex scale in the blade chord.When the flow is separated at the leading edge,a separated vortex of low pressure is formed at the vicinity of the trailing edge.The pressure fluctuations on the blade surface at the vicinity of the trailing edge become large due to the vortex in the wake.It is considered that the aerodynamic noise level increases when the flow is separated at the leading edge because the separated vortex is causing the fluctuations due to wake vortex shedding.

Dynamic analysis on pressure fluctuation in vaneless region of a pump turbine

As the pump turbine tends to be operated with high head and high rotational speed, the study of stability problems becomes more important. The pump turbine usually works at operating conditions where the guide vanes experience strong vibrations. However, most traditional studies were carried out based on constant GVO(guide vane opening) simulations. In this work, dynamic analysis on pressure fluctuation in the vaneless region of a pump turbine model was conducted using a dynamic mesh method in turbine mode. 3D unsteady simulations were conducted where GVO was closed and opened by 1° from the initial 18°. Detailed time domain and frequency domain characteristics on pressure fluctuation in the vaneless region under different guide vane rotational states compared with constant GVO simulations were investigated. Results show that, during the guide vanes oscillating process, the low and intermediate frequency components in the vaneless region are significantly different. The amplitudes of pressure fluctuation are higher than those with constant GVO simulations, which agree better with the experimental data. In addition, the pressure fluctuation increases when GVO is opened, and vice versa. It can be concluded that pressure fluctuation in the vaneless region is strongly influenced by the oscillating of the guide vanes.