Gypsum sludge,a hazardous waste generated by the non-ferrous smelting industry,presents a significant challenge for disposal and utilization.To investigate the feasibility of substituting gypsum sludge for limestone a...Gypsum sludge,a hazardous waste generated by the non-ferrous smelting industry,presents a significant challenge for disposal and utilization.To investigate the feasibility of substituting gypsum sludge for limestone as a flux for smelting,the effects of calcium sulfate(CaSO_(4))and smelting conditions on oxygen-rich smelting of lead concentrate were studied.The interaction between CaSO_(4)and sulfides facilitates the conversion of CaSO_(4)into CaO,which is crucial for slag formation.The order of the influence of sulfide minerals on the conversion of CaSO_(4)is pyrite>sphalerite>galena.When using gypsum sludge exclusively as the calcium source,under optimal conditions with a CaO/SiO_(2)mass ratio of 0.8,an FeO/SiO_(2)mass ratio of 1.2,a melting temperature of 1150℃,an oxygen flow rate of 1.3 L/min,the recovery rates of Pb and Zn in the lead-rich slag reached 85.01%and 95.69%,respectively,with a sulfur content of 2.65 wt%.The As content in the smelting slag obtained by reduction smelting was 0.02 wt%.Resource utilization of gypsum sludge in lead smelting is a feasible method.展开更多
Polyepoxysuccinic acid （PESA）, as an environmental benign biodegradable chelant, was used to remove heavy metals from the sewage sludge of Shanghai Taopu Wastewater Treatment Plant. The extraction of cadmium （Cd） ...Polyepoxysuccinic acid （PESA）, as an environmental benign biodegradable chelant, was used to remove heavy metals from the sewage sludge of Shanghai Taopu Wastewater Treatment Plant. The extraction of cadmium （Cd） from sewage sludge using aqueous solution of PESA was studied. It was found that PESA was capable of extracting Cd from the sludge, and the extraction efficiency was dependent on both pH and the concentration of the chelating reagent. The extraction efficiency decreased gradually with increasing of pH, whereas the dependency on pH decreased as the concentration of PESA increased. In the case of the high PESA to total metal ratio, e.g., 10：1, the extraction efficiency reached above 70% within the pH range from 1 to 7. The highest extraction efficiency obtained in tbe experiment was 78%. By comparing the contents of the heavy metals in sewage sludge before and after the extraction, it was found that the extracted Cd came mainly from the four fractions： acid-soluble, reducible, oxidizable, and water-soluble fractions.展开更多
Although concerns about harvesting levels of the American Horseshoe Crab, Limulus polyphemus have prompted increased research into its ecology, current understanding of the species＇ foraging ecology is mostly limited...Although concerns about harvesting levels of the American Horseshoe Crab, Limulus polyphemus have prompted increased research into its ecology, current understanding of the species＇ foraging ecology is mostly limited to mid-Atlantic populations. This study elucidates the spatial and temporal pattern of Limulus foraging on an intertidal mudflat of a northern New Eng- land estuary. A novel survey method was used to monitor Limulus foraging activity without disturbing the sediment. A fixed 50 mx2 m transect was monitored with monthly surveys of the number of Limulus feeding pits from June to October 2009, May and June 2010. Snorkelling surveys were also carried out to observe individual behavior and examine the spatial scale of activity of individual animals. Results showed frequent and intensive use of the mudflat by foraging Limulus. Limulus were actively foraging within the survey area during all months surveyed. Foraging patterns exhibited a seasonal pattern with activity levels peaking in August 2009 and increased significantly towards the end of the study in June 2010. It was also shown that Limulus intertidal foraging persisted and peaked after the spring breeding season. Observations of foraging Limulus revealed that individual predators dig multiple pits within a single high tide, with little disturbance to the sediment in between. In addition to altering the perception of Limulus as a subtidal predator outside of the breeding season, findings from this study suggests a segregation of spawning and feeding habitats, thus underscoring the need to consider a wider range of critical habitats in the management of Limulus populations展开更多
The denitrifying sulfide removal(DSR) process has recently been studied extensively from an engineering perspective. However, the importance of microbial communities of this process was generally underestimated. In th...The denitrifying sulfide removal(DSR) process has recently been studied extensively from an engineering perspective. However, the importance of microbial communities of this process was generally underestimated. In this study, the microbial community structure of a lab-scale DSR reactor was characterized in order to provide a comprehensive insight into the key microbial groups in DSR system. Results from high-throughput sequencing analysis revealed that the fraction of autotrophic denitrifiers increased from 2.34 % to 10.93% and 44.51% in the DSR system when the influent Na Cl increased from 0 g/L, to 4 g/L and 30 g/L, respectively. On the contrary, the fraction of heterotrophic denitrifiers decreased from 61.74% to 39.57%, and 24.12%, respectively. Azoarcus and Thiobacillus were the main autotrophic denitrifiers, and Thauera was the main hetetrophic denitrifier during the whole process. This study could be useful for better understanding the interaction between autotrophs and heterotrophs in DSR system.展开更多
Considering limited success in target-hitting discharge from alcohol industry, our attention was directed toward a recycling use of distillery spentwash (DS) in cassava bioethanol production by using a two-stage up-fl...Considering limited success in target-hitting discharge from alcohol industry, our attention was directed toward a recycling use of distillery spentwash (DS) in cassava bioethanol production by using a two-stage up-flow anaerobic sludge blanket bioremediation (TS-UASBB). With the TS-UASBB, 2 4 SO , COD, N and P in the effluent from the DS degraded significantly and their concentrations were kept at 0.2 g·L -1 , 2.0 g·L -1 , 1.0 g·L -1 and 15 mg·L -1 , respectively, in 13 batch processes for water-recycled ethanol fermentation. With the effluent used directly as dilution water, no heat-resistant bacteria were found alive. The thirteen-batch ethanol production individually achieved 10% after 48 h fermentation. The starch utilization ratio and total sugar consumption were 90% and 99.5%, respectively. The novel water-recycled bioethanol production process with ethanol fermentation and TS-UASBB has a considerable potential in other starchy and cellulosic ethanol production.展开更多
This paper summarizes the selected results of an extensive investigation of application of two methods （hydrothermal and mechanochemical） assisted by calcination for synthesizing belite cement from reactive mixtures...This paper summarizes the selected results of an extensive investigation of application of two methods （hydrothermal and mechanochemical） assisted by calcination for synthesizing belite cement from reactive mixtures （CaO/SiO2 molar ratio of 2） consisting of various waste kinds from fluidized brown coal combustion in Slovakian power plant and CaO addition. Based on XRD diffraction patterns and infrared spectra ofpre-treatment products, the formation of the new profiles corresponding to CSH phases with low degree of ordering as belite precursors after hydrothermal treatment as well as metastables calcium silicates and aluminosilicates in mechanosynthesized products was confirmed. Calcination of hydrothermally treated products led to transformation of CSH phases to wollastonite （CS）, belite and gehlenite phase, whereas creation oft^- and I^-C2S or wollastonite in milled reactive mixture took place. Differences in phase composition of products before and after calcination depend upon waste quality and precursor＇s synthesis conditions. Bottom ash isn＇t suitable as raw material for synthesizing belite phase because of high CaO content fixed in anhydrite form （44.1%）. Coal fly ash with low CaO content in anhydrite form （4.2%） and its mechanochemical or hydrothermal treatment in combination with subsequent heating offer opportunities for the utilization of coal fly ash as raw material for belite production.展开更多
The pollution of aquatic ecosystem by heavy metals has assumed serious proportions due to their toxicity and accumulative behavior. The toxicity metal is dependent on its chemical form and therefore removal of metal i...The pollution of aquatic ecosystem by heavy metals has assumed serious proportions due to their toxicity and accumulative behavior. The toxicity metal is dependent on its chemical form and therefore removal of metal is more meaningful than the estimation of its concentrations. In this study, the batch experiments were carried out under 30℃ to study the effect of pH, initial Cr concentration, adsorbent dose and contact time on the removal of Cr （lII）. The maximum adsorption efficiency （99%） was observed when 1.5 g of pond mud was used for removal ofCr （Ⅲ） from test solution containing 150 mg·Cr / 100 ml. The optimal pH and contact time recorded during the study were 6 and 10.0, respectively.展开更多
Processing cow manure into biogas is a solution to reduce air pollutant, because it reduces the smell of the manure up to 70%. Besides producing biogas, the sludge of biodigester can also serve as solid and liquid fer...Processing cow manure into biogas is a solution to reduce air pollutant, because it reduces the smell of the manure up to 70%. Besides producing biogas, the sludge of biodigester can also serve as solid and liquid fertilizer. The solid fertilizer can be used as carder of entomopathogenic fungi to control the pest which lives underground. The research aimed to investigate the benefits of biodigester sludge as fertilizer and carrier of entomopathogenic fungi （Cordyceps sp.） to control white grub pest. The use of organic fertilizer and pesticide in the cultivation can minimize the environmental hazard. The method used in the study was completely randomized design with four treatments, which were the addition of Cordyceps sp. corn media as much as 0, 10, 20 and 30 g/kg of sludge. Every addition was repeated three times to corn planted in a tub. To examine the effect of the treatments, the data were analyzed with ANOVA and Duncan test was applied when differences occurred between treatments. The results of the research showed that the nutrients contained in the manure which had been processed into biogas were not lost. The plants cultivated in the planting medium supplemented with sludge grew healthier, bigger, taller and had stronger and longer roots. On the contrary, the plants cultivated without sludge addition were vulnerable to white grub attack. The Cordyceps sp., which was added into the sludge, was effective to control the white grub. The concentration of Cordyceps sp. as much as 20 g/kg of sludge in corn planting medium was the most effective concentration to control white grub pest.展开更多
Abstract The principles of reduction, stabilization, harmlessness, resource utilization and low carbonization for sludge treatment and disposal were stated, and the ad- vantages and disadvantages of different sludge t...Abstract The principles of reduction, stabilization, harmlessness, resource utilization and low carbonization for sludge treatment and disposal were stated, and the ad- vantages and disadvantages of different sludge treatment methods were analyzed, from which it concluded that sludge treatment should be acted according to the practical circumstances but not blindly followed, by choosing the appropriate way of sludge treatment. Key words Sludge; Sludge treatment; Landfill; Incineration; Digestion; Land use展开更多
基金Project(2020YFC1909203)supported by the National Key R&D Project of ChinaProjects(51974364,52074355,51904339)supported by the National Natural Science Foundation of China。
文摘Gypsum sludge,a hazardous waste generated by the non-ferrous smelting industry,presents a significant challenge for disposal and utilization.To investigate the feasibility of substituting gypsum sludge for limestone as a flux for smelting,the effects of calcium sulfate(CaSO_(4))and smelting conditions on oxygen-rich smelting of lead concentrate were studied.The interaction between CaSO_(4)and sulfides facilitates the conversion of CaSO_(4)into CaO,which is crucial for slag formation.The order of the influence of sulfide minerals on the conversion of CaSO_(4)is pyrite>sphalerite>galena.When using gypsum sludge exclusively as the calcium source,under optimal conditions with a CaO/SiO_(2)mass ratio of 0.8,an FeO/SiO_(2)mass ratio of 1.2,a melting temperature of 1150℃,an oxygen flow rate of 1.3 L/min,the recovery rates of Pb and Zn in the lead-rich slag reached 85.01%and 95.69%,respectively,with a sulfur content of 2.65 wt%.The As content in the smelting slag obtained by reduction smelting was 0.02 wt%.Resource utilization of gypsum sludge in lead smelting is a feasible method.
基金Project supported by the National High Technology Research and Development Program (863 Program) of China(No.2006AA06Z384)the National Natural Science Foundation of China (No. 50478103)
文摘Polyepoxysuccinic acid （PESA）, as an environmental benign biodegradable chelant, was used to remove heavy metals from the sewage sludge of Shanghai Taopu Wastewater Treatment Plant. The extraction of cadmium （Cd） from sewage sludge using aqueous solution of PESA was studied. It was found that PESA was capable of extracting Cd from the sludge, and the extraction efficiency was dependent on both pH and the concentration of the chelating reagent. The extraction efficiency decreased gradually with increasing of pH, whereas the dependency on pH decreased as the concentration of PESA increased. In the case of the high PESA to total metal ratio, e.g., 10：1, the extraction efficiency reached above 70% within the pH range from 1 to 7. The highest extraction efficiency obtained in tbe experiment was 78%. By comparing the contents of the heavy metals in sewage sludge before and after the extraction, it was found that the extracted Cd came mainly from the four fractions： acid-soluble, reducible, oxidizable, and water-soluble fractions.
基金the National Estuarine Research Reserve Graduate Research FellowshipUNH Marine ProgramNew Hampshire Seagrant
文摘Although concerns about harvesting levels of the American Horseshoe Crab, Limulus polyphemus have prompted increased research into its ecology, current understanding of the species＇ foraging ecology is mostly limited to mid-Atlantic populations. This study elucidates the spatial and temporal pattern of Limulus foraging on an intertidal mudflat of a northern New Eng- land estuary. A novel survey method was used to monitor Limulus foraging activity without disturbing the sediment. A fixed 50 mx2 m transect was monitored with monthly surveys of the number of Limulus feeding pits from June to October 2009, May and June 2010. Snorkelling surveys were also carried out to observe individual behavior and examine the spatial scale of activity of individual animals. Results showed frequent and intensive use of the mudflat by foraging Limulus. Limulus were actively foraging within the survey area during all months surveyed. Foraging patterns exhibited a seasonal pattern with activity levels peaking in August 2009 and increased significantly towards the end of the study in June 2010. It was also shown that Limulus intertidal foraging persisted and peaked after the spring breeding season. Observations of foraging Limulus revealed that individual predators dig multiple pits within a single high tide, with little disturbance to the sediment in between. In addition to altering the perception of Limulus as a subtidal predator outside of the breeding season, findings from this study suggests a segregation of spawning and feeding habitats, thus underscoring the need to consider a wider range of critical habitats in the management of Limulus populations
基金supported by the National Natural Science Foundation of China under Grant No.21307160the Natural Science Foundation of Shandong Province under Grant No.ZR2013EEQ030the Fundamental Research Funds for the Central Universities under Grant No.R1404005A
文摘The denitrifying sulfide removal(DSR) process has recently been studied extensively from an engineering perspective. However, the importance of microbial communities of this process was generally underestimated. In this study, the microbial community structure of a lab-scale DSR reactor was characterized in order to provide a comprehensive insight into the key microbial groups in DSR system. Results from high-throughput sequencing analysis revealed that the fraction of autotrophic denitrifiers increased from 2.34 % to 10.93% and 44.51% in the DSR system when the influent Na Cl increased from 0 g/L, to 4 g/L and 30 g/L, respectively. On the contrary, the fraction of heterotrophic denitrifiers decreased from 61.74% to 39.57%, and 24.12%, respectively. Azoarcus and Thiobacillus were the main autotrophic denitrifiers, and Thauera was the main hetetrophic denitrifier during the whole process. This study could be useful for better understanding the interaction between autotrophs and heterotrophs in DSR system.
基金Supported by the National High Technology Research and Development Program of China （2008AA10Z338） the National Natural Science Foundation of China （20906041）
文摘Considering limited success in target-hitting discharge from alcohol industry, our attention was directed toward a recycling use of distillery spentwash (DS) in cassava bioethanol production by using a two-stage up-flow anaerobic sludge blanket bioremediation (TS-UASBB). With the TS-UASBB, 2 4 SO , COD, N and P in the effluent from the DS degraded significantly and their concentrations were kept at 0.2 g·L -1 , 2.0 g·L -1 , 1.0 g·L -1 and 15 mg·L -1 , respectively, in 13 batch processes for water-recycled ethanol fermentation. With the effluent used directly as dilution water, no heat-resistant bacteria were found alive. The thirteen-batch ethanol production individually achieved 10% after 48 h fermentation. The starch utilization ratio and total sugar consumption were 90% and 99.5%, respectively. The novel water-recycled bioethanol production process with ethanol fermentation and TS-UASBB has a considerable potential in other starchy and cellulosic ethanol production.
文摘This paper summarizes the selected results of an extensive investigation of application of two methods （hydrothermal and mechanochemical） assisted by calcination for synthesizing belite cement from reactive mixtures （CaO/SiO2 molar ratio of 2） consisting of various waste kinds from fluidized brown coal combustion in Slovakian power plant and CaO addition. Based on XRD diffraction patterns and infrared spectra ofpre-treatment products, the formation of the new profiles corresponding to CSH phases with low degree of ordering as belite precursors after hydrothermal treatment as well as metastables calcium silicates and aluminosilicates in mechanosynthesized products was confirmed. Calcination of hydrothermally treated products led to transformation of CSH phases to wollastonite （CS）, belite and gehlenite phase, whereas creation oft^- and I^-C2S or wollastonite in milled reactive mixture took place. Differences in phase composition of products before and after calcination depend upon waste quality and precursor＇s synthesis conditions. Bottom ash isn＇t suitable as raw material for synthesizing belite phase because of high CaO content fixed in anhydrite form （44.1%）. Coal fly ash with low CaO content in anhydrite form （4.2%） and its mechanochemical or hydrothermal treatment in combination with subsequent heating offer opportunities for the utilization of coal fly ash as raw material for belite production.
文摘The pollution of aquatic ecosystem by heavy metals has assumed serious proportions due to their toxicity and accumulative behavior. The toxicity metal is dependent on its chemical form and therefore removal of metal is more meaningful than the estimation of its concentrations. In this study, the batch experiments were carried out under 30℃ to study the effect of pH, initial Cr concentration, adsorbent dose and contact time on the removal of Cr （lII）. The maximum adsorption efficiency （99%） was observed when 1.5 g of pond mud was used for removal ofCr （Ⅲ） from test solution containing 150 mg·Cr / 100 ml. The optimal pH and contact time recorded during the study were 6 and 10.0, respectively.
文摘Processing cow manure into biogas is a solution to reduce air pollutant, because it reduces the smell of the manure up to 70%. Besides producing biogas, the sludge of biodigester can also serve as solid and liquid fertilizer. The solid fertilizer can be used as carder of entomopathogenic fungi to control the pest which lives underground. The research aimed to investigate the benefits of biodigester sludge as fertilizer and carrier of entomopathogenic fungi （Cordyceps sp.） to control white grub pest. The use of organic fertilizer and pesticide in the cultivation can minimize the environmental hazard. The method used in the study was completely randomized design with four treatments, which were the addition of Cordyceps sp. corn media as much as 0, 10, 20 and 30 g/kg of sludge. Every addition was repeated three times to corn planted in a tub. To examine the effect of the treatments, the data were analyzed with ANOVA and Duncan test was applied when differences occurred between treatments. The results of the research showed that the nutrients contained in the manure which had been processed into biogas were not lost. The plants cultivated in the planting medium supplemented with sludge grew healthier, bigger, taller and had stronger and longer roots. On the contrary, the plants cultivated without sludge addition were vulnerable to white grub attack. The Cordyceps sp., which was added into the sludge, was effective to control the white grub. The concentration of Cordyceps sp. as much as 20 g/kg of sludge in corn planting medium was the most effective concentration to control white grub pest.
基金Supported by the Science and Technology Planning Project of Chongqing Municipality(cstc2011pt-gc80019)the Plan for the Construction of Technical Research and Development Base of Chongqing Municipality(cstc2014gjhz20001)the International Science&Technology Cooperation Program of China(2015DFR70390)~~
文摘Abstract The principles of reduction, stabilization, harmlessness, resource utilization and low carbonization for sludge treatment and disposal were stated, and the ad- vantages and disadvantages of different sludge treatment methods were analyzed, from which it concluded that sludge treatment should be acted according to the practical circumstances but not blindly followed, by choosing the appropriate way of sludge treatment. Key words Sludge; Sludge treatment; Landfill; Incineration; Digestion; Land use
