炼化企业循环水系统粘泥污堵问题分析及解决措施

对某炼化企业循环水系统中大量粘泥污堵物滋生问题进行分析,一方面采取优化清洗剥离方案,增强清洗、剥离及对粘泥污堵物的溶解效果,并缩短清洗周期和及时调整杀菌方案等措施控制了细菌滋生,另一方面采取调整pH值与碱度、降低浓缩倍数及优化阻垢分散剂等措施防止结垢。解决了循环水系统粘泥污堵问题,达到控制腐蚀速率与保证循环水系统正常运行的目的。

城市河道底泥污染及清淤治理研究

某国内清淤工程河道严重淤积,对河道底泥污染程度进行分析,其重金属指标、有机质及氮磷严重超标。根据河道现场实际情况,采水力冲洗清淤与人工清淤相结合的方式对河道进行治理,并对清理的淤泥采用机械脱水固结一体化处理工艺,脱水尾水通过净化处理后,用于水利冲挖用水,泥饼转运至指定的消纳场所,使大布涌兴贤支涌水体生态环境得到改善,消除水利安全隐患。

五里湖底泥污染物浅析

1五里湖水质现状五里湖地处太湖北部,湖区面积约5.6km2,是无锡市著名的风景旅游区.但随着城乡经济的高速发展,人口的增加和生活方式的改变,五里湖水污染日益加重,水质逐年下降,富营养问题严重,藻类接连爆发,影响了旅游区的环境形象.

Resource utilization of hazardous gypsum sludge in oxidation smelting of lead concentrate

Gypsum sludge,a hazardous waste generated by the non-ferrous smelting industry,presents a significant challenge for disposal and utilization.To investigate the feasibility of substituting gypsum sludge for limestone as a flux for smelting,the effects of calcium sulfate(CaSO_(4))and smelting conditions on oxygen-rich smelting of lead concentrate were studied.The interaction between CaSO_(4)and sulfides facilitates the conversion of CaSO_(4)into CaO,which is crucial for slag formation.The order of the influence of sulfide minerals on the conversion of CaSO_(4)is pyrite>sphalerite>galena.When using gypsum sludge exclusively as the calcium source,under optimal conditions with a CaO/SiO_(2)mass ratio of 0.8,an FeO/SiO_(2)mass ratio of 1.2,a melting temperature of 1150℃,an oxygen flow rate of 1.3 L/min,the recovery rates of Pb and Zn in the lead-rich slag reached 85.01%and 95.69%,respectively,with a sulfur content of 2.65 wt%.The As content in the smelting slag obtained by reduction smelting was 0.02 wt%.Resource utilization of gypsum sludge in lead smelting is a feasible method.

Comparative study of two biological nitrogen removal processes:A/O process and step-feeding process

Two biological nitrogen removal processes are compared in the aspect of nitrogen removal, process operation and energy saving. Results show that when the returned sludge ratio is 50% of the inflow rate, the step-feeding process achieves over 80% total nitrogen （TN） removal efficiency, but the TN removal efficiency of the A/O process is only 40%. Moreover, filamentous sludge bulking can be well restrained in the step-feeding process. Given the conditions of a returned sludge ratio of 100% and a nitrifying liquor recycle ratio of 200%, the TN removal efficiency is 78.32% in the A/O process, but the sludge volume index （SVI） value increases to 143 mL/g. In the step-feeding process, the SVI is only 94.4 mL/g when the TN removal efficiency reaches 81. 1%. The step-feeding process has distinct advantages over the A/O process in the aspects of practicability, nitrogen removal and operating stability.

Effect of Sludge from Different Sources on Solid Anaerobic Digestion of Corn Straw

[Objective] The aim was to study on effect of sludge from different sources on biogas yield efficiency through anaerobic digestion of corn straw. [Method] The present research studied on daily biogas yield and the accumulated biogas amount through anaerobic digestion of corn straw and sludges from four sources. [Result] The accumulated biogas yields produced from sludges in four sources from high to low were granular sludge, river sediments, concentrated sludge and filtered sludge. The first one proved the highest at 3.73 and 56.29 L/kg VS in daily biogas yield and the accumulated biogas. [Conclusion] The research laid foundation for full utilization of straw, improvement of energy utilization and sustainable development.

Effects of Sludge Application on Accumulition of Heavy Metals in Rape and Soil

[Objective] This study aimed to provide reliable theoretical basis for re- source utilization of sludge. [Method] By using pot experiment, variations of the yield index and salt content of rape and the accumulation of three kinds of heavy metals in rape plants and soil including Hg, As and Zn were explored. [Result] The results showed that medium sludge level （50 g/pot） significantly increased the rape yield and root/shoot ratio; when the application amount of sludge reached 100 g/pot, the fertil- ization effect of sludge on potted rape yield was significantly reduced. Compared with chemical fertilizer and chicken manure, sludge promoted N and P absorption of rape more significantly, but the effect of sludge application on K absorption was less significant than chicken manure. Sludge can increase the soil salinity, which is higher than the chemical fertilizer and chicken manure, but the effect was not significant. Compared with chemical fertilizer and chicken manure treatments, the Hg, As and Zn contents in rape plants and soil after sludge application increased, to be specific, Hg content increased relatively significantly. Hg, As and Zn contents in rape plants and soil were all in accordance with China National Safety Standards for Heavy Met- als in Vegetables and China National Environmental Quality Standards for Soils. [Conclusion] Short-term sludge application will not lead to secondary heavy metal pollution of agricultural soils, but the Hg content should be monitored and controlled in long-term sludge application.

Total concentrations and different fractions of heavy metals in sewage sludge from Guangzhou, China

Dewatered municipal sludge samples were collected from five municipal wastewater treatment plants （WWTPs） and one industrial WWTP in Guangzhou, China. A number of agricultural parameters and total metal concentrations in the sludge were determined. Metal speciation was also studied. The results showed that sewage sludge had high organic carbon, and was rich in such nutrients as N and P. The concentrations of Mn, Zn, and Cu were the highest, followed by Ni, Pb, and Cr, Cd had the lowest concentration. In addition, the concentrations of the aforementioned heavy metals in the sludge samples were higher than those recorded in the background data for crop soils. With the exception of Cu and Cd from site S1, and Ni from sites S1, $2, and $5, all other metal concentrations conformed to permissible levels prescribed by the national application standard of acid soil in China （GB 18918--2002）. The results of the BCR sequential extraction showed that the concentrations of Mn and Zn were predominant in acid-soluble/exchangeable and reducible fractions. Cu was principally distributed in oxidizable and residual fractions, whereas Cr was present in oxidizable and residual fractions, Pb was found in the state of residual fractions, and the distribution of Ni and Cd did not show significant characteristics.

Influence of Pyrolytic Biochar on Settleability and Denitrification of Activated Sludge Process

Biochar is a massively produced by-product of biomass pyrolysis to obtain renewable energy and has not been fully used. Incomplete separation of sludge and effluent and insufficient denitrification of sewage are two of main factors that influence the efficiency of activated sludge process. In this work, we proposed a new utilization of biochar and investigated the effect of biochar addition on the performance of settleability and denitrification of activated sludge. Results show that the addition of biochar can improve the settleability of activated sludge by changing the physicochemical characteristics of sludge （e.g., flocculating ability, zeta-potential, hydrophobicity, and extracellular polymeric substances constituents）. Moreover, the dissolved organic carbon released from biochar obtained at lower pyrolysis temperature can improve the nitrate removal efficiency to a certain extent.

Early-warning of Mud Expansion in Sewage Treatment Plants by A/O Technology

Early-warning is an effective way to control mud expansion in sewage treatment plants with A/O technology. In the research, warning indices and technology of active mud were explored and it is concluded that bacteria growth in mud can be obtained by observation of mud appearance and microorganism variety, and measurement of the number of filamentous bacteria, water quality, mud load and age, dissolved oxygen, temperature and pH. Furthermore, filamentous bacteria in mud can be researched through fluorescence in situ hybridization, PCR-temperature denaturing gradient gel electrophoresis and PCR-single-stranded conformation polymorphism in order to determine the characters and states of active mud to achieve early warning of mud expansion.

H_2S removal in landfill leachate treatment using UASB reactor

Leachate from a sanitary landfill site in Chengdu, China is treated using a hybrid-UASB reactor at pilot scale. H2S, resulting from the anaerobic bioconversion process of sulfate-reducing bacteria（SRB）, inhibits the growth and activity of methane-producing bacteria（MPB）and poses serious problems of pollution, so FeCl3is used for H2S removal. The results show that the system performs well in the treatment process. COD removal generally increases with the increase in the organic loading rate（OLR）, while the sulfate removal decreases slowly. As the OLR is higher than 7 kgCOD/（m3·d）, both COD and sulfate removal tend to be stable. When the reactor is operated at the design load of 9 kgCOD/（m3·d）, COD and sulfate removal remain about 79% and 91%, respectively. At the same time, the percentage of COD removed by SRB（CODSRB）also decreases from 8.9% to 4.0%. With FeCl3 addition, COD removal increases to 83%, while sulfate removal and CODSRBfurther decrease to 89% and 1.89%, respectively. According to the mass balance, nearly 82% of the sulfur is prevented from converting into H2S. Moreover, when the FeCl3 dosage is more than 1.6 g/L leachate, H2S can be removed totally from the biogas. Therefore, the application of FeCl3 for H2S removal in leachate treatment using the UASB reactor is very suitable and viable.

Discussion on Comprehensive Treatments of Sewage Sludge and Mine Wastewater in Small Towns

An engineering technology for the comprehensive treatments of sewage sludge and mine wastewater in smal town was introduced. As fil ing materials, gangue to fil in the col apse basin, construction waste, household refuse and ex-cess sludge as wel as clay were mixed with water into organic fil ing soil, turning the waste sludge into useful soil matrix, which solved the difficulties in growing plants in the reclaimed land that lack of organic soil. The col apse basin was de-signed into oxidation pond, wetland and land infiltration system to treat industrial wastewater and domestic wastewater, realizing the up-to-standard release after sewage treatment.

Study on Limited Filamentous Sludge Bulking Test in A/O Activated Sludge Process

[Objective] This study aimed to make use of the limited filamentous sludge bulking characteristics to purify water quality and save energy. [Method] The effects of dissolved oxygen （DO） on sludge bulking were explored by changing the DO con- centration in the aerobiotic pool of NO system from the low load （0.25 kg COD/（kg MLSS.d）） and the medium to high load （0.55 kgCOD/（kg MLSSod））. [Result] In the NO activated sludge system, when the sludge load was 0.25 kg COD/（kg MLSS.d）, DO=1.5 mg/L, the sludge index was at around 250, while when the sludge load- ing was 0.55 kg COD/（kg MLSS.d）, DO=1.5 mg/L, the sludge index was close to 300, occurring the limited filamentous bulking. The bulked sludge still showed high removal rates to COD, SS, nitrogen and phosphorus. [Conclusion] It could improve the oxygen transfer rate and reduce the aeration rate at low DO conditions to achieve energy-saving.

Screening of a Novel Bioflocculant-producing Strain and Research on Its Flocculation

[Objective] This study aimed to screen a bacterial strain capable of producing bioflocculant. [Method] A bacterial strain T-11 capable of producing bioflocculant was isolated from activated sludge. Detailed tests on the morphological, physiological and biochemical characteristics were carried out and identification was performed to identify the strain. Finally, the bioflocculant was isolated and purified, and the flocculating activity and chemical characteristics were measured. [Result] It was identified as Serratia plumuthica based on its morphological, physiological and biochemical characteristics. This strain secreted flocculant best in a culture medium which included sucrose and NaNO3. The maximal cell growth was achieved within 10 h and the flocculating activity paralleled to it. It was found to be effective for flocculation of kaolin suspension, when added at a final concentration of 0.7 mg/L, over a range of pHs （2-7）, and temperature （approximately 30-80 ℃）. Chemical analysis indicated that the bioflocculant was an acidic polysaccharide consisting of glucose, glucuronic acid and galactose, talose and altrose. Infrared spectrum analysis also revealed typical characteristics of polysaccharides. [Conclusion] The biofloccu- lants produced by strain T-11 can greatly improve the ability of activated sludge to settle.

Effects of Red Mud on the Remediation of Pb, Zn and Cd in Heavy Metal Contaminated Paddy Soil

[Objective] To study the remediation efficiency of red mud on Pb, Zn and Cd in the heavy metal contaminated paddy soil of mine area, to clarify its remediation mechanism and fertilizer efficiency on heavy metal contaminated soil. [Method] The soil incubation experiment was conducted to study the effect of red mud on the pH values and electrical conductivity （EC）, and the remediation efficiency of red mud on lead （Pb）, zinc （Zn） and cadmium （Cd） in heavy metal contaminated soil. [Result] Red mud addition reduced the content of exchangeable Pb, Zn and Cd in the soil significantly. Compared with the control, when incubated for 30, 60 and 90 d with the red mud dosage of 4% （W/W）, the exchangeable Pb content was decreased by 39.25%, 41.38% and 50.19%; exchangeable Zn content was decreased by 49.26%, 57.32% and 47.16%; and exchangeable Cd content was decreased by 19.53%, 24.06% and 25.70%, respectively. The application of red mud had significant impact on the share of Pb, Zn and Cd contents in five forms, and different amounts of red mud application all reduced the proportion of exchangeable Pb, Zn and Cd to the total Pb, Zn and Cd. In addition, the proportion of exchangeable Pb, Zn and Cd to total Pb, Zn and Cd decreased with the increasing amount of red mud addition. [Conclusion] The study provided references for reasonable application of red mud and reduction of heavy metal pollution in paddy soil.

STUDY AND SIMULATION OF AN ACTIVATED SLUDGE TREATMENT FOR METHYL VIOLET WASTE WATER

This paper researched a promising biological treatment of methyl violet waste water by methods of activated sludge.Effects of temperature and pH were studied on this process.Kinetic equation of the substrate biodegradation was investigated in the experimental range.It was studied and simulated that flow within the bubble region of this bioreactor according to the κ ε two fluid equation.Simulation results agree well with experimental data.

Optimization of Extraction Conditions of Extracellular Polymeric Substances from Activated Sludge

[Objective] To explore the optimal extraction conditions of extracellular polymeric substances （EPS） from activated sludge. [Method] The efficiency of five methods （H2SO4, formaldehyde-NaOH, mixing, heating and NaOH） on the extraction of EPS was investigated comparatively. The optimal extraction conditions of the most suitable method were determined. [Result] NaOH method is most effective in extracting EPS with less DNA contamination and shortened extraction period. The optimal extraction condition was pH of 11, extraction time of 10 min and agitation speed of 80-120 r/min. [Conclusion] The determined optimal extraction condition provided theoretical basis for EPS study.

CHARACTERISTICS OF THERMOPHILIC ANAEROBIC ACIDOGENESIS OF STARCH WASTEWATER

Acidogenic dissimilation of synthetic starch wastewater (1 000～10 000 mg COD·L -1 ) was studied in a thermophilic (55 ℃) upflow anaerobic sludge blanket (UASB) reactor.The production of volatile fatty acids (VFA) was proportional to the chemical oxygen demand (COD) loading rate.The yield of VFA was around 0.28 g VFA/g COD over the COD loading rate from 1.25 to 30 g COD·L -1 ·d -1 and the hydraulic retention time from 8.8 h to 24 h.Distribution of organic acids,the contents of propionic and butyric acids in the effluent in particular were also dependent on the COD loading rate.The thermophilic UASB reactor showed a stable performance on hydrolysis and acidogenesis of starch as well as suspended solid removal at short hydraulic retention times and high influent pH(10～11),during the operation of 110 d.

火焰原子吸收光度法测定活性污泥的金属元素

对火焰原子吸收光度法测定工业废水生化处理剩余活性污泥中十三种金属元素进行了研究,选择和优化,确定了元素测定的最佳工作条件,并对实际样品进行了测定,取得了满意的效果。