从钒浸出液除磷泥中回收钒的研究

采用硫酸浸出-铁盐沉淀的方法从钒浸出液除磷泥中回收钒,考察了浸出及沉淀参数对钒收率的影响。试验结果表明:在硫酸浓度2.7mol/L、液固比5∶1、浸出温度70℃和浸出时间30min的优化条件下,钒浸出率超过97.1%。酸浸液经硫酸铁沉淀后,钒收率为92.13%且所得钒酸铁中钒含量为33.92%。该工艺获得的钒酸铁可用于冶炼低钒铁。

Competition for Single Carbon Source Between Denitrification and Phosphorus Release in Sludge under Anoxic Condition

In order to investigate the competition for carbon source between denitrification and phosphorus release processes,simultaneous phosphorus release and denitrification in sludge operated in anoxic,aerobic mode are investigated by varying the ratio of influent COD to nitrogenous compound concentration under anoxic condition using a lab-scale sequencing batch reactor（SBR）.The results show that the nitrate reduction rate is nearly independent of the ratio of influent COD to nitrate under anoxic condition.More NOx^--N in the influent leads to less PO4^3--P release during the feeding period.However, PO4^3--P release proceeds at a low rate simultaneously with denitrification even when the influent NOx^--N concentration is as large as 20 mg·L^-1and its rate is increased obviously when NOx^--N is denitrified to a concentration lower than 0.5 mg·L^-1.The variation of pH during anoxic period gives some information about the biochemical reactions of denitrification and PO4^3--P release.When more nitrate is present in the influent,more acetate uptake in feeding period is used for direct microorganism growth.

Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process

This paper studied the effect of ferric chloride on waste sludge digestion,dewatering and sedimentation under the optimized doses in co-precipitation phosphorus removal process.The experimental results showed that the concentration of mixed liquid suspended solid(MLSS) was 2436 mg.L-1 and 2385 mg.L-1 in co-precipitation phosphorus removal process(CPR) and biological phosphorous removal process(BPR),respectively.The sludge reduction ratio for each process was 22.6% and 24.6% in aerobic digestion,and 27.6% and 29.9% in anaerobic digestion,respectively.Due to the addition of chemical to the end of aeration tank,the sludge content of CPR was slightly higher than that of BPR,but the sludge reduction rate for both processes had no distinct difference.The sludge volume index(SVI) and sludge specific resistance of BPR were 126 ml.g-1 and 11.7×1012 m.kg-1,respectively,while those of CPR were only 98 ml.g-1 and 7.1×1012 m.kg-1,indicating that CPR chemical could improve sludge settling and dewatering.

Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch

A pilot-scale,pre-anoxic-anaerobic oxidation ditch was used in this study to treat municipal wastewater with limited carbon source.A novel return activated sludge(RAS) pre-concentration tank was adopted for improv-ing the phosphorus removal efficiency and the effects of RAS pre-concentration ratio were studied.Under the opti-mal operational condition,the suspended total phosphorus(STP) and the total phosphorus(TP) removal efficiencies were around 58.9% and 63.9% respectively and the effluent-P was lower than 0.8 mg·L-1.The reason is that with the optimal RAS pre-concentration ratio,nitrate is completely removed with endogenous carbon source and the secondary phosphorus release is strictly restrained in the pre-anoxic tank.Therefore,the anaerobic phosphorus release and the carbon source uptake by phosphorus accumulation organisms(PAOs) in the sludge,which are ex-tremely important to the phosphorus removal process,can be fully satisfied.Furthermore,the oxidation-reduction potential is proved to be suitable for controlling the RAS pre-concentration ratio due to influent fluctuation and varied conditions.The novel modified system is also beneficial for PAO accumulation.

Enhanced biological nutrient removal in modified carbon source division anaerobic anoxic oxic process with return activated sludge pre-concentration

A pilot-scale modified carbon source division anaerobic anoxic oxic(AAO) process with pre-concentration of returned activated sludge(RAS) was proposed in this study for the enhanced biological nutrient removal(BNR) of municipal wastewater with limited carbon source. The influent carbon source was fed in step while a novel RAS pre-concentration tank was adopted to improve BNR efficiency, and the effects of an influent carbon source distribution ratio and a RAS pre-concentration ratio were investigated. The results show that the removal efficiency of TN is mainly influenced by the carbon source distribution ratio while the TP removal relies on the RAS pre-concentration ratio. The optimum carbon source distribution ratio and RAS pre-concentration ratio are 60% and 50%, respectively, with an inner recycling ratio of 100% under the optimum steady operation of pilot test, reaching an average effluent TN concentration of 9.8 mg·L-1with a removal efficiency of 63% and an average TP removal efficiency of 94%. The mechanism of nutrient removal is discussed and the kinetics is analyzed. The results reveal that the optimal carbon source distribution ratio provides sufficient denitrifying carbon source to each anoxic phase, reducing nitrate accumulation while the RAS pre-concentration ratio improves the condition of anaerobic zone to ensure the phosphorus release due to less nitrate in the returned sludge. Therefore, nitrifying bacteria, denitrifying bacteria and phosphorus accumulation organisms play an important role under the optimum condition, enhancing the performance of nutrient removal in this test.

Enhanced Biological Phosphorus Removal with Pseudomonas putida GM6 from Activated Sludge

The enhanced biological phosphorus removal （EBPR） method is widely adopted for phosphorus removal from wastewater, yet little is known about its microbiological and molecular mechanisms. Therefore, it is difficult to predict and control the deterioration of the EBPR process in a large-scale municipal sewage treatment plant. This study used a novel strain isolated in the laboratory, Pseudomonas putida GM6, which had a high phosphate accumulating ability and could recover rapidly from the deteriorated system and enhance the capability of phosphorus removal in activated sludge. Strain GM6 marked with gfp gene, which was called GMTR, was delivered into a bench-scale sequencing batch reactor （SBR） of low efficiency, to investigate the colonization of GMTR and removal of phosphorus. After 21 days, the proportion of GMTR in the total bacteria of the sludge reached 9.2%, whereas the phosphorus removal rate was 96%, with an effluent concentration of about 0.2 mg L^-1. In the reactor with the addition of GMTR, phosphorus was removed quickly, in 1 h under anaerobic conditions, and in 2 h under aerobic conditions. These evidences were characteristic of EBPR processes. Field testing was conducted at a hospital sewage treatment facility with low phosphorus removal capability. Twentyone days after Pseudomonas putida GM6 was added, effluent phosphorus concentration remained around 0.3 mg L^-1, corresponding to a removal rate of 96.8%. It was therefore demonstrated that Pseudomonas putida GM6 could be used for a quick startup and enhancement of wastewater biological phosphorus removal, which provided a scientific basis for potential large-scale engineering application.

Performance of biological phosphorus removal and characteristics of microbial community in the oxic-settling-anaerobic process by FISH analysis

Performance of biological phosphorus removal in the oxic-settling-anaerobic(OSA) process was investigated. Cell staining and fluorescent in situ hybridization(FISH) were used to analyze characteristics and microbial community of sludge. Experimental results showed that phosphorus removal efficiency was near 60% and the amount of biological phosphorus accumulation in aerobic sludge of the OSA system was up to 26.9 mg/g. Biological phosphorus removal efficiency was partially inhibited by carbon sources in the continuous OSA system. Contrasted to the OSA system,biological phosphorus removal efficiency was enhanced by 14% and the average total phosphorus(TP) contents of aerobic sludge were increased by 0.36 mg/g when sufficient carbon sources were supplied in batch experiments. Staining methods indicated that about 35% of microorganisms had typical characteristics of phosphorus accumulating organisms(PAOs) . FISH analysis demonstrated that PAOMIX-binding bacteria were predominant microbial communities in the OSA system,which accounted for around 28% of total bacteria.