柱形Pt-SDB催化剂的水–氢交换高处理量工艺

摘要:研究了基于柱形Pt-SDB催化剂的水–氢催化交换工艺, 进行了柱形Pt-SDB催化剂的流体力学性能实验并讨论了填料规格、填料催化剂装填比、反应温度、气液比、处理量等对水–氢交换传质单元高度和传质系数的影响。结果表明,催化活性较低的柱形Pt-SDB催化剂,具有液泛气速高、持液量稳定、单位床层高度压降低等优点;柱形Pt-SDB催化剂水–氢催化交换的高处理量工艺条件为θ环填料与催化剂填装比例1:1、反应温度70℃~75℃、气液比1:1、空塔气速0.3 m/s。

循氢机循环量及相关参数波动分析报告

加氢精制装置全年处理量120万t,于2008年1月建成投产。以常减压直镏柴油和少量焦化汽柴油为原料,将原料中金属、硫、氮、氧等脱出。2010年1月在装置高处理量时,循环氢压缩机入口流量、原料泵出口流量、新氢机出口压力、系统压力等相关参数均出现波动。通过类似异常情况中的数据的比对和查找相关资料得出结论以供参考。

Design and Simulation of High-power LED Array Packaging

Thermal management is one of the key technologies for high-power Light emitting diode(LED)entering into the general illuminating field.Successful thermal management depends on optimal packaging structure and selected packaging materials.In this paper,the aluminum is employed as a substrate of LED,3×3 array chips are placed on the substrate,heat dissipation performance is simulated using finite element analysis(FEA)software,analyzed are the influences on the temperature of the chip with different convection coefficient,and optical properties are simulated using optical analysis software.The results show that the packaging structure can not only effectually improve the thermal performance of high-power LED array but also increase the light extraction efficiency.

Microstructure and performance of Al-Si alloy with high Si content by high temperature diffusion treatment

The Al-Si alloy with high Si content was prepared by pressure infiltration. Microstructure observation shows that three-dimensional structure （3D-structure） is obtained from irregular sharp Si particles via high temperature diffusion treatment （HTDT）. Flat Si-Al interfaces transform to smooth curves, and Si phases precipitate in Al and Si-Al interface. The bonding of Si-Al interface is improved by HTDT, which improves the mechanical performance of Al-Si alloy. The bending strength of 3D-Al-Si alloy increases by 6% compared with that of Al-Si alloy, but the elastic modulus changes a little. The coefficient of thermal expansion （CTE） of the 3D-Al-Si alloy is 7.7×10^-6/℃ from 20℃ to 100 ℃, which decreases by 7% compared with that of Al-Si alloy. However, HTDT has little effect on the thermal conductivity of Al-Si alloy.

INTRODUCTION OF THE HIGH THROUGHPUT SCREENING SYSTEM

In this article, we introduce the system of high throughput screening (HTS). Its role in new drug study and current development is described. The relationship between research achievements of genome study and new type screening model of new drugs is emphasized. The personal opinions of current problems about HTS study in China are raised.

Affinity ultrafiltration of DNA topoisomerases-targeted compounds determined with HPLC／ESI-MS for drug candidate screening

A method of screening assay is demonstrated. The approach is based on the affinity of antitumor candidates for topoisomerases. In this method, antitumor candidates are fished out using topoisomerases as targets. Traditional analysis of complex compounds typically encounters signal suppression due to the relatively low concentrations, but enzyme-affinity screening for the active compounds can effectively concentrate the desired analysts into a small volume of high concen-tration. Active compounds are separated from non-affinity compounds by ultrafiltration. The molecules-enzymes complexes that are retained on the filter are subsequently separated by acidification to obtain the topoisomerases-affinity compounds for analysis on High Performance Liquid Chromatography coupled with electrospray ionization mass spectrometric detec-tion (ESI-MS). This enzyme-affinity based screening assay provides a highly specific and efficient method that can directly screen, identify, and acquire drug candidates thus improving the accuracy and speed of high-throughput screening activities.

Comparative Studies of Thermal Stability of Coal Tar Pitches

In the present work, three medium softening point coal tar pitches were used for comparative thermal stability and under-storage stability investigation. Powders of the pitches were found to be different under storage： one of the pitches was caked and slumped after 7-day or longer storage. For thermal stability investigation the soft temperature treatment （265℃） of coal tar pitches was used. Detailed study of initial and treated pitches was carried out. Experimental results demonstrated that LMW-HC （high low-molecular-weight hydrocarbons） and oxygen content influence pitch quality characteristics in a negative way under long-term storage and lead to highest properties change after thermal stability treatment.

Sorption and Diffusion Behavior of Carbon Dioxide into Poly（l-lactic acid） Films at Elevated Pressures

Equilibrium sorption amount, desorption diffusion coefficients and sorption diffusion coefficients of CO2 in poly（l-lactic acid） （PLLA） films at elevated pressures were determined by the gravimetric method, in which the Fick＇s diffusion model was applied to analyze both the desorption and sorption processes. The equilibrium sorption amount of CO2 in PLLA increased with lowering temperature and elevating pressure at the temperature range from 40 to 60 ℃ and pressure from 10^4 to 2x10^4 kPa. Desorption diffusion coefficients were greatly influenced by the equilibrium sorption amount, and they were in the same order of magnitude as the sorption diffusion coefficients. The scan electron microscope （SEM） photos demonstrated that there was no foaming phenomenon of the PLLA film during desorption and sorption processes. The XRD spectra implied that the crystalline degree of PLLA film decreased after CO2 processing. It was concluded that PLLA polymer could be well swollen and plasticized by supercritical CO2.

Inhibitory effects and mechanisms of high molecular-weight phlorotannins from Sargassum thunbergii on ADP-induced platelet aggregation

We evaluated the effects of high molecular-weight phlorotannins from Sargassum thunbergii(STP) on ADP-induced platelet aggregation and arachidonic acid(AA) metabolism in New Zealand white rabbits and Wistar rats.The inhibition of STP on platelet aggregation was investigated using a turbidimetric method,and the levels of the terminal products of AA metabolism were measured using the corresponding kits for maleic dialdehyde(MDA),thromboxane B2(TXB2) and 6-keto-prostaglandin F1α(6-keto-PGF1α) by colorimetry and radioimmunoassay,as appropriate.We found that STP could inhibit ADP-induced platelet aggregation,and the inhibitory ratio was 91.50% at the STP concentration of 4.0 mg/mL.Furthermore,STP markedly affected AA metabolism by decreasing the synthesis of MDA(P<0.01) and increasing the synthesis of 6-keto-PGF1α,thus changing the plasma TXB2/6-keto-PGF1α balance when the platelets were activated(P<0.01).Therefore,STP altered AA metabolism and these findings partly revealed the molecular mechanism by which STP inhibits ADP-induced platelet aggregation.

Evapotranspiration and Removal Performance in the Treatment of High Salinity LandfilI-Leachate Using HSF

In this study, the water budget in the treatment of high salinity landfill-leachate was estimated and the influence of evapotranspiration （ET） on treatment performance was investigated. The salinity of the inside of horizontal subsurface flow constructed wetland （HSF） of the raw leachate inflow was 15.0± 3.4 g.Cl/L which was in the level of the salinity of the survival limit of reed, and that of the double diluted leachate inflow was 9.3 ± 1.9 g.CI7L. There were large differences in the vegetation between HSF of the raw leachate inflow and that of the double diluted leachate inflow. The dense vegetation bed of double diluted leachate inflow during the growing season （April-October） provided a high ET and a large water loss, which made great contributions to the reduction of the outflow load of COD and T-N. The HSF with die-back reeds in the non-growing season （November-March） provided a slight ET and a small water loss and made less of a contribution to pollutant removal compared to the HSF with dense vegetation bed during the growing season. However, the HSF with die-back reeds during the non-growing season exhibited higher removal performance than the unplanted HSF.

Pre-harvest Treatment of Zn ＆ B Affects the Fruit Quality and Storability of Sweet Orange

Physico-chemical composition of sweet orange （Citrus sinensis L.） cv. blood red was determined in relation to different storage conditions and micronutrients application at department of horticulture, Agricultural University Peshawar, Pakistan during 2006-2007 and 2007-2008. The post-harvest quality of sweet orange was evaluated for 60 days storage with 20 days intervals. Fruit were harvested after the foliar application of zinc and boron in two consecutive seasons. The harvested fruits were stored at an ambient temperature （ATS） of 25 ＋ 2 ℃ and at low temperature storage （LTS） of 15 ± 2 ℃ with 60%-70% relative humidity （RH） for 60 days. Sweet oranges stored at LTS maintained better fruit quality than ATS. The foliar application of zinc and boron significantly enhanced fruit juice content, total soluble solids （TSS）, ascorbic acid （AA） and non-reducing sugar （NRS） of fruit. However, fruit juice content, TSS and AA were observed significantly higher, when the fruit was treated with high zinc （1%） and low boron （0.02%）. The percent of weight loss, disease incidence, TSS and reducing sugar （RS） increased with increasing the storage durations. A reduction was noted in fruit juice, AA and NRS with increasing the storage durations.

Polycyclic aromatic hydrocarbons in the centralized wastewater treatment plant of a chemical industry zone:Removal,mass balance and source analysis

Increased attention has been given to the fate of pollutants such as polycyclic aromatic hydrocarbons (PAHs) introduced to the wastewater treatment plants.Dissolved and adsorbed PAHs were detected in the centralized wastewater treatment plant of a chemical industry zone in Zhejiang Province,China.The most abundant PAHs were the low molecular weight PAHs (e.g.,Acy,Ace,Flu and Phe),accounting for more than 80% of the total 16 PAHs in each treatment stage.Phase partitioning suggested that the removal of PAHs in every treatment stage was influenced greater by the sorption of particles or microorganisms.The removal efficiencies of individual PAHs ranged between 4% and 87% in the primary sedimentation stage,between 1% and 42% in anaerobic hydrolysis stage,between <1% and 70% in aerobic bio-process stage,between 1.5% and 80% in high-density clarifier stage,and between 44% and 97% in the whole treatment process.Mass balance calculations in primary stage showed significant losses for low molecular weight PAHs and relatively good agreements for high molecular weight PAHs as well as in anaerobic hydrolysis,high-density clarifier stage and sludge stream for most PAHs.Great gains of 60%-150% were obtained for high molecular weight PAHs in aerobic bio-process stage due to biosorption and bioaccumulation.Our investigations found that PAHs entering the wastewater treatment plant (WWTP) could be derived from the dyeing chemical processes as the byproducts,and the contribution supported by the largest dyeing chemical group was up to 48%.