Simultaneous removal of nitrogen and phosphorus from swine wastewater in a sequencing batch biofilm reactor

In this study, the performance of a sequencing batch biofilm reactor(SBBR) for removal of nitrogen and phosphorus from swine wastewater was evaluated. The replacement rate of wastewater was set at 12.5% throughout the experiment. The anaerobic and aerobic times were 3 h and 7 h, respectively, and the dissolved oxygen concentration of the aerobic phase was about 3.95 mg·L-1. The SBBR process demonstrated good performance in treating swine wastewater. The percentage removal of total chemical oxygen demand(COD), ammonia nitrogen(NH4+-N), total nitrogen(TN), and total phosphorus(TP) was 98.2%, 95.7%, 95.6%, and 96.2% at effluent concentrations of COD85.6 mg·L-1, NH4+-N 35.22 mg·L-1, TN 44.64 mg·L-1, and TP 1.13 mg·L-1, respectively. Simultaneous nitrification and denitrification phenomenon was observed. Further improvement in removal efficiency of NH4+-N and TN occurred at COD/TN ratio of 11:1, with effluent concentrations at NH4+-N 18.5 mg·L-1and TN 34 mg·L-1, while no such improvement in COD and TP removal was found. Microbial electron microscopy analysis showed that the filler surface was covered with a thick biofilm, forming an anaerobic–aerobic microenvironment and facilitating the removal of nitrogen, phosphorus and organic matters. A long-term experiment(15 weeks) showed that stable removal efficiency for N and P could be achieved in the SBBR system.

Nitrogen and Phosphorus Removal from Lake Kinneret Inputs

The Hula Valley was drained in 1957. The land use was modified from natural wetland and old shallow lake ecosystems to agricultural development. About half of the drained land area was utilized for aquaculture. Population size was enhanced and the diary was developed intensively resulting in the enhancement of domestic and husbandry sewage production that increased as well. The natural intact Hula Valley-Lake Kinneret ecosystem was heavily anthropogenically interrupted: The Hula was drained and Kinneret became a national source for domestic water supply. Some aspects of the environmental and water quality protection policy of the system are presented. The causation and operational management implications for the reduction of Nitrogen and Phosphorus migration from the Hula Valley are discussed. Drastic (81%) restriction of aquaculture accompanied by sewage totally removed achieved a reasonable improvement in pollution control which was also supported by the Hula Project. The implications of anthropogenic intervention in the process of environmental management design are presented.

Removal of nitrogen and phosphorus in a combined A^2/O-BAF system with a short aerobic SRT

A bench-scale anaerobic/anoxic/aerobic process-biological aerated filter （A^2/O-BAF） combined system was carded out to treat wastewater with lower C/N and C/P ratios. The A^2/O process was operated in a short aerobic sludge retention time （SRT） for organic pollutants and phosphorus removal, and denitrification. The subsequent BAF process was mainly used for nitrification. The BAF effluent was partially returned to anoxic zone of the A^2/O process to provide electron acceptors for denitrification and anoxic P uptake. This unique system formed an environment for reproducing the denitdfying phosphate-accumulating organisms （DPAOs）. The ratio of DPAOs to phosphorus accumulating organisms （PAOs） could be maintained at 28% by optimizing the organic loads in the anaerobic zone and the nitrate loads into the anoxic zone in the A^2/O process. The aerobic phosphorus over-uptake and discharge of excess activated sludge was the main mechanism of phosphorus removal in the combined system. The aerobic SRT of the A^2/O process should meet the demands for the development of aerobic PAOs and the restraint on the nitrifiers growth, and the contact time in the aerobic zone of the A^2/O process should be longer than 30 min, which ensured efficient phosphorus removal in the combined system. The adequate BAF effluent return rates should be controlled with 1--4 mg/L nitrate nitrogen in the anoxic zone effluent of A^2/O process to achieve the optimal nitrogen and phosphorus removal efficiencies.

Simultaneous nitrogen and phosphorus removal under low dissolved oxygen conditions

A full-scale test was operated by using low dissolved oxygen activated sludge process to enhance biological nitrogen and phosphorus removal. When the influent concentrations of CODCr, TN and TP varied in a range of 352.9 mg/L-1338.2 mg/L, 34.4 mg/L-96.3 mg/L, and 2.21 mg/L-24.0 mg/L, the average removal efficiencies were 94.9%, 86.7% and 93.0%, respectively. During the test period of two months, effluent meas of CODCr,, BOD5, NH3-N, TN and TP were below 50 mg/L, 25 mg/L, 10 mg/L and 1.0 mg/L respectively. The low dissolved oxygen activated sludge process has a simple flow sheet, fewer facilities and high N and P removal efficiency. It is very convenient to retrofit the conventional activated sludge process with the above process.

Simultaneous removal of ethanol, acetaldehyde and nitrogen oxides over V-Pd/γ-Al_2O_3-TiO_2 catalyst

V-Pd/γ-Al2O3-TiO2 catalysts with different vanadium contents were prepared by a combined sol-gel and impregnation method. X-ray diffraction （XRD）, N2 adsorption-desorption （BET）, X-ray photoelectron spectroscopy （XPS） and catalytic removal of ethanol, acetaldehyde and nitrogen oxides at low temperature （〈300 ？C） were used to assess the properties of the catalysts. The results showed that the sample with 1wt% vanadium exhibited an excellent catalytic performance for simultaneous removal of ethanol, acetaldehyde and nitrogen oxides. The conversions of ethanol, acetaldehyde and nitrogen oxides at 250 ？C were 100%, 74.4% and 98.7%, respectively. V-Pd/γ-Al2O3-TiO2 catalyst with 1 wt% vanadium showed the largest surface area and higher dispersion of vanadium oxide on the catalyst surface, and possessed a larger mole fraction of V4＋ species and unique PdO species on the surface, which can be attributed to the strong synergistic effect among palladium, vanadium and the carriers. The higher activity of V-Pd/γ-Al2O3-TiO2 catalyst is related to the V4＋ and Pd2＋ species on the surface, which might be favorable for the formation of active sites.

Mechanism of Simultaneous Nitrogen Removal and Electricity Generation by Microbial Fuel Cell

The working mechanism of MFC used for simultaneous nitrogen removal and electricity generation was studied.The results show that the electrode biofilms and suspension had different modes of electron transfer.The microorganisms growing on the electrodes and bioflocs could transfer electrons by direct contact and intermediaries respectively.The electrode biofilms and bioflocs were dominant in different functional spaces,and played a synergistic role in the process of contaminant removal,but showed a certain competitive relationship in the process of electricity generation.This study can provide a theoretical basis for the development of a new low-consumption wastewater treatment technology and promote technological innovation in wastewater treatment.

Research Development and Application of Nitrogen and Phosphorus Removal in Sequencing Batch Biofilm Reactor

Frequent variations of the wastewater quality and quantity and other uncertain factors are the challenges faced by many wastewater treatment plants during the operation. Sequencing batch biofilm reactor（ SBBR） process provides a new idea for an effective solution to this problem. This paper introduces the basic processes and characteristics of the sequencing batch biofilm reactor（ SBBR） process,and summarizes the research status of this process in wastewater treatment. Factors affecting the nitrogen and phosphorus removal effect of the SBBR process are also analyzed.

Discussion on nitrogen and phosphorus removal process characteristics of improved oxidation ditch

In order to enhance efficiency of the nitrogen and phosphorus removal of sewage treatment plant, Taking Wu Long kou sewage treatment plant project in Zhengzhou as an example, this article introduces the structure, the working principle, the craft character, as well as the problems existed in the practical application of the improved oxidation ditch, and raises some corresponding processing countermeasures. Looked from the running situation of Wu Long kou sewage treatment plant, the improved oxidation ditch have certain advantages in city sewage treatment, such as high organic removing efficiency, good removing effect of nitrogen and phosphorus, low investing expenses and operating cost and so on. It is a craft that is worth promoting in urban sewage treatment.

Analysis of the Effect and Influencing Factors of Rural Domestic Sewage Treatment Based on A^(2)O-MBBR Integrated Process

[Objectives] This study was conducted to solve the prominent problems in the treatment of domestic sewage in southern rural areas of China. [Methods] An integrated process treatment mode of anaerobic/anoxic/aerobic moving bed biofilm reactor (A 2O-MBBR) was proposed to analyze and study its operating effect and influencing factors. [Results] The A^(2)O-MBBR mode had good COD removal efficiency and nitrogen and phosphorus removal performance, and the water quality index of the effluent met the Class A standard of GB181918-2002. This mode is suitable for treating rural domestic sewage, and has high treatment effects in different operating periods. In spring, the average removal rates of COD, NH_(4)^(+)-N, TN, TP and SS reached (83.53 ± 2.15)%, (89.44 ± 4.97)%, (67.36±18.53)%, (88.22±11.21)% and (91.73±2.25)%, respectively;In the autumn period, the average removal rates of COD, NH_(4)^(+)-N, TN, TP and SS were (83.49±2.64)%, (89.26±9.19)%, (66.05±17.00)%, (87.48±9.68)%, and (91.13±2.35)%. [Conclusions] This study provides theoretical reference and technical support for the popularization and application of A^(2)O-MBBR integrated process.

Nitrogen and phosphorus removal in pilot-scale anaerobic-anoxic oxidation ditch system

To achieve high efficiency of nitrogen and phosphorus removal and to investigate the rule of simultaneous nitrification and denitrification phosphorus removal （SNDPR）, a whole course of SNDPR damage and recovery was studied in a pilot-scale, anaerobicanoxic oxidation ditch （OD）, where the volumes of anaerobic zone, anoxic zone, and ditches zone of the OD system were 7, 21, and 280 L, respectively. The reactor was fed with municipal wastewater with a flow rate of 336 L/d. The concept of simultaneous nitrification and denitrification （SND） rate （rSND） was put forward to quantify SND. The results indicate that： （1） high nitrogen and phosphorus removal efficiencies were achieved during the stable SND phase, total nitrogen （TN） and total phosphate （TP） removal rates were 80% and 85%, respectively; （2） when the system was aerated excessively, the stability of SND was damaged, and rSND dropped from 80% to 20% or less; （3） the natural logarithm of the ratio of NOx to NH4^＋ in the effluent had a linear correlation to oxidation-reduction potential （ORP）; （4） when NO3^- was less than 6 mg/L, high phosphorus removal efficiency could be achieved; （5） denitrifying phosphorus removal （DNPR） could take place in the anaerobic-anoxic OD system. The major innovation was that the SND rate was devised and quantified.

Simultaneous nitrification and denitrification in step feeding biological nitrogen removal process

The simultaneous nitrification and denitrification in step-feeding biological nitrogen removal process were investigated under different influent substrate concentrations and aeration flow rates. Biological occurrence of simultaneous nitrification and denitrification was verified in the aspect of nitrogen mass balance and alkalinity. The experimental results also showed that there was a distinct linear relationship between simultaneous nitrification and denitrification and DO concentration under the conditions of low and high aeration flow rate. In each experimental run the floc sizes of activated sludge were also measured and the results showed that simultaneous nitrification and denitrification could occur with very small size of floc.

Nitrogen Removal by Simultaneous Nitrification and Denitrification via Nitrite in a Sequence Hybrid Biological Reactor

Sequence hybrid biological reactor （SHBR） was proposed, and some key control parameters were investigated for nitrogen removal from wastewater by simultaneous nitrification and denitrification （SND） via nitrite. SND via nitrite was achieved in SHBR by controlling demand oxygen （DO） concentration. There was a programmed decrease of the DO from 2.50 mg·L^-1 to 0.30 mg·L^-1, and the average nitrite accumulation rate （NAR） was increased from 16.5% to 95.5% in 3 weeks. Subsequently, further increase in DO concentration to 1.50 mg·L^-1 did not destroy the partial nitrification to nitrite. The results showed that limited air flow rate to cause oxygen deficiency in the reactor would eventually induce only nitrification to nitrite and not further to nitrate. Nitrogen removal efficiency was increased with the increase in NAR, that is, NAR was increased from 60% to 90%, and total nitrogen removal efficiency was increased from 68% to 85%. The SHBR could tolerate high organic loading rate （OLR）, COD and ammonia-nitrogen removal efficiency were greater than 92% and 93.5%, respectively,, and it even operated under low DO concentration （0.5 mg·L^-1） and maintained high OLR （4.0 kg COD·m^-3·d^-1）. The presence of biofilm positively affected the activated sludge settling capability, and sludge volume index （SVI） of activated sludge in SHBR never hit more than 90 ml·L^-1 throughout the experiments.

Nitrogen and phosphorus removal under intermittent aeration conditions

A practice wastewater treatment plant was operated using intermittent aeration activated sludge process to enhance biological nitrogen and phosphorus removal. When the influent concentrations of COD Cr , BOD 5, TN, TP, NH 3\|N, TKN, and SS varied in a range of 207.5—1640 mg/L, 61.8—637 mg/L, 28.5—75.6 mg/L, 4.38—20.2 mg/L, 13.6—31.9 mg/L, 28.5—75.6 mg/L, and 111—1208 mg/L, the effluent means were less than 50 mg/L, 20 mg/L, 5 mg/L, 1.0 mg/L, 5 mg/L, 10 mg/L, and 20 mg/L, respectively. Based on a long time of operating results, this process is very suitable for nutrient biological removal for treating the municipal wastewater those water characteristics are similar as that of the Songjiang Municipal Waste Water Treatment Plant(SJMWTP).

Phosphorus and Nitrogen Removal by Saturated Vertical-Flow Constructed Wetlands (SVCWs) Type Micro-Pilot Using Shale from Ivory Coast as a Substrate

This study evaluates the performance of shale from Ivory Coast used as substrate in vertical-flow constructed wetlands in removal of phosphates and nitrogen. The pilot-scale artificial wetland has been duplicated: filter planted with Panicum maximun and unplanted. They were set up outdoors, and fed with a municipal wastewater. The wetlands have been fed with three batches per week (intermittent) over a period of 3 months. During the operation period, the hydraulic residence time (HRT) 52 h was used, while wastewater temperatures varied from about ~33°C. The removal performance of the constructed wetland units was very good, since it reached on an average 98%, 89.4%, 89.4%, 84%, 80%, 84.8% and 92% for TSS, DOC, BOD5, , TKN, TP and respectively. In addition, the vegetation did not demonstrate superior performance to unplanted controls. Therefore, this study focuses on the role of shale in the phosphorus and nitrogen removal from wastewater by constructed wetland.

Simultaneous nitrification and autotrophic denitrification in fluidized bed reactors using pyrite and elemental sulfur as electron donors

In this study, simultaneous nitrification and autotrophic denitrification (SNAD) with either elemental sulfur or pyrite were investigated in fluidized bed reactors in mesophilic conditions. The reactor performance was evaluated at different ammonium (12-40 mg/L of NH4+-N), nitrate (35-45 mg/L of NO3--N), and dissolved oxygen (DO) (0.1-1.5 mg/L) concentrations, with a hydraulic retention time of 12 h. The pyrite reactor supported the SNAD process with a maximum nitrogen removal efficiency of 139.5 mg/(L·d) when the DO concentration was in the range of 0.8-1.5 mg/L. This range, however, limited the denitrification efficiency of the reactor, which decreased from 90.0% ± 5.3% in phases II-V to 67.9% ± 7.2% in phases VI and VII. Sulfate precipitated as iron sulfate (FeSO4/Fe2(SO4)3) and sodium sulfate (Na2SO4) minerals during the experiment. The sulfur reactor did not respond well to nitrification with a low and unstable ammonium removal efficiency, while denitrification occurred with a nitrate removal efficiency of 97.8%. In the pyrite system, the nitrifying bacterium Nitrosomonas sp. was present, and its relative abundance increased from 0.1% to 1.1%, while the autotrophic denitrifying genera Terrimonas, Ferruginibacter, and Denitratimonas dominated the community. Thiobacillus, Sulfurovum, and Trichlorobacter were the most abundant genera in the sulfur reactor during the entire experiment.

Novel strategy of nitrogen removal from domestic wastewater using pilot Orbal oxidation ditch

A pilot-scale Orbed oxidation ditch was operated for 17 months to optimize nitrogen removal from domestic wastewater of average COD to total nitrogen ratio of 2.7, with particular concern about the roles of dissolved oxygen （DO）, mixed liquor suspended solids （MLSS） and return activated sludge （RAS） recycle ratio. Remarkable simultaneous nitrification and denitrification （SND） was observed and mean total nitrogen （TN） removal efficiency up to 72.1% was steadily achieved, at DO concentration in the out, middle and inner channel of 0.1, 0.4 and 0.7 mg/L, respectively, with an average M LSS of 5.5 g/L and RAS recycle ratio of 150%. Although the out channel took the major role in TN removal, the role of middle channel should never be ignored. The denitrification potential could be fully developed under low DO, high MLSS with adequate RAS ratio. The sludge settleability was amazingly improved under low DO operation mode, and some explanations were tried. In addition, a scries of simplified batch tests were done to determine whether novel microorganisms could make substantial contribution to the performance of nitrogen removal. The results indicated that the SND observed in this Orbal oxidation ditch was more likely a physical phenomenon.

Effects of low temperature on sludge settleability and nutrients removal performance treating domestic wastewater

In order to investigate the effect of temperature on activated sludge systems,sludge settleability,nitrogen and phosphorus removal processes were investigated by changing temperature variation patterns using 4 sequencing batch reactors (SBR).The results showed that no matter temperature changes in the range of 15-22 ℃ (decrease or increase) gradually or sharply,it has little effect on nitrogen and phosphorus removal processes.But when temperature decreases to 12 ℃,biochemical reactions will be inhibitted obviously.At least 1 sludge retention time (SRT) is needed for nitrification adapt to new temperature envirionment,and more time is necessary for phosphorus removal process.When temperature increases from 12 ℃ to 22 ℃ sharply,nitrification process deteriorates seriously,but phosphorus removal process shows no change.In addition,sludge settleability deteriorates when temperature changes sharply (decrease or increase),but the reasons are different.Under temperature decrease condition,it is mainly caused by the increase of accumulated extracellular polymeric substances (EPS).Under temperature increase condition,the loosing sludge flocs' configuration is the main reason.It should be pointed out that the filamentous bacteria content during the entire experiment keeps almost constant,and the sludge settleability variations are the reflection of the change of sludge physicochemical characteristics.

Study on Purification Efficiency of Vertical Flow Wetlands on Domestic Wastewater

The combination method of intermittent influent and vertical flow wetlands （VFW） was used in the test to treat the domestic wastewater. Four artificial wetlands including Typha latifolia wetland,Phragmites australis （P.H.） wetland,polyculture wetlands （Typha latifolia and Phragmites australis） and non-vegetation wetland were established in the test. The effects of hydraulic retention time （HRT） and plant species on pollutants removal efficiencies were studied. The results showed that when HRT=7,the treatment efficiencies of wetlands with plants for the removal of TN and NH＋4-N were up to 99.65% and 99.58%,respectively. For the control wetland,TN removal efficiency was up to 87.9% when HRT were 6 days,and NH＋4-N removal efficiency was up to 91.8% when HRT were 5 days. TP removal efficiencies of four wetlands were higher than 93% when HRT was 6 days. Through the studies on different plants,it was found that vegetation wetlands had better nitrogen removal efficiency than non-vegetation wetland. The treatment efficacy of Phragmites australis wetland and polyculture wetland was better than Typha latifolia wetland.

Effect of substrate COD/N ratio on performance and microbial community structure of a membrane aerated biofilm reactor

Two parallel carbon-membrane aerated biofilm reactors were operated at well-defined conditions to investigate the effect of substrate COD/N ratios on the performance and microbial community structure of the bioreactor. Results showed that at substrate COD/N of 5, organic and nitrogen could be eliminated simultaneously, and COD removal degree, nitrification and denitrification efficiency reached 85%, 93% and 92%, respectively. With increasing substrate COD/N ratios, the specific oxygen utilization rates of nitrifying bacteria in biofilm were found to decrease, indicating that nitrifying population became less dominant. At substrate COD/N ratio of 6, excessive heterotrophs inhibited the activity of nitrifying bacteria greatly and thus led to poor nitrification process. With the help of fluorescence in situ hybridization （FISH）, Nitrosomonas and Nitrosospira were identified as dominant ammonia-oxidizing bacteria in the biofilm at substrate COD/N of 0, whereas only Nitrosospira were detected in the biofilm at COD/N ratio of 5. Nitrospira were present as dominant nitrite-oxidizing bacteria in our study. Confocal laser scanning microscopy images revealed that at substrate COD/N ratio of 0 nitrifying bacteria existed throughout the biofilm and that at COD/N ratio of 5 they were mainly distributed in the inner layer of biofilm.

Response of aerobic sludge to AHL-mediated QS:Granulation,simultaneous nitrogen and phosphorus removal performance

The effects of different species and concentrations’signal molecules on aerobic activated sludge system were investigated through batch experiments.Results showed that the fastest NH^(+)_(4)-N oxidization rate and the most extracellular polymeric substances(EPS)secretion were obtained by adding 5 nmol/L N-hexanoyl-l-homoserine lactone(C_(6)-HSL)into the aerobic activated sludge.Further study investigated the correlation among N-acyl-homoserine lactones-mediated quorum sensing(AHLs-mediated QS),nutrient removal performances and microbial communities with the long-term addition of 5 nmol/L C_(6)-HSL.It was found that C_(6)-HSL-manipulation could enhance the stability and optimize the decontamination performance of aerobic granular sludge(AGS)system.Microbial compositions considerably shifted with long-term C_(6)-HSL-manipulation.Exogenous C_(6)-HSL-manipulation inhibited quorum quenching-related(QQ-related)activities and enhanced QS-related activities during the stable period.The proposed C_(6)-HSL-manipulation might be a potential technology to inhibit the growth of harmful bacteria in AGS,which could provide a theoretical foundation for the realization of more stable biological wastewater treatments.