Based on theoretical analysis about local strain,strain rate and dissolving rate at crack tip, the corrosion fatigue crack growth rate of steels ZG20SiMn and SM50B-Zc in fresh water and 3.5% NaCl solution were measure...Based on theoretical analysis about local strain,strain rate and dissolving rate at crack tip, the corrosion fatigue crack growth rate of steels ZG20SiMn and SM50B-Zc in fresh water and 3.5% NaCl solution were measured experimentally,and the PH and electrode potential within crack were also measured continuously along with crack propagating.It showed that the increase of crack growth rate,caused by both decreasing frequency and raising stress ratio,was mainly accelerated by hydrogen embrittlement.展开更多
The microstructure evolution and age-hardening response for different Sm/Sn ratios(0-2.55,in wt.%)of Mg-Sn-Sm alloys were investigated.The second phase formation in as-cast alloys and the Mg_(3)Sm precipitates formed ...The microstructure evolution and age-hardening response for different Sm/Sn ratios(0-2.55,in wt.%)of Mg-Sn-Sm alloys were investigated.The second phase formation in as-cast alloys and the Mg_(3)Sm precipitates formed in aged alloys were characterized using XRD,FESEM and HAADF-STEM with EDS techniques.Results indicate that the Sm/Sn ratio has a great influence on the phase constitution,α-Mg grain size and age-hardening response.With the increment of Sm/Sn ratio,Mg_(41)Sm_(5) and thermally stable MgSnSm phases precipitate.When the Sm/Sn ratio is about 1.19,the secondary dendrite arm spacing ofα-Mg grains significantly decreases.Furthermore,the alloy with Sm/Sn ratio up to 2.55 exhibits the highest age-hardening response,the hardness value increases from 52 HB at solution-treated condition to 74 HB at peak-aged condition(ageing at 220 ℃ for a short time of 4 h).This is attributed to the large volume fraction of needle-like Mg_(3)Sm precipitates formed in theα-Mg matrix during ageing treatment,which results in a significant precipitation strengthening effect.展开更多
The experiment was conducted at Veterinary Research Station of Faculty of Veterinary Medicine,Royal University of Agriculture.The experimental period lasted 60 days,starting from October 1st to November 30th 2022.CRD(...The experiment was conducted at Veterinary Research Station of Faculty of Veterinary Medicine,Royal University of Agriculture.The experimental period lasted 60 days,starting from October 1st to November 30th 2022.CRD(Completely Randomized Design)was used with 2 treatments/groups,vaccination group and non-vaccination group“control”,and 6 replications.The vaccination groups received two times of vaccination by dropping into the ocular at 7 days and 21 days.Meanwhile,blood samples were collected 3 times to detect the antibody level of ND(Newcastle Disease)and contained 21 days old,35 days old and 49 days old chicks.The ELISA(Enzyme-Linked Immunosorbent Assay)was performed to detect the antibody of those 2 groups.The result of finding showed that the S/P(Sample to Positive)ratio of control at 21 days,was very low,even in 3rd quartile,which was below the threshold.However,the vaccination group was relatively high,even in 1st quartile,which was higher than the threshold.At 35 days,S/P ratio of control group was still very low,but a bit higher than at 21 days.Meanwhile,the vaccination group was still high,even in 1st quartile,and two-time higher than at 21 days,but an increasing number of samples developed less antibody than threshold,accounting for 12.22%.At 49 days,the control group was still very low,even in 3rd quartile,but a bit higher than at 21 days and 35 days,and was close to the threshold.The vaccination group was still relatively high,even in 1st quartile but lower than three times comparing to 35 days.However,in this age,the number of chickens that developed antibody seemed to be increased in the control group,vice versa for vaccination group.The average S/P ratio was different significant(p<0.001),where vaccination had higher S/P ratio than control.It was similar finding for log-titer,the vaccination had higher figure(p<0.001).The risk of infection of ND was higher in control group,but it will reduce by increasing the age of chicken,while vaccination group was decreased by increasing age,especially at 49 days and we need to consider another vaccination to get full protection.展开更多
A number of epuilibrium data of single stage in the system (Nd-SM)Cl_3-HCl-H_2O-1mol/L HEHEHP-kerosence was determined On the basis of epuilibrium data, two mathematical describing extract epui-librium of Nd and Sm...A number of epuilibrium data of single stage in the system (Nd-SM)Cl_3-HCl-H_2O-1mol/L HEHEHP-kerosence was determined On the basis of epuilibrium data, two mathematical describing extract epui-librium of Nd and Sm were developed.The models cover wide available ranges (the total RE concentration inepuilibrated apueous phase is 0. 07～0. 77 mol/L and the acidity is 0. 11～0. 48 mol/L; the mole fraction ofMd or Sm is 0. 020～0. 998) with small average relative errors(The model of Nd is 6. 11 % and the model ofSm is 3. 07 %, respectively ) With the developed models, the extract behaviors of Nd and sM, such as thedistribution of rare earth concentrations in both phase, the effects of acidity, RE concentration, mole fractionof RE in aqueous phase on the RE concentration in organic phase, were researched The separation circuits be-tween Nd and Sm simulated and performed by the experiments in laboratory. The purities obtained prod-uct of Nd_2O_3O_3 as well as Sm_2O_3 were higher than 99%.Two calculation programs were written in BASIC language. One of them is used for publishing epuilibri-um model and another is used for simulation of fractional solvent extraction. The amulation results obtainedmay serve as a reference for designing solvent extraction process.展开更多
文摘Based on theoretical analysis about local strain,strain rate and dissolving rate at crack tip, the corrosion fatigue crack growth rate of steels ZG20SiMn and SM50B-Zc in fresh water and 3.5% NaCl solution were measured experimentally,and the PH and electrode potential within crack were also measured continuously along with crack propagating.It showed that the increase of crack growth rate,caused by both decreasing frequency and raising stress ratio,was mainly accelerated by hydrogen embrittlement.
基金the Natural Science Foundation of Inner Mongolia under Grant No.2020MS05014the Science and Technology Planning of Inner Mongolia under Grant No.2020GG0318.
文摘The microstructure evolution and age-hardening response for different Sm/Sn ratios(0-2.55,in wt.%)of Mg-Sn-Sm alloys were investigated.The second phase formation in as-cast alloys and the Mg_(3)Sm precipitates formed in aged alloys were characterized using XRD,FESEM and HAADF-STEM with EDS techniques.Results indicate that the Sm/Sn ratio has a great influence on the phase constitution,α-Mg grain size and age-hardening response.With the increment of Sm/Sn ratio,Mg_(41)Sm_(5) and thermally stable MgSnSm phases precipitate.When the Sm/Sn ratio is about 1.19,the secondary dendrite arm spacing ofα-Mg grains significantly decreases.Furthermore,the alloy with Sm/Sn ratio up to 2.55 exhibits the highest age-hardening response,the hardness value increases from 52 HB at solution-treated condition to 74 HB at peak-aged condition(ageing at 220 ℃ for a short time of 4 h).This is attributed to the large volume fraction of needle-like Mg_(3)Sm precipitates formed in theα-Mg matrix during ageing treatment,which results in a significant precipitation strengthening effect.
文摘The experiment was conducted at Veterinary Research Station of Faculty of Veterinary Medicine,Royal University of Agriculture.The experimental period lasted 60 days,starting from October 1st to November 30th 2022.CRD(Completely Randomized Design)was used with 2 treatments/groups,vaccination group and non-vaccination group“control”,and 6 replications.The vaccination groups received two times of vaccination by dropping into the ocular at 7 days and 21 days.Meanwhile,blood samples were collected 3 times to detect the antibody level of ND(Newcastle Disease)and contained 21 days old,35 days old and 49 days old chicks.The ELISA(Enzyme-Linked Immunosorbent Assay)was performed to detect the antibody of those 2 groups.The result of finding showed that the S/P(Sample to Positive)ratio of control at 21 days,was very low,even in 3rd quartile,which was below the threshold.However,the vaccination group was relatively high,even in 1st quartile,which was higher than the threshold.At 35 days,S/P ratio of control group was still very low,but a bit higher than at 21 days.Meanwhile,the vaccination group was still high,even in 1st quartile,and two-time higher than at 21 days,but an increasing number of samples developed less antibody than threshold,accounting for 12.22%.At 49 days,the control group was still very low,even in 3rd quartile,but a bit higher than at 21 days and 35 days,and was close to the threshold.The vaccination group was still relatively high,even in 1st quartile but lower than three times comparing to 35 days.However,in this age,the number of chickens that developed antibody seemed to be increased in the control group,vice versa for vaccination group.The average S/P ratio was different significant(p<0.001),where vaccination had higher S/P ratio than control.It was similar finding for log-titer,the vaccination had higher figure(p<0.001).The risk of infection of ND was higher in control group,but it will reduce by increasing the age of chicken,while vaccination group was decreased by increasing age,especially at 49 days and we need to consider another vaccination to get full protection.
文摘A number of epuilibrium data of single stage in the system (Nd-SM)Cl_3-HCl-H_2O-1mol/L HEHEHP-kerosence was determined On the basis of epuilibrium data, two mathematical describing extract epui-librium of Nd and Sm were developed.The models cover wide available ranges (the total RE concentration inepuilibrated apueous phase is 0. 07～0. 77 mol/L and the acidity is 0. 11～0. 48 mol/L; the mole fraction ofMd or Sm is 0. 020～0. 998) with small average relative errors(The model of Nd is 6. 11 % and the model ofSm is 3. 07 %, respectively ) With the developed models, the extract behaviors of Nd and sM, such as thedistribution of rare earth concentrations in both phase, the effects of acidity, RE concentration, mole fractionof RE in aqueous phase on the RE concentration in organic phase, were researched The separation circuits be-tween Nd and Sm simulated and performed by the experiments in laboratory. The purities obtained prod-uct of Nd_2O_3O_3 as well as Sm_2O_3 were higher than 99%.Two calculation programs were written in BASIC language. One of them is used for publishing epuilibri-um model and another is used for simulation of fractional solvent extraction. The amulation results obtainedmay serve as a reference for designing solvent extraction process.
