Synergistic effect of total ionizing dose on single-event gate rupture in SiC power MOSFETs

The synergistic effect of total ionizing dose(TID) and single event gate rupture(SEGR) in SiC power metal–oxide–semiconductor field effect transistors(MOSFETs) is investigated via simulation. The device is found to be more sensitive to SEGR with TID increasing, especially at higher temperature. The microscopic mechanism is revealed to be the increased trapped charges induced by TID and subsequent enhancement of electric field intensity inside the oxide layer.

Total Ionizing Dose Radiation Effects on MOS Transistors with Different Layouts

Both nMOS and pMOS transistors with two-edged and multi-finger layouts are fabricated in a standard commercial 0.6μm CMOS/bulk process to study their total ionizing dose （TID） radiation effects. The leakage current, threshold voltage shift, and transconductance of the devices are monitored before and after T-ray irradiation. Different device bias conditions are used during irradiation. The experiment results show that TID radiation effects on nMOS devices are very sensitive to their layout structures. The impact of the layout on TID effects on pMOS devices is slight and can be neglected.

Machine learning-based analyses for total ionizing dose effects in bipolar junction transistors

Machine learning methods have proven to be powerful in various research fields.In this paper,we show that research on radiation effects could benefit from such methods and present a machine learning-based scientific discovery approach.The total ionizing dose(TID)effects usually cause gain degradation of bipolar junction transistors(BJTs),leading to functional failures of bipolar integrated circuits.Currently,many experiments of TID effects on BJTs have been conducted at different laboratories worldwide,producing a large amount of experimental data which provides a wealth of information.However,it is difficult to utilize these data effectively.In this study,we proposed a new artificial neural network(ANN)approach to analyze the experimental data of TID effects on BJTs An ANN model was built and trained using data collected from different experiments.The results indicate that the proposed ANN model has advantages in capturing nonlinear correlations and predicting the data.The trained ANN model suggests that the TID hardness of a BJT tends to increase with base current I.A possible cause for this finding was analyzed and confirmed through irradiation experiments.

Synergistic effect of total ionizing dose on single event effect induced by pulsed laser microbeam on SiGe heterojunction bipolar transistor

The synergistic effect of total ionizing dose（TID） on single event effect（SEE） in SiGe heterojunction bipolar transistor（HBT） is investigated in a series of experiments. The SiGe HBTs after being exposed to 60 Co g irradiation are struck by pulsed laser to simulate SEE. The SEE transient currents and collected charges of the un-irradiated device are compared with those of the devices which are irradiated at high and low dose rate with various biases. The results show that the SEE damage to un-irradiated device is more serious than that to irradiated SiGe HBT at a low applied voltage of laser test. In addition, the g irradiations at forward and all-grounded bias have an obvious influence on SEE in the SiGe HBT, but the synergistic effect after cutting off the g irradiation is not significant. The influence of positive oxide-trap charges induced by TID on the distortion of electric field in SEE is the major factor of the synergistic effect. Moreover, the recombination of interface traps also plays a role in charge collection.

Synergistic effects of total ionizing dose and radiated electromagnetic interference on analog-to-digital converter

The influence of combined total ionization dose(TID)and radiated electromagnetic interference(EMI)in a commercial analog-to-digital converter(ADC)was studied.The degradation of the direct-current response,the static parameters,and the dynamic parameters caused by the TID and EMI separately and synergistically is presented.The experimental results demonstrate that the increase in TID intensifies data error and the signal-tonoise ratio(SNR)degradation caused by radiated EMI.The cumulative distribution function of EMI failure with respect to data error and SNR with different TIDs was extracted.The decreasing trend of the threshold was acquired with a small sample size of five for each TID group.The result indicates that the ADC is more sensitive in a compound radiation environment.

Suppressing the hot carrier injection degradation rate in total ionizing dose effect hardened nMOSFETs

Annular gate nMOSFETs are frequently used in spaceborne integrated circuits due to their intrinsic good capability of resisting total ionizing dose （TID） effect. However, their capability of resisting the hot carrier effect （HCE） has also been proven to be very weak. In this paper, the reason why the annular gate nMOSFETs have good TID but bad HCE resistance is discussed in detail, and an improved design to locate the source contacts only along one side of the annular gate is used to weaken the HCE degradation. The good TID and HCE hardened capability of the design are verified by the experiments for I/O and core nMOSFETs in a 0.18 μm bulk CMOS technology. In addition, the shortcoming of this design is also discussed and the TID and the HCE characteristics of the replacers （the annular source nMOSFETs） are also studied to provide a possible alternative for the designers.

Influence of characteristics' measurement sequence on total ionizing dose effect in PDSOI nMOSFET

The influence of characteristics’ measurement sequence on total ionizing dose effect in partially-depleted SOI nMOSFET is comprehensively studied. We find that measuring the front-gate curves has no influence on total ionizing dose effect.However, the back-gate curves’ measurement has a great influence on total ionizing dose effect due to high electric field in the buried oxide during measuring. In this paper, we analyze their mechanisms and we find that there are three kinds of electrons tunneling mechanisms at the bottom corner of the shallow trench isolation and in the buried oxide during the backgate curves’ measurement, which are: Fowler–Nordheim tunneling, trap-assisted tunneling, and charge-assisted tunneling.The tunneling electrons neutralize the radiation-induced positive trapped charges, which weakens the total ionizing dose effect. As the total ionizing dose level increases, the charge-assisted tunneling is enhanced by the radiation-induced positive trapped charges. Hence, the influence of the back-gate curves’ measurement is enhanced as the total ionizing dose level increases. Different irradiation biases are compared with each other. An appropriate measurement sequence and voltage bias are proposed to eliminate the influence of measurement.

Influences of total ionizing dose on single event effect sensitivity in floating gate cells

The influences of total ionizing dose （TID） on the single event effect （SEE） sensitivity of 34-nm and 25-nm NAND flash memories are investigated in this paper. The increase in the cross section of heavy-ion single event upset （SEU） in memories that have ever been exposed to TID is observed, which is attributed to the combination of the threshold voltage shifts induced by 7-rays and heavy ions. Retention errors in floating gate （FG） cells after heavy ion irradiation are observed. Moreover, the cross section of retention error increases if the memory has ever been exposed to TID. This effect is more evident at a low linear energy transfer （LET） value. The underlying mechanism is identified as the combination of the defects induced by 7-rays and heavy ions, which increases the possibility to constitute a multi-trap assisted tunneling （m- TAT） path across the tunnel oxide.

Total ionizing dose effect in an input/output device for flash memory

Input/output devices for flash memory are exposed to gamma ray irradiation. Total ionizing dose has been shown great influence on characteristic degradation of transistors with different sizes. In this paper, we observed a larger increase of off-state leakage in the short channel device than in long one. However, a larger threshold voltage shift is observed for the narrow width device than for the wide one, which is well known as the radiation induced narrow channel effect. The radiation induced charge in the shallow trench isolation oxide influences the electric field of the narrow channel device. Also, the drain bias dependence of the off-state leakage after irradiation is observed, which is called the radiation enhanced drain induced barrier lowing effect. Finally, we found that substrate bias voltage can suppress the off-state leakage, while leading to more obvious hump effect.

Total Ionizing Dose Radiation Effects in the P-Type Polycrystalline Silicon Thin Film Transistors

The total ionizing dose radiation effects in the polycrystalline silicon thin film transistors are studied. Transfer characteristics, high-frequency capacitance-voltage curves and low-frequency noises (LFN) are measured before and after radiation. The experimental results show that threshold voltage and hole-field-effect mobility decrease, while sub-threshold swing and low-frequency noise increase with the increase of the total dose. The contributions of radiation induced interface states and oxide trapped charges to the shift of threshold voltage are also estimated. Furthermore, spatial distributions of oxide trapped charges before and after radiation are extracted based on the LFN measurements.

New Method of Total Ionizing Dose Compact Modeling in Partially Depleted Silicon-on-Insulator MOSFETs

On the basis of a detailed discussion of the development of total ionizing dose （TID） effect model, a new commercial-model-independent TID modeling approach for partially depleted silicon-on-insulator metal-oxide- semiconductor field effect transistors is developed. An exponential approximation is proposed to simplify the trap charge calculation. Irradiation experiments with 60Co gamma rays for IO and core devices are performed to validate the simulation results. An excellent agreement of measurement with the simulation results is observed.

Total ionizing dose induced single transistor latchup in 130-nm PDSOI input/output NMOSFETs

Total ionizing dose induced single transistor latchup effects for 130 nm partially depleted silicon-on-insulator （PDSOI） NMOSFETs with the bodies floating were studied in this work. The latchup phenomenon strongly correlates with the bias configuration during irradiation. It is found that the high body doping concentration can make the devices less sensitive to the single transistor latchup effect, and the onset drain voltage at which latchup occurs can degrade as the total dose level rises. The mechanism of band-to-band tunneling （BBT） has been discussed. Two-dimensional simulations were conducted to evaluate the BBT effect. It is demonstrated that BBT combined with the positive trapped charge in the buried oxide （BOX） contributes a lot to the latchup effect.

Total Ionization Dose Effects on Charge Storage Capability of Al2O3/HfO2/Al2O3-Based Charge Trapping Memory Cell

Because of the discrete charge storage mechanism, charge trapping memory（CTM） technique is a good candidate for aerospace and military missions. The total ionization dose（TID） effects on CTM cells with Al2O3/HfO2/Al2O3（AHA） high-k gate stack structure under in-situ 10 keV x-rays are studied. The C-V characteristics at different radiation doses demonstrate that charge stored in the device continues to be leaked away during the irradiation,thereby inducing the shift of flat band voltage（V（fb））. The dc memory window shows insignificant changes, suggesting the existence of good P/E ability. Furthermore, the physical mechanisms of TID induced radiation damages in AHA-based CTM are analyzed.

Total ionizing radiation-induced read bit-errors in toggle magnetoresistive random-access memory devices

The 1-Mb and 4-Mb commercial toggle magnetoresistive random-access memories（MRAMs） with 0.13 μm and 0.18-μm complementary metal–oxide–semiconductor（CMOS） process respectively and different magnetic tunneling junctions（MTJs） are irradiated with a Cobalt-60 gamma source. The electrical functions of devices during the irradiation and the room temperature annealing behavior are measured. Electrical failures are observed until the dose accumulates to 120-krad（Si） in 4-Mb MRAM while the 1-Mb MRAM keeps normal. Thus, the 0.13-μm process circuit exhibits better radiation tolerance than the 0.18-μm process circuit. However, a small quantity of read bit-errors randomly occurs only in 1-Mb MRAM during the irradiation while their electrical function is normal. It indicates that the store states of MTJ may be influenced by gamma radiation, although the electrical transport and magnetic properties are inherently immune to the radiation. We propose that the magnetic Compton scattering in the interaction of gamma ray with magnetic free layer may be the origin of the read bit-errors. Our results are useful for MRAM toward space application.

Modeling operation amplifier based on VHDL-AMS for TID effect

A model of the operational amplifier based on VHDL-AMS is proposed. According to needs of simulating the total ionizing dose(TID) radiation effect, parameters of operational amplifier are taken into account when the performance is specified. The operational amplifier model used for the TID radiation effect simulation is completed after verifying each modeled parameter. And a parameter for describing the external environment is introduced to make the model combined with TID. Finally, an example is used to illustrate the TID effect on the operational amplifier of MC14573, proving the validity of the model.

集成电路和功率器件抗辐射工艺加固技术研究综述

随着我国空间装备的高速发展,尤其是深空探测器,微电子器件抗辐射性能得到广泛关注。抗辐射工艺加固是实现器件抗辐射性能提升的重要途径之一。本文围绕空间总剂量效应和单粒子效应,对近年来集成电路和功率器件辐射效应机理和工艺加固技术的研究进展进行了介绍和总结,为抗辐射工艺加固技术的发展与应用提供了有益参考。

基于PXI标准的功率器件总剂量效应测试系统研制

设计了一款针对功率器件的总剂量效应测试系统。该系统基于外围组件互连(PXI)扩展主机系统,设计了测试板卡,并通过设计不同工艺的半导体功率器件测试工装,实现功率器件的批量自动化测试。结果表明,氮化镓工艺的功率器件的耐总剂量效应优于硅和碳化硅工艺的功率器件的。

SOI高压LDMOS器件氧化层抗总电离剂量辐射效应研究

绝缘体上硅(SOI)高压横向扩散金属氧化物半导体(LDMOS)器件是高压集成电路的核心器件,对其进行了总电离剂量(TID)辐射效应研究。利用仿真软件研究了器件栅氧化层、场氧化层和埋氧化层辐射陷阱电荷对电场和载流子分布的调制作用,栅氧化层辐射陷阱电荷主要作用于器件沟道区,而场氧化层和埋氧化层辐射陷阱电荷则主要作用于器件漂移区;辐射陷阱电荷在器件内部感生出的镜像电荷改变了器件原有的电场和载流子分布,从而导致器件阈值电压、击穿电压和导通电阻等参数的退化。对80 V SOI高压LDMOS器件进行了总电离剂量辐射实验,结果表明在ON态和OFF态下随着辐射剂量的增加器件性能逐步衰退,当累积辐射剂量为200 krad(Si)时,器件的击穿电压大于80 V,阈值电压漂移为0.3 V,器件抗总电离剂量辐射能力大于200 krad(Si)。

Trench型N-Channel MOSFET低剂量率效应研究

基于抗辐射100V Trench型N-Channel MOSFET开展了不同剂量率的总剂量辐射实验并进行了分析,创新性提出了器件随低剂量率累积以及不同偏置状态下的变化趋势和机理,给出了器件实验前后的转移曲线和直流参数,进行了二维数值仿真比较,证明了实验和仿真的一致性。研究表明:随高剂量率的剂量增加,器件阈值电压(V_(TH))发生了明显负向漂移现象,导通电阻(R_(DSON))出现5%左右的降低,击穿电压(BV_(DS))保持基本不变;低剂量率下总剂量效应与高剂量率有明显不同,阈值电压漂移量减小,同时出现正向漂移现象;此时导通电阻(R_(DSON))和击穿电压(BV_(DS))较高剂量率变化量进一步下降。研究认为,低剂量率下器件界面缺陷电荷增加变多,使得阈值电压的漂移方向发生改变,同时低剂量率实验周期是高剂量率的500倍,退火效应也较高剂量率的明显,导致器件参数辐射前后差异性减小。

H型栅NMOS器件Kink效应的研究

H型栅NMOS器件因其强抗辐照和低功耗等优势已逐渐成为PDSOI电路设计中的核心器件。但H型栅NMOS器件的Ids-Vds曲线会在漏极电压较高时发生明显的翘曲现象,称为Kink效应。该效应严重影响一定工作条件下的电路性能和稳定性。为此,依据实测和TCAD仿真数据,分析了H型栅NMOS器件发生Kink效应的机理,并且基于0.15μm SOI工艺,进一步量化分析了顶层硅膜厚度、阱浓度、栅尺寸、温度以及总剂量辐照等方面对Kink效应的影响。最终结果表明,高漏极电压下NMOS器件体区积累大量空穴导致寄生NPN三极管开启,从而引发了Kink效应。本工作完善了H型栅NMOS器件Kink效应的研究,为PDSOI电路设计中抑制Kink效应提供了有益的参考。