The oily wastewater generated from pretreatment unit of electrocoating industry contains oils, phosphate, organic solvents, and surfactants. In order to improve the removal efficiencies of phosphate and oils, to mitig...The oily wastewater generated from pretreatment unit of electrocoating industry contains oils, phosphate, organic solvents, and surfactants. In order to improve the removal efficiencies of phosphate and oils, to mitigate the membrane fouling, coagulation for ceramic membrane microfiltration of oily wastewater was performed. The results of filtration tests show that the membrane fouling decreased and the permeate flux and quality increased with coagulation as pretreatment. At the coagulant Ca （OH）2 dosage of 900 mg/L, the removal efficiency of phosphate was increased from 46.4% without coagulation to 99.6%; the removal of COD and oils were 97.0% and 99.8%, respectively. And the permeate flux was about 70% greater than that when Ca（OH）2 was not used. The permeate obtained from coagulation and microfiltration can be reused as make-up water, and the recommended operation conditions for pilot and industrial application are transmembrane pressure of 0.10 MPa and cross-flow velocity of 5 m/s. The comparison results show that 0.2 μm ZrO2 microfilter with coagulation could be used to perform the filtration rather than conventional ultrafilter, with very substantial gain in flux and removal efficiency of phosphate.展开更多
Several microorganisms such as bacteria, fungi, Protozoa, Rotifera, cystic amoeba and algae diagnosed in activated sludge aerobic （Rustumiya treatment plant） and anaerobic reactor. Results have shown a reduction in ...Several microorganisms such as bacteria, fungi, Protozoa, Rotifera, cystic amoeba and algae diagnosed in activated sludge aerobic （Rustumiya treatment plant） and anaerobic reactor. Results have shown a reduction in the turbidity rates when using activated sludge at Rustumiya plant of 76.3 to 2.653 NTU in pre-treatment and final tank respectively, also COD （chemical oxygen demand） amount reduced from 427.263 to 82 mg/L respectively, In addition, concentrations of phosphates and nitrates decreased from 12.083 to 8.426 mg/L and 3.59 to 2.43 mg/L respectively, by removing 30.2% and 32.3% respectively of the final tank. The ratio of ammonia removing was 89.6% for ammonia, reducing process from 1358 to 140 mg/L. Furthermore, sulfates concentration decreased from 30.883 to 23.337 mg/L. However, the system in the anaerobic reactor depends on non-aerated activated sludge. Results show turbidity reduced from 12.5 to 2 NTU in pre-treatment and final tank respectively, also the COD mount reduced from 191 to 130 mg/L, the percentage removal of 31.9%. In addition phosphates, nitrates and sulfates concentrations were decreased by using activated sludge from 17.15 to 8.15, 1.2 to 0.1 and 28 to 9.2 mg/L respectively. The ammonia concentration has reduced from 1.2 to 0. i mg/L where at a removal percentage of 90.9%.展开更多
Antimony ore dressing wastewater was treated by using Bacillus sp. and the influences of treatment time, temperature, inoculation size, and pH value on Sb removal effect were explored. The results showed that the best...Antimony ore dressing wastewater was treated by using Bacillus sp. and the influences of treatment time, temperature, inoculation size, and pH value on Sb removal effect were explored. The results showed that the best removal efficiency of Sb in mineral processing wastewater could reach 99.75% in 4 d under the optimum conditions of 30 ℃, microbial inoculated quantity 5%, and pH value at 2.0. After the treatment, the concentration of Sb in wastewater was reduced from 122.21 to 0.30mg/L, which was lower than the local industrial wastewater discharge standard of0.50 mg/L.展开更多
The development of biochar-based granule-like adsorbents suitable for scaled-up application has been attracting increasing attention in the field of water treatment.Herein,a new formable porous granulated biochar load...The development of biochar-based granule-like adsorbents suitable for scaled-up application has been attracting increasing attention in the field of water treatment.Herein,a new formable porous granulated biochar loaded with La-Fe(hydr)oxides/montmorillonite(LaFe/MB)was fabricated via a granulation and pyrolysis process for enhanced phosphorus(P)removal from wastewater.Montmorillonite acted as a binder that increased the size of the granulated biochar,while the use of Fe promoted the surface charge and facilitated the dispersion of La,which was responsible for selective phosphate removal.LaFe/MB exhibited rapid phosphate adsorption kinetics and a high maximum adsorption capacity(Langmuir model,52.12 mg P g^(−1)),which were better than those of many existing granulated materials.The desorption and recyclability experiments showed that LaFe/MB could be regenerated,and maintained 76.7%of its initial phosphate adsorption capacity after four adsorption cycles.The high hydraulic endurance strength retention rate of the developed material(91.6%)suggested high practical applicability in actual wastewater.Electro-static attraction,surface precipitation,and inner-sphere complexation via ligand exchange were found to be involved in selective P removal over a wide pH range of 3-9.The thermodynamic parameters were determined,which revealed the feasibility and spontaneity of adsorption.Based on approximate site energy distribution analyses,high distribution frequency contributed to efficient P removal.The research results provide a new insight that LaFe/MB shows great application prospects for advanced phosphate removal from wastewater.展开更多
The adsorption capacities of Y zeolite and La （III）-modified Y zeolite were studied. A series of La（III）- modified Y zeolites with different La/Y zeolite mass ratios were characterized by X-ray diffi＇action, X-ra...The adsorption capacities of Y zeolite and La （III）-modified Y zeolite were studied. A series of La（III）- modified Y zeolites with different La/Y zeolite mass ratios were characterized by X-ray diffi＇action, X-ray fluores- cence and Brunauer-Emmett-Teller surface area analysis. Batch experiments were conducted to evaluate the effects of various experimental parameters, such as pH, ionic strength, coexisting anions （CO32 , Cl-, SO24- and NO3-） and temperature, on the phosphate adsorption. The capacity of the La （III）-modified Y zeolite to remove phosphate increased as the La/Y zeolite mass ratio increased and after 4 h, a phosphate removal efficiency of 95% was achieved for a La/Y zeolite mass ratio of 0.10. The equilibrium adsorption isotherm data correlated better to the Langmuir model than the Freundlich model and the data followed a pseudo-second-order kinetic equation.展开更多
文摘The oily wastewater generated from pretreatment unit of electrocoating industry contains oils, phosphate, organic solvents, and surfactants. In order to improve the removal efficiencies of phosphate and oils, to mitigate the membrane fouling, coagulation for ceramic membrane microfiltration of oily wastewater was performed. The results of filtration tests show that the membrane fouling decreased and the permeate flux and quality increased with coagulation as pretreatment. At the coagulant Ca （OH）2 dosage of 900 mg/L, the removal efficiency of phosphate was increased from 46.4% without coagulation to 99.6%; the removal of COD and oils were 97.0% and 99.8%, respectively. And the permeate flux was about 70% greater than that when Ca（OH）2 was not used. The permeate obtained from coagulation and microfiltration can be reused as make-up water, and the recommended operation conditions for pilot and industrial application are transmembrane pressure of 0.10 MPa and cross-flow velocity of 5 m/s. The comparison results show that 0.2 μm ZrO2 microfilter with coagulation could be used to perform the filtration rather than conventional ultrafilter, with very substantial gain in flux and removal efficiency of phosphate.
文摘Several microorganisms such as bacteria, fungi, Protozoa, Rotifera, cystic amoeba and algae diagnosed in activated sludge aerobic （Rustumiya treatment plant） and anaerobic reactor. Results have shown a reduction in the turbidity rates when using activated sludge at Rustumiya plant of 76.3 to 2.653 NTU in pre-treatment and final tank respectively, also COD （chemical oxygen demand） amount reduced from 427.263 to 82 mg/L respectively, In addition, concentrations of phosphates and nitrates decreased from 12.083 to 8.426 mg/L and 3.59 to 2.43 mg/L respectively, by removing 30.2% and 32.3% respectively of the final tank. The ratio of ammonia removing was 89.6% for ammonia, reducing process from 1358 to 140 mg/L. Furthermore, sulfates concentration decreased from 30.883 to 23.337 mg/L. However, the system in the anaerobic reactor depends on non-aerated activated sludge. Results show turbidity reduced from 12.5 to 2 NTU in pre-treatment and final tank respectively, also the COD mount reduced from 191 to 130 mg/L, the percentage removal of 31.9%. In addition phosphates, nitrates and sulfates concentrations were decreased by using activated sludge from 17.15 to 8.15, 1.2 to 0.1 and 28 to 9.2 mg/L respectively. The ammonia concentration has reduced from 1.2 to 0. i mg/L where at a removal percentage of 90.9%.
基金Supported by National Water Pollution and Treatment Major Project(2009ZX07212001)Hunan Environment Protection Technology Major Project(2009sk4013)~~
文摘Antimony ore dressing wastewater was treated by using Bacillus sp. and the influences of treatment time, temperature, inoculation size, and pH value on Sb removal effect were explored. The results showed that the best removal efficiency of Sb in mineral processing wastewater could reach 99.75% in 4 d under the optimum conditions of 30 ℃, microbial inoculated quantity 5%, and pH value at 2.0. After the treatment, the concentration of Sb in wastewater was reduced from 122.21 to 0.30mg/L, which was lower than the local industrial wastewater discharge standard of0.50 mg/L.
基金National Key Research and Development Program of China(2021YFD1700805)National Natural Science Foundation of China(41807132,22078136,41877090)the Jiangsu Province Agricultural Independent Innovation Fund(CX(19)2003).
文摘The development of biochar-based granule-like adsorbents suitable for scaled-up application has been attracting increasing attention in the field of water treatment.Herein,a new formable porous granulated biochar loaded with La-Fe(hydr)oxides/montmorillonite(LaFe/MB)was fabricated via a granulation and pyrolysis process for enhanced phosphorus(P)removal from wastewater.Montmorillonite acted as a binder that increased the size of the granulated biochar,while the use of Fe promoted the surface charge and facilitated the dispersion of La,which was responsible for selective phosphate removal.LaFe/MB exhibited rapid phosphate adsorption kinetics and a high maximum adsorption capacity(Langmuir model,52.12 mg P g^(−1)),which were better than those of many existing granulated materials.The desorption and recyclability experiments showed that LaFe/MB could be regenerated,and maintained 76.7%of its initial phosphate adsorption capacity after four adsorption cycles.The high hydraulic endurance strength retention rate of the developed material(91.6%)suggested high practical applicability in actual wastewater.Electro-static attraction,surface precipitation,and inner-sphere complexation via ligand exchange were found to be involved in selective P removal over a wide pH range of 3-9.The thermodynamic parameters were determined,which revealed the feasibility and spontaneity of adsorption.Based on approximate site energy distribution analyses,high distribution frequency contributed to efficient P removal.The research results provide a new insight that LaFe/MB shows great application prospects for advanced phosphate removal from wastewater.
基金The authors are also grateful to the Tianjin Natural Science Foundation （No. 12JCYBJ14000） for providing financial assistance for this investigation.
文摘The adsorption capacities of Y zeolite and La （III）-modified Y zeolite were studied. A series of La（III）- modified Y zeolites with different La/Y zeolite mass ratios were characterized by X-ray diffi＇action, X-ray fluores- cence and Brunauer-Emmett-Teller surface area analysis. Batch experiments were conducted to evaluate the effects of various experimental parameters, such as pH, ionic strength, coexisting anions （CO32 , Cl-, SO24- and NO3-） and temperature, on the phosphate adsorption. The capacity of the La （III）-modified Y zeolite to remove phosphate increased as the La/Y zeolite mass ratio increased and after 4 h, a phosphate removal efficiency of 95% was achieved for a La/Y zeolite mass ratio of 0.10. The equilibrium adsorption isotherm data correlated better to the Langmuir model than the Freundlich model and the data followed a pseudo-second-order kinetic equation.
