Improvement of Methane Production from Corn Stalk for Whole Slurry Anaerobic Co-digestion Under Hydrothermal Wastewater Pretreatment

Corn stalk hydrothermal wastewater(CSHW)was used as a pretreatment for whole-slurry anaerobic co-digestion instead of conventional acid pretreatment.CSHW pretreatment was conducted at 20℃,35℃and 50℃for 3,6 and 9 h,after which all experimental groups were digested at 35℃for 24 days.This pretreatment method efficiently broke the lignocellulose structure of the corn stalk.Different from the volatile fatty acids(VFAs)content,the pH and RS contents were relatively higher than those of the control during the pretreatment process.Furthermore,the highest methane production[185.03 mL•g-1 VS(volatile solid)]was achieved at 55.46%under 35℃in 6 h,which was higher than that of the normal corn stalk anaerobic digestion.The VFAs contents and pH increased compared to CK upon the addition of NaOH to adjust pH,and the RS content also increased slightly due to the degradability of lignocellulose during the whole-slurry anaerobic co-digestion.This work provided a potential method to sustainably treat wastewater and improve fermentation performance.

High-solid Anaerobic Co-digestion of Food Waste and Rice Straw for Biogas Production

Anaerobic co-digestion of food waste（FW） and rice straw（RS） in continuously stirred tank reactor（CSTR） at high organic loading rate（OLR） was investigated. Co-digestion studies of FW and RS with six different mixing ratios were conducted at an initial volatile solid（VS） concentration of more than 3 g VS · L-1. The biogas production, methane contents, degradation efficiency of VS, chemical oxygen demand（COD） and volatile fatty acids（VFAs） were determined to evaluate the stability and performance of the system. The results showed that the co-digestion process had higher system stability and higher volumetric biogas production than mono-digestions. Increase in FW content in the feedstock could increase the methane yield and shorten retention time. The efficiency of co-digestion systems mainly relied on the mixing ratios of FW and RS to some extent. The highest methane yield was 60.55 m L· g V· S-1 · d-1 at a mass ratio（FW/RS） of 3 ： 1, which was 178% and 70% higher than that of mono-digestions of FW and RS, respectively. Consequently, the anaerobic co-digestion of FW and RS could have superior stability and better performance than monodigestions in higher organic loading system.

Study on anaerobic co-digestion with distillery wastewater to improve the dewatering property of the secondary sludge

This paper presents the results obtained for the effluent dewatering properties of anaerobic digestion of secondary sludge （SS） and anaerobic co-digestion of mixture of this sludge with the distillery wastewater （DW） under thermophilic （55±1 ℃）, 5 L of working volume, three parallel lab-scale conditions. Its mixtures were prepared with a DW content of 25%and 50% and the C/N ratios of mixtures are 13.1 and 17.6, respectively. The effluent dewatering properties were evaluated under stable conditions which the biogas yield and the effluent pH were steady. The natural settleability, biogas yield, centrifugal dewatering, centrifugal supernatant turbidity and specific resistance filtration （SRF） were investigated. The results showed that the effluent dewatering properties of anaerobic co-digestion of mixtures between SS and DW were better than that of anaerobic digestion of SS alone. In the anaerobic digestion system with the feed were SS, mixture of SS and a DW content of 25%and 50% in order, the net biogas yield of secondary sludge in ADSA,ADSB and ADSC were 0.42 0.507 and 0.511 m3 biogass/kg.VS.d ; compared with the biogas yield in anaerobic digestion system A （ADSA）, the biogas yield in anaerobic digestion system B （ADSB） and anaerobic digestion system C （ADSC） had been increased by more than 20% respectively; the SRF of three digested sludge are（were） from 6.8×10^13, 1. 1×10^13 to 5.1×10^12 m/Kg, natural settling rates of 12 h are 26, 37 and 56% and that of 24 h are 32%, 45% and 59% respectively; the centrifugal dewatering rate of 3 min at speed of 1000 rpm were 16%, 31% and 51% respectively; the turbidity of centrifugal supernatant were 804, 754 and 678FTU simultaneously.

Characterization of Digestates from Anaerobic Co-Digestion of Manioc Effluent, Human Urine and Cow Dung

This study focused on the characterization of digestates resulting from anaerobic digestion of manioc effluents from attiéké factories. Two types of digestate were characterized, one consisting of manioc effluent + urine and another composed of manioc effluent + urine + cow dung. As a result, these residues of bio-digestion rich in nutrients (NPK) can be used as agricultural fertilizer. Moreover, the determination of some microorganisms and heavy metals digestates allowed to better appreciate its fertilizing quality. These parameters remained in accordance with the quality standards of a digestate prescribed. These results show that digestates from anaerobic co-digestion of manioc effluents, urine and cow dung can be used without fear as an agricultural biofertilizer.

Co-digestion Of Olive Mill Wastewater and Swine Manure Using Up-Flow Anaerobic Sludge Blanket Reactor for Biogas Production

Swine wastewater (SW) and olive mill wastewater (OMW) are two problematic wastes that have become major causes of health and environmental concerns. The main objective of the current work was to evaluate the efficiency of the co-digestion strategy for treatment of SW and OMW mixtures. Mesophilic batch reac-tors fed with mixtures of SW and OMW showed that the two adapted sludges Gadot and Prigat exhibited the best COD removal capacity and biogas production;therefore both were selected to seed up-flow anaerobic sludge blanket (UASB) continuous reactors. During 170 days of operation, both sludges Gadot and Prigat showed high biodegradation potential. The highest COD removal of 85-95% and biogas production of 0.55 L?g-1 COD were obtained at a mixture consisting of 33% OMW and 67% SW. Under these conditions, an organic load of 28,000 mg?L-1 COD was reduced to 1,500-3,500 mg?L-1. These results strongly suggest that co-digestion technology using UASB reactors is a highly reliable and promising technology for wastewater treatment and biogas production.

Bioelectricity from Anaerobic Co-Digestion of Organic Solid Wastes and Sewage Sludge Using Microbial Fuel Cells (MFCs)

Recently microbial fuel cells (MFCs) have been considered as an alternative power generation technique by utilizing organic wastes. In this study, an experiment was carried out to generate bioelectricity from co-digestion of organic waste (kitchen waste) and sewage sludge as a waste management option using microbial fuel cell (MFC) in anaerobic process. A total of five samples with different sludge-waste ratio were used with zinc (Zn) and cupper (Cu) as cell electrodes for the test. The trends of voltage generation were different for each sample in cells such as 350 mV, 263 mV, 416 mV maximum voltage were measured from sample I, II and III respectively. It was observed that the MFC with sewage sludge showed the higher values (around 960 mV) of voltages with time whereas 918 mV obtained with organic waste. Precisely comparing cases with varying the organic waste and sewage sludge ratio helps to find the best bioelectricity generation option. Using MFCs can be appeared as the solution of electricity scarcity along the world as an efficient and eco-friendly manner as well as organic solid waste and sewage sludge management.

Phylogenetic Analysis of Anaerobic Co-Digestion of Animal Manure and Corn Stover Reveals Linkages between Bacterial Communities and Digestion Performance

Over 3 million tons of manures are produced annually in the United States and pose environmental and health risks if not remediated. Anaerobic digestion is an effective method in treating organic wastes to reduce environmental impacts and produce methane as an alternative energy. Previous studies suggested that optimization of feed composition, hydraulic retention time, and other operational conditions can greatly improve total solids removal and increase methane productivity. These environmental factors improve functionality by altering the microbial community structure but explicit details of how the bacterial community shifts are poorly understood. Our investigations were conducted to investigate the relationship between environmental factors, microbial community structure and bioreactor efficiency by using metagenomic analysis of the microbial communities. Our results indicated that the bioreactor with the greatest methane production, digestion efficiency and reduced levels of E. coli/Shigella had a distinctive community structure at the genus level with unique and abundant uncultivated strains of Bacteroidetes. Moreover the same bioreactor was enriched in Aminomonas paucivorans and Clostridia populations that can utilize secondary metabolites produced during cellulose/hemicellulose degradation to generate hydrogen and acetate. Hence specific digestion conditions that enrich for these populations may provide a route to the optimization of co-digestion systems and control the variability in reactor performance.

Bioenergy Production from Anaerobic Co-Digestion of Sewage Sludge and Abattoir Wastes

Energy is the pillar of human economic development. Several energy sources, renewable and non-renewable, have been exploited to assure and sustain the need for sustainable development. However, depletion of non-renewable energy sources forced researchers to search for alternative cost effective and environmental friendly energy sources. Thus, conversion of waste materials into energy has obtained considerable attention. In line with this, the aim of this study is to investigate the improvement of bio-energy production through anaerobic digestion of mixture of wastes from sewage sludge and abattoir sources. The abattoir waste is functioned as a co-substrate. Laboratory scale batch anaerobic co-digestion of the waste is carried out under mesophilic condition for 20 days. Sewage Sludge (SS) alone, and different mix ratios of SS to Abattoir Waste (AW) were analyzed for bioenergy production. Besides, the nutrient values and reduction in volume of the sewage after digestion were determined. The results show that methane productions of 33.8%, 48.3% and 56.9% were obtained for SS alone and for SS:AW mix ratios of 4:1 and 3:2, respectively. The nutrient values of the slurry increased as mix ratio decreased due to the increase in the amount of AW. The obtained results indicate that bio-energy production can be improved through co-digestion of SS using AW as a co-substrate;thus warranting further investigation for the practical application in the energy production.

Effect of goethite on anaerobic co-digestion process of corn straw and algae biomass

1 Introduction Recently the demand for fossil fuel has grown significantly with the rapid development of the Chinese economy.Renewable energy was developed to replace traditional fossil fuels,which would decrease the

Effects of Biowaste-Derived Hydrochar on Anaerobic Digestion:Insights into Hydrochar Characteristics

Hydrochar prepared with four typical biowastes,pine wood,food waste,digested sewage sludge,and Chlorella were applied for the promotion of anaerobic digestion.The gas production and substrate composition were analyzed associated with the hydrochar characteristics.The results suggested that Chlorella hydrochar(C-C)showed the highest cumulative yield of methane(approximately 345 mL)with high total organic carbon(TOC)removal efficiency and low volatile fatty acids(VAFs)concentration.Especially,food waste hydrochar(F-C)showed a poor effect on anaerobic digestion and aroused 1.4–1.6 g/L accumulation of VAFs,in which the toxic components may account for the low efficiency.The C-C and sludge hydrochar(S-C)may develop direct interspecific electron transport(DIET)to facilitate the generation of methane by both surface groups and conductivity of the body structure,unlike pinewood hydrochar(P-C),which mainly depended on the aromatic matrix structure of hydrochar body.This work suggested that C-C can be the best candidate for the facilitation of anaerobic digestion,and N-containing biowaste like algae and lignocellulose like pine wood may establish different DIET pathways based on the physicochemical characteristics of hydrochar.

Density Functional Theory Study of Marine Polybrominated Diphenyl Ethers in Anaerobic Degradation

Polybrominated diphenyl ethers(PBDEs)are a kind of serious pollutants in the ocean.Biodegradation is considered as an economical and safe way for PBDEs removal and reductive debromination dominates the initial pathway of anaerobic degradation.On the basis of experimental study,Octa-BDE 197,Hepta-BDE 183,Hexa-BDE 153,Penta-BDE 99 and Tetra-BDE 47 were selected as the initial degradation objects,and their debromination degradation were studied using density functional theory.The structures were optimized by Gaussian 09 program.Furthermore,the molecular orbitals and charge distribution were analyzed.All C-Br bond dissociation energies at different positions including ortho,meta and para bromine atoms were calculated and the sequence of debromination was obtained.There is a close relationship between molecular structure,charge,molecular orbital and C-Br bond.All PBDEs exhibited similar debromination pathways with preferential removal of meta and para bromines.

Effects of Potassium Ferrate and Low-Temperature Thermal Hydrolysis Co-Pretreatment on the Hydrolysis and Anaerobic Digestion Process of Waste Activated Sludge

This study evaluated the effect of potassium ferrate(PF)and low-temperature thermal hydrolysis co-pretreatment on the promotion of sludge hydrolysis process and the impact on acid production in the subsequent anaerobic digestion process.The analytical investigations showed that co-pretreatment significantly facilitated the hydrolysis process of the sludge and contributed to the accumulation of short-chain fatty acids(SCFAs).The pretreatment conditions under the optimal leaching of organic matter from sludge were hydrothermal temperature of 75℃,hydrothermal treatment time of 12 h,and PF dosage of 0.25 g g^(−1)TSS(total suspended solids),according to the results of orthogonal experiments.By pretreatment under proper conditions,the removal rate of soluble chemical oxygen demand(SCOD)achieved 71.8%at the end of fermentation and the removal rate of total phosphorus(TP)was 69.1%.The maximum yield of SCFAs was 750.3 mg L^(−1),7.45 times greater than that of the blank group.Based on the analysis of the anaerobic digestion mechanism,it was indicated that the co-pretreatment could destroy the floc structure on the sludge surface and improve organic matter dissolving,resulting in more soluble organic substances for the acidification process.Furthermore,microbial community research revealed that the main cause of enhanced SCFAs generation was an increase in acidogenic bacteria and a reduction of methanogenic bacteria.

Co-digestion of Waste Coffee and Cocoa Hulls: Modeling of Biogas Production by the Particle Swarm Method

Energy is a crucial material for the development of our economy.Access to sufficient energy remains a major concern for developing countries,particularly those in sub-Saharan Africa.The major challenge lies in access to clean,environmentally friendly,quality and low-cost energy in different households in our municipalities.To cope with this vast energy gap,many households are dependent on fossil fuels.In Cameroon,the consumption of wood for the supply of energy is increasing by 4%per year.Overall,approximately 80%of households in Cameroon depend on woody biomass as the sole main source of energy supply in Cameroon and demand is growing over time.In view of the climatic variations that our countries,particularly Cameroon,undergo through deforestation,the use of wood as a source of energy is expensive and harmful to the environment,hence the urgency of replacing wood with renewable energy.Biogas is one of the most versatile sources of renewable energy.On an industrial scale,it is important to automate the process control.The main objective of the present work is to model the anaerobic digestion of coffee and cocoa hulls using the particle swarm optimisation method.Pretreatment using the organosolv process was done.This resulted in 48%lignin removal and 22%cellulose increase.For the pretreated biomass,the maximum production rate was 21 NmLCH4 per day with a biomethane yield of 90 NmLCH4/gVS.This represents an enhancement of 117%in biomethane yield.A positive flammability test was recorded after the 10th day of retention time.Moreover,the data collected during anaerobic digestion allowed implementation of a two-phase mathematical model.The thirteen parameters of the model were estimated with particle swarm optimisation method in Matlab.The model was able to simulate the biomethane production kinetics and variation of volatile fatty acid concentration.

Relation between anthropometric variations and resting energy expenditure,VO_(2) max and anaerobic capacity of young,healthy individuals-an update

Anthropometric variations can affect resting energy expenditure,VO_(2) max and anaerobic capacity of young,healthy individuals.Studies have shown that body fat percentage,weight,and height can all affect the three measures.The study aimed to study VO_(2) max and 24-hour thermogenesis measures in predominantly sedentary individuals and weight changes afterwards.VO_(2) max-associated research shows that taller individuals tend to have higher VO_(2) max levels compared to shorter individuals.This could be because taller individuals have a larger lung capacity and greater oxygen delivery to the muscles.Weight can also affect VO_(2) max,as heavier individuals tend to have higher VO_(2) max levels than lighter individuals.Weight is also associated with resting energy expenditure,as heavier individuals tend to have a higher resting energy expenditure than lighter individuals.The purpose of this study was to conduct a systematic review of the existing literature related to resting energy expenditure and metabolic effects of VO_(2) max,and anaerobic capacity in sedentary active adults of anthropometric variations.Several studies have recently examined the possibility of improving aerobic and metabolic functions ensuring cardiorespiratory fitness within the population of anthropometric variations.Everyday physical activity and heredity ability influenced mainly the gold standard measuring tool for cardiorespiratory fitness,VO_(2) max,predicting mortality and morbidity.Weight gain has also been shown to be associated with lower cardiorespiratory fitness,regardless of physical activity levels.The VO_(2) max may have a different effect on energy balance apart from physical activity’s energy expenditure(EE),possibly by affecting the resting metabolic rate(RMR)or triggering a common mechanism associated with diet-induced thermogenesis.Weight change is predicted by sedentary energy expenditure,but directly measured VO_(2) max does not appear to be correlated with weight change.The relationship between resting energy expenditure,VO_(2) max,and anaerobic capacity in individuals is complex.Resting energy expenditure is directly related to anaerobic capacity,as it is an indicator of the body’s ability to work anaerobically.VO_(2) max is also related to anaerobic capacity,as it reflects the body’s maximal aerobic power.However,the strength of this relationship is not known.Overall,both resting energy expenditure and VO_(2) max are important determinants of anaerobic capacity in individuals and are worth considering when evaluating an individual’s anaerobic potential.

Short-term influence of anaerobically-digested and conventional swine manure, and N fertilizer on organic C and N, and available nutrients in two contrasting soils

A three-year (2006-2008) field experiment was conducted at Swift Current and Star City in Saskatchewan to determine the short-term in-fluence of land-applied anaerobically digested swine manure (ADSM), conventionally treated swine manure (CTSM) and N fertilizer on total organic C (TOC), total organic N (TON), light fraction organic C (LFOC), light fraction organic N (LFON) and pH in the 0 - 7.5 and 7.5 - 15 cm soil layers, and ammonium-N, nitrate-N, extractable P, exchangeable K and sulphate-S in the 0 - 15, 15 - 30, 30 - 60, 60 - 90 and 90 - 120 cm soil layers. Treatments included spring and autumn applications of CTSM and ADSM at a 1x rate (10,000 and 7150 L·ha-1, respectively) applied each year, a 3x rate (30,000 and 21,450 L·ha-1, respectively) applied once at the beginning of the experiment, plus a treatment receiving commercial fertilizer (UAN at 60 kg·N·ha-1·yr-1) and a zero-N control. There was no effect of swine manure rate, type and application time on soil pH. Mass of TOC and TON in the 15 cm soil layer increased significantly with swine manure application compared to the control, mainly at the Swift Current site, with greater increases from 3x rate than 1x rate (by 2.21 Mg·C·ha-1 and 0.167 Mg·N·ha-1). Compared to the control, mass of LFOC and LFON in the 15 cm soil layer increased with swine manure application at sites, with greater increases from 3x rate than 1x rate (by 287 kg·C·ha-1 and 26 kg·N·ha-1 at Star City, and by 194 kg·C·ha-1 and 19·kg·N ha-1 at Swift Current). Mass of TOC and TON in soil layer was tended to be greater with ADSM than CTSM, but mass of LFOC and LFON in soil was greater with CTSM than ADSM. Mass of TOC, TON, LFOC and LFON in soil also increased with annual N fertilizer application compared to the control (by 3.2 Mg·C·ha-1 for TOC, 0.195 Mg·N·ha-1 for TON, 708 kg·C·ha-1 for LFOC and 45 kg·N·ha-1 for LFON). In conclusion, our findings suggest that the quantity and quality of organic C and N in soil can be affected by swine manure rate and type, and N fertilization even after three years, most likely by influencing inputs of C and N through crop residue, and improve soil quality.

Relative effects of anaerobically-digested and conventional liquid swine manure, and N fertilizer on crop yield and greenhouse gas emissions

Anaerobic digestion is a promising technology that could provide an option for managing animal waste with reduced greenhouse gas emissions. A three-year (2006-2008) field experiment was conducted at Star City, Saskatchewan, Canada, to compare the effects of land-applied anaerobically digested swine manure (ADSM), conventionally treated swine manure (CTSM) and N fertilizer on grain yield of barley, applied N use efficiency (ANUE, kg·grain·kg-1 of applied N·ha-1), ammonia (NH3) volatilization and nitrous oxide (N2O) emissions. Treatments included spring and autumn applications of CTSM and ADSM at a 1x rate (10,000 and 7150 L·ha-1, respectively) applied every year, a 3x rate (30,000 and 21,450 L·ha-1, respectively) applied once at the beginning of the experiment, plus a treatment receiving commercial fertilizer (UAN at 60 kg·N·ha-1·yr-1) and a zero-N control. There was a significant grain yield response of barley to applied N in all three years. The ANUE of ADSM or CTSM applied once at the 3x rate were lower than annual applications at the 1x rate (grain yield by 595 kg·ha-1 and NFUE by 6 kg·grain·kg-1 of applied N·ha-1). On average, agronomic performance of ADSM was similar to CTSM. The APNU of N fertilizer was greater than the 3x rate but lower than the 1x rate of ADSM or CTSM. Ammonia loss from ADSM was similar to CTSM, except for much higher loss of NH3-N from CTSM at the 3x rate applied in the autumn (8100 g·N·ha-1) compared to the other treatments (1100 - 2600 g·N·ha-1). The percentage of applied N lost as N2O gas was generally higher for treatments receiving CTSM (4.0%) compared to ADSM (1.4%). In conclusion, the findings suggest that ADSM is equal or slightly better than CTSM in terms of agronomic performance, but has lower environmental impact.

Effect of Sludge from Different Sources on Solid Anaerobic Digestion of Corn Straw

[Objective] The aim was to study on effect of sludge from different sources on biogas yield efficiency through anaerobic digestion of corn straw. [Method] The present research studied on daily biogas yield and the accumulated biogas amount through anaerobic digestion of corn straw and sludges from four sources. [Result] The accumulated biogas yields produced from sludges in four sources from high to low were granular sludge, river sediments, concentrated sludge and filtered sludge. The first one proved the highest at 3.73 and 56.29 L/kg VS in daily biogas yield and the accumulated biogas. [Conclusion] The research laid foundation for full utilization of straw, improvement of energy utilization and sustainable development.

Research on the Nature of Thermophilic Anaerobic Ethanol Producer Thermo anaerobacter sp DF3 in Petroleum Reservoirs

[Objective] The aim was to study the physiological and biochemical char- acteristics of Thermoanaerobacter sp DF3 in petroleum reservoirs and optimize the culture plan of producing ethanol from xylose. [Method] DF3, an anaerobic bacillus producing ethanol, was isolated from produced liquid from oil layer of Dagang oil field with anaerobic isolation technique. The phylogenetic position was analyzed by physiological and biochemical identification and phylogeny of 16S rDNA sequence. The metabolites were analyzed by gas chromatograph. [Result] The strain DF3 was a strict anaerobic thermophilic bacterium, which was straight in rod shape,and gram negative. Besides, it was 0.42 μmx（1.60-5.20） iJm in length. The strains can be soli- tary,in pairs or string and apical spore usually produced. Its growth temperature was 45-78 and 65 ℃ was the optimum. Many substances could be used as carbon sources, including glucose, xylose, fructose, ribose, mannose, arabinose, sucrose, galactose, lactose, cellobiose, melizitose, raffinose-, and starch. The similarity between strain DF3 and T. pseudoethanolicus achieved 99.7%. The main product of glucose and xylose fermentation was ethanol. After the culture plan was optimized,the final concentration of ethanol was 2.0 g/L. [Conclusion] It was proved through experiments that the strain DF3 was one of the strains with higher activity to produce ethanol at present and it could produce 2.0 g/L ethanol from xylose metabolization at 65 ℃. It has been demonstrated that DF3 is one of the known strains with high-production to produce ethanol,for example, 2.0 g/L ethano at 65℃. Presently, all the high-yield ethanol can be produced from metabolic xylose strains of metabolic xylose were isolat- ed by foreign countries, therefore, isolation of strain DF3 has provided an excellent original strain for studying ethanol production from lignocellulose in China.

CHARACTERISTICS OF THERMOPHILIC ANAEROBIC ACIDOGENESIS OF STARCH WASTEWATER

Acidogenic dissimilation of synthetic starch wastewater (1 000～10 000 mg COD·L -1 ) was studied in a thermophilic (55 ℃) upflow anaerobic sludge blanket (UASB) reactor.The production of volatile fatty acids (VFA) was proportional to the chemical oxygen demand (COD) loading rate.The yield of VFA was around 0.28 g VFA/g COD over the COD loading rate from 1.25 to 30 g COD·L -1 ·d -1 and the hydraulic retention time from 8.8 h to 24 h.Distribution of organic acids,the contents of propionic and butyric acids in the effluent in particular were also dependent on the COD loading rate.The thermophilic UASB reactor showed a stable performance on hydrolysis and acidogenesis of starch as well as suspended solid removal at short hydraulic retention times and high influent pH(10～11),during the operation of 110 d.

Stable Control of Influence Factor during Two-phase Anaerobic Digestion for Agricultural Organic Waste

Two-phase anaerobic digestion process is influenced by acid control for hydrogen production, reaction temperature, substrate detention time, sludge activity, and granular formation. Al of these technological parameters are directly related to success or failure of the system operation and treatment effect.